Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses Volkswagen Fox (5Z) (2004, 2005, 2006, 2007, 2008, 2009).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Switch off the headlights, the ignition, and all electrical consumers.
- Open the appropriate fuse box.
- See diagrams below for details about which fuse to check.
- Remove the fuse using the plastic tweezers located on the fuse box cover.
- Check if the fuse is blown – if the thin metal strip inside is broken, the fuse has blown.
- If the fuse is blown, replace the fuse with a new fuse of the same amperage (same color and same imprint) and the same overall size.
- Replace the cover.
Notice
- Never replace a fuse with one that has a higher amp rating. Replace a blown fuse only with a fuse of the same amperage (same color and same imprint) and the same overall size.
- Never repair fuses.
- Never replace fuses with a metal strip, a paper clip, or a similar object.
- If a newly replaced fuse blows again after a short time, the electrical system should be checked by an authorized Volkswagen dealer or an authorized Volkswagen Service Facility.
Location
- Battery fuse holder -S-
- Fuse holders -SB- and -SC-
- Relay holder fuses
Engine Compartment Fuse Box
The fuses are located on the battery.
| № | A | Function / Component |
|---|---|---|
| 1 | 175 | Alternator -C- |
| Voltage regulator -C1- | ||
| 2 | 110 | Terminal 30 wiring junction -TV2- |
| 3 | 40 | Radiator fan control unit -J293- |
| 4 | 50 | ABS control unit -J104- |
| 5 | 40 | Steering hydraulics pump -V119- |
| ABS control unit -J104- | ||
| Radiator fan control unit -J293- | ||
| Power steering control unit -J500- | ||
| 50 | Steering hydraulics pump -V119- (Until December, 2006) | |
| Power steering control unit -J500- (Until December, 2006) | ||
| 6 | 50 | Glow plug relay -J52- (Only for vehicles with 1.4l Diesel engine) |
| 7 | 25 | ABS control unit -J104- |
| 8 | 30 | Radiator fan thermal switch -F18- (Only for vehicles with 1.2l and 1.4l Diesel engines) |
| Radiator fan 2nd speed relay -J101- (Only for vehicles with 1.4l engine) | ||
| Fresh air blower and radiator fan relay -J209- (Only for vehicles with 1.4l engine) | ||
| Radiator fan control unit -J293- | ||
| 9 | 5 | Radiator fan control unit -J293- |
| 10 | 15 | Onboard supply control unit -J519- (Until December, 2006) |
| Engine control unit -J623- | ||
| 11 | 5 | Air conditioning system control unit -J301- |
| Radiator fan control unit -J293- |
Advertisements
Passenger Compartment Fuse Box
The fuse panel is located behind the cover below the steering wheel.
| № | A | Function / Component |
|---|---|---|
| 1 | 5 | High-pressure sender -G65- |
| Radiator fan control unit -J293- | ||
| Air conditioning system control unit -J301- | ||
| 2 | 5 | Convenience system central control unit -J393- |
| Onboard supply control unit -J519- | ||
| 3 | 5 | Speedometer sender -G22- |
| Power steering control unit -J500- | ||
| Spray jet heater element for windscreen washer -N113- | ||
| 4 | 5 | Driver door exterior handle switch for anti-theft -F121- |
| 5 | 20 | Radio -R- |
| 6 | 20 | Heated rear window control relay -J48- |
| Onboard supply control unit -J519- | ||
| 7 | 10 | Intermittent wiper switch -E22- |
| 8 | 5 | Onboard supply control unit -J519- |
| 9 | - | Empty |
| 10 | 20 | Sliding sunroof adjustment control unit -J245- |
| 11 | 10 | Front right turn signal bulb -M7- |
| Rear right turn signal bulb -M8- | ||
| Right turn signal repeater bulb -M19- | ||
| Convenience system central control unit -J393- | ||
| Onboard supply control unit -J519- | ||
| 12 | 10 | Front left turn signal bulb -M5- |
| Rear left turn signal bulb -M6- | ||
| Left turn signal repeater bulb -M18- | ||
| Convenience system central control unit -J393- | ||
| Onboard supply control unit -J519- | ||
| 13 | - | Empty |
| 14 | 5 | Mirror adjustment switch -E43- |
| Convenience system central control unit -J393- | ||
| 15 | 15 | Heated driver seat regulator -E94- |
| Heated front passenger seat regulator -E95- | ||
| Heated driver seat control unit -J131- | ||
| 16 | 25 | Convenience system central control unit -J393- |
| 17 | 15 | Front and rear fog light switch -E23- |
| Front and rear fog light switch illumination bulb -L40- | ||
| 18 | 10 | Rear window wiper motor -V12- |
| 19 | - | Empty |
| 20 | 5 | Heated exterior mirror on driver side -Z4- |
| Heated exterior mirror on front passenger side -Z5- | ||
| Onboard supply control unit -J519- | ||
| 21 | - | Empty |
| 22 | - | Empty |
| 23 | 5 | Steering angle sender -G85- |
| TCS and ESP button -E256- | ||
| Switches and instruments regulator illumination -L155- | ||
| ABS control unit -J104- | ||
| 24 | 10 | Steering angle sender -G85- |
| ABS control unit -J104- | ||
| 25 | 10 | Front left turn signal bulb -M5- |
| Rear left turn signal bulb -M6- | ||
| Front right turn signal bulb -M7- | ||
| Rear right turn signal bulb -M8- | ||
| Onboard supply control unit -J519- | ||
| 26 | 10 | Ignition coil 1 with output stage -N70- |
| Ignition coil 2 with output stage -N127- | ||
| Ignition coil 3 with output stage -N291- | ||
| Ignition transformer -N152- (Only for vehicles with 1.4l engine) | ||
| Engine control unit -J623- | ||
| 27 | 15 | Air conditioning system control unit -J301- |
| Fitting connector, 16-pole, in diagnosis -T16a- | ||
| 28 | 5 | Dash panel insert -K- |
| Convenience system central control unit -J393- | ||
| 29 | 20 | Automatic intermittent wash and wipe relay -J31- |
| Onboard supply control unit -J519- | ||
| 30 | 5 | Heater element for crankcase breather -N79- (Only for vehicles with 1.4l Petrol engine) |
| Air mass meter -G70- (Only for vehicles with 1.4l Diesel engine) | ||
| Current supply relay -J16- (Only for vehicles with 1.2l engine) | ||
| Engine control unit -J623- | ||
| 31 | 5 | Right tail light bulb -M2- (Until December, 2006) |
| Right side light bulb -M3- | ||
| Right brake and tail light bulb -M22- | ||
| Dash panel insert -K- | ||
| 32 | 5 | Number plate light -X- |
| 33 | 15 | Fuel gauge sender -G- |
| Fuel system pressurisation pump -G6- | ||
| 34 | 10 | Hall sender -G40- (Only for vehicles with 1.2l and 1.4l Petrol engines) |
| Intake manifold flap motor -V157- (Only for vehicles with 1.4l Diesel engine) | ||
| Exhaust gas recirculation valve -N18- (Only for vehicles with 1.4l Diesel