Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Volkswagen Golf IV (Mk4 / 1J) / Bora (1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Switch off the headlights, the ignition, and all electrical consumers.
- Open the appropriate fuse box.
- See diagrams below for details about which fuse to check.
- Remove the fuse using the plastic tweezers located on the fuse box cover.
- Check if the fuse is blown – if the thin metal strip inside is broken, the fuse has blown.
- If the fuse is blown, replace the fuse with a new fuse of the same amperage (same color and same imprint) and same overall size.
- Replace the cover.
Notice
- Never replace a fuse with one that has a higher amp rating. Replace a blown fuse only with a fuse of the same amperage (same color and same imprint) and same overall size.
- Never repair fuses.
- Never replace fuses with a metal strip, a paper clip, or a similar object.
- If a newly replaced fuse blows again after a short time, the electrical system should be checked by an authorized Volkswagen dealer or an authorized Volkswagen Service Facility.
Engine Compartment Fuse Box
The fuses are located on the battery.
| № | A | Function/component |
|---|---|---|
| S162 | 50 | Heated pin heating |
| S163 | 50 | Engine management |
| S164 | 40 | Radiator fan |
| S176 | 110 | Interior |
| S177 | 110 | Alternator (90 A) |
| 150 | Alternator (120 A) | |
| S178 | 30 | ABS (pump) |
| S179 | 30 | ABS |
| S180 | 30 | Radiator fan |
Advertisements
Passenger Compartment Fuse Box
The fuse panel is located behind the cover on the driver’s side of the dashboard.
| № | A | Function/component |
|---|---|---|
| 1 | 5 | Z4 - Driver side heated exterior mirror (models without ohne electric window regulator) |
| Z5 - Front passenger side heated exterior mirror (models without ohne electric window regulator) | ||
| Z20 - Left washer jet heater element | ||
| Z21 - Right washer jet heater element | ||
| 2 | 5 | E3 - Hazard warning light switch |
| J1 - Turn signal relay | ||
| M5 - Front left turn signal bulb | ||
| M6 - Rear left turn signal bulb | ||
| M7 - Front right turn signal bulb | ||
| M8 - Rear right turn signal bulb | ||
| J567 - Left gas discharge light control unit | ||
| J568 - gas discharge light control unit with headlight range control right | ||
| 3 | 5 | J5 - Fog light relay |
| E20 - Switches and instruments illumination regulator | ||
| 4 | 5 | X - Number plate lights |
| 5 | 7.5 | E45 - Cruise control system switch |
| E221 - Operating unit in steering wheel | ||
| E227 - Cruise control system button (CCS) SET button | ||
| G65 - High pressure sender (air conditioning system) | ||
| J131 - Heated driver seat control unit | ||
| J132 - Heated front passenger seat control unit | ||
| J245 - Sliding sunroof adjustment control unit (models without central locking) | ||
| J255 - Climatronic | ||
| G266 - Oil level and oil temperature sender | ||
| J293 - Radiator fan control unit, multifunction steering wheel | ||
| J393 - Convenience system (E231 - Exterior mirror heater button), | ||
| J453 - Multifunction steering wheel control unit | ||
| J446 - Parking aid control unit | ||
| J503 - Control unit with display for radio and navigation system | ||
| N147 - 2-way valve for coolant shut-off valve (above F269 - temperature flap position switch) | ||
| V154 - Fresh air/recirculated air flap control motor | ||
| 6 | 5 | Up to April 2001: |
| J379 - Central locking and anti-theft alarm system control unit | ||
| from September 2002: | ||
| 5 | J651 - Shut-off valve relay 1 (engine code BEH) | |
| 7 | 10 | K142 - Selector lever position P/N warning lamp |
| M16 - Left reversing light bulb | ||
| M17 - Right reversing light bulb | ||
| 8 | 5 | J412 - Mobile telephone operating electronics control unit |
| 9 | 5 | E256 - TCS and ESP button |
| G85 -Steering angle sender | ||
| J104 - ABS/ABS control unit with EDL/ ASR/ ESP | ||
| 10 | 15 | up to October 2001: |
| Engine management: Petrol | ||
| 5 | Engine management: Diesel | |
| from November 2001: | ||
| 10 | R - Radio (S-contact) | |
| J285 - Display in dash panel insert | ||
| J503 - Control unit with display for radio and navigation | ||
| 11 | 5 | J285 - Control unit with display in dash panel insert |
| N110 - Selector lever lock solenoid | ||
| 12 | 7.5 | J412 - Mobile telephone operating electronics control unit |
| G273 - Interior monitoring sensor | ||
| G274 - Interior monitoring sender | ||
| T16 - 16-pin connector, (in centre dash panel, self-diagnosis connection) | ||
| W11 - Rear left reading light (models with interior monitor) | ||
| W12 - Rear right reading light (models with interior monitor) | ||
| 13 | 10 | F - Brake light switch |
| M9 - Left brake light bulb (only Golf/Bora) | ||
| J.....-.Engine control units | ||
| J104 - ABS/ABS control unit with EDL/ ASR/ ESP | ||
| M9 - Left brake light bulb (only Golf/Bora) | ||
| M10 - Right brake light bulb (only Golf/Bora) | ||
| M21 - Left brake and tail light bulb (only Golf Variant/Bora Variant) | ||
| M25 - High level brake light bulb | ||
| 14 | 10 | J393 - Convenience system central control unit (models without central lock) |
| J546 - Rear lid remote release control unit | ||
| models without central lock: | ||
| M27 - Left door warning lamp | ||
| M28 - Right door warning lamp | ||
| W - Front interior light | ||
| W3 - Luggage compartment light | ||
| W11 - Rear left reading light | ||
| W12- Rear right reading light | ||
| W14 - Illuminated vanity mirror (front passenger side) | ||
| W18 - Luggage compartment light on left | ||
| W19 - Reading light/driver side | ||
| W20 - Illuminated vanity mirror (driver side) | ||
| 15 | 5 | G85 - Steering angle sender |
| J217 - Automatic gearbox control unit | ||
| J285 - Control unit with display in dash panel insert | ||
| 16 | 10 | J255 - Climatronic |
| J293 - Radiator fan control unit | ||
| 17 | - | - |
| 18 | 10 | J285 - Control unit with display in dash panel insert |
| L2 - Right twin filament bulb (only Bora) | ||
| M32 - Right main beam bulb (only Golf) | ||
| 19 | 10 | L1 - Left twin filament bulb (only Bora) |
| M30 - Left headlight main beam bulb (only Golf) | ||
| 20 | 15 | E102 - Headlight range control regulator |
| J427 - Right headlight starter for gaseous discharge light | ||
| J568 - Gas discharge light control unit with headlight range control right | ||
| L2 - Right twin filament bulb (only Bora) | ||
| M31 - Right headlight dipped beam bulb (only Golf) | ||
| V48 - Left headlight range control motor | ||
| V49 - Right headlight range control motor | ||
| 21 | 15 | L1 - Left twin filament bulb (only Bora), |
| M29 - Left headlight dipped beam bulb (only Golf) | ||
| J426 - Left headlight starter for gaseous discharge light, | ||
| J567 - Gas discharge light control unit with headlight range control left | ||
| 22 | 5 | J285 - Control unit with display in dash panel insert |
| M3 - Right side light bulb | ||
| 23 | 5 | J285 - Control unit with display in dash panel insert |
| M1 - Left side light bulb | ||
| 24 | 20 | E22 - Intermittent wiper switch, windscreen wiper motor |
| J31 - Automatic intermittent wash and wipe relay | ||
| V - Windscreen wiper motor | ||
| V59 - Windscreen and rear window washer pump | ||
| 25 | 20 | E9 - Fresh air blower switch |
| E35 - Air conditioning system switch | ||
| N24 - Fresh air blower series resistor with overheating fuse | ||
| V2 - Fresh air blower | ||
| J293 - Radiator fan control unit | ||
| J255 - Climatronic | ||
| J... -Engine control units | ||
| 26 | 25 | Z1 - Heated rear window |
| 27 | 15 | up to November 2005: |
| V12 - Rear window wiper motor | ||
| from December 2005: | ||
| U1 - Cigarette lighter | ||
| U5 - 12 V socket, on left in luggage compartment | ||
| 28 | 15 | G6 - Fuel pump (pre-supply pump) |
| 29 | 15 | Petrol (not for engine code BDE) |
| 20 | Engine management: Engine code BDE | |
| 10 | Engine management: Diesel | |
| 30 | 20 | J245 - Sliding sunroof adjustment control unit |
| V1 - Sliding sunroof motor | ||
| 31 | 20 | J217 - Automatic gearbox control unit |
| F125 - Multifunction switch | ||
| J542 - Brake servo control unit | ||
| 5 | J492 - Four-wheel drive control unit (4 Motion) | |
| 32 | 10 | Injectors: Petrol |
| 30 | Engine management: Diesel | |
| 33 | 20 | J31 - Automatic intermittent wash and wipe relay |
| V11 - Headlight washer system pump | ||
| 34 | 10 | Engine management |
| 35 | 30 | U10 - Trailer socket |
| up to November 2005: | ||
| U5-12 V socket, on left in luggage compartment | ||
| 36 | 15 | J5 - Fog light relay |
| L22 - Left fog light bulb | ||
| L23 - Right fog light bulb | ||
| L46 - Rear left fog light bulb | ||
| J285 - Control unit with display in dash panel insert | ||
| 37 | 15 | up to October 2001: |
| J285 - Control unit with display in dash panel insert | ||
| 5 | J503 - Control unit with display for radio and navigation system | |
| R - Radio, S-contact | ||
| 10 | from November 2001: | |
| Engine management: Petrol | ||
| Engine management: Diesel | ||
| 38 | 15 | E204 - Tank filler flap remote release switch |
| J379 - Central locking and anti-theft alarm system control unit | ||
| J386 - Driver door control unit | ||
| J387 - Front passenger door control unit | ||
| J388 - Rear left door control unit | ||
| J389 - Rear right door control unit | ||
| J398 - Rear lid remote release relay | ||
| V155- Tank filler flap locking motor | ||
| 39 | 15 | E3 - Hazard warning light switch |
| J1 - Turn signal relay | ||
| J567 - Gas discharge light control unit with headlight range control right | ||
| J568 - Gas discharge light control unit with headlight range control right | ||
| M5 - Front left turn signal bulb | ||
| M6 - Rear left turn signal bulb | ||
| M7 - Front right turn signal bulb | ||
| M8 - Rear right turn signal bulb | ||
| 40 | 20 | H1 - Dual tone horn |
| 41 | 15 | U1-Cigarette lighter (up to November 2005) |
| 42 | 25 | R - Radio |
| R12 - Amplifier | ||
| J503 - Control unit with display for radio and navigation system | ||
| J415 - Navigation system tuner for TV | ||
| J559 - Traffic information control unit | ||
| 43 | 10 | Engine management |
| 44 | 15 | J131 -Heated driver seat control unit |
| J132 -Heated front passenger seat control unit |
Advertisements
Relay Block
It is in the instrument panel on the driver’s side.
| № | A | Fuse/Relay |
|---|---|---|
| A | - | Seat adjustment fuse |
| B | - | Fuses for V192 - Vacuum pump for brakes (from May 2002) |
| C | - | Window regulator fuse, central locking and heated exterior mirror (only models with convenience system and window regulator) |
| 1 | J4 - Dual tone horn relay (53) | |
| 2 | J59 - X-contact relief relay (18) J59 - X-contact relief relay (100) | |
| 3 | Vacant | |
| 4 | J17 - Fuel pump relay (409) J52 - Glow plug relay (103) | |
| V/VI | J31 - Automatic intermittent wash and wipe relay, without headlight washer system (377), -with headlight washer system (389), -with rain sensor (192) | |
| 1 | Vacant | |
| 2 | J398 - Rear lid remote release relay (79) | |
| J546 - Rear lid remote release control unit (407) | ||
| 3 | Vacant | |
| 4 | J5 - Fog light relay (53) | |
| 5 | J453 - Multifunction steering wheel control unit (450) | |
| 6 | J453 - Multifunction steering wheel control unit (450) | |
| 7 | J508 - Brake light suppression relay (206) | |
| 8 | J99 - Heated exterior mirror relay (53) | |
| J541 - Coolant shut-off valve relay (53) | ||
| 9 | J17 - Fuel pump relay, four-wheel-diesel, (53) | |
| 10 | J17 - Fuel pump relay (pre-supply pump) (167) | |
| 11 | J226 - Starter inhibitor and reversing light relay (175) | |
| 12 | J317 - Terminal 30 voltage supply relay (109) | |
| 13 | J151 - Continued coolant circulation relay (53) | |
| D | - | Vacant |
| E | - | Vacant |
| F | 15A | S30 - Rear window wiper single fuse (from December 2005), |
| S144 - Anti-theft alarm system central locking fuse (ATA turn signal) | ||
| G | 15A | S111 - Anti-theft alarm system fuse (ATA horn) |
| 1 | J453 - Multifunction steering wheel control unit (450) | |
| 2 | J453 - Multifunction steering wheel control unit (450) | |
| 3 | J5 - Fog light relay (53) | |
| 4 | Vacant | |
| 5 | J398 - Rear lid remote release relay (79) | |
| J546 - Rear lid remote release control unit (407) | ||
| 6 | Vacant | |
| 7 | J151 - Continued coolant circulation relay (53) | |
| 8 | J317 - Terminal 30 voltage supply relay (109) | |
| 9 | J226 - Starter inhibitor and reversing light relay (175) | |
| 10 | J17 - Fuel pump relay (pre-supply pump) (167) | |
| 11 | J17 - Fuel pump relay, four-wheel-diesel, (53) | |
| 12 | J99 - Heated exterior mirror relay (53) | |
| J541 - Coolant shut-off valve relay (53) | ||
| J193 - Cigarette lighter relay (53) | ||
| 13 | J508 - Brake light suppression relay (206) | |
| D | 15A | S144 - Anti-theft alarm system central locking fuse (ATA turn signal) |
| E | 15A | S111 - Anti-theft alarm system fuse (ATA horn) |
| S30 - Rear window wiper single fuse (from December 2005) | ||
| F | - | Vacant |
| G | - | Vacant |
Advertisements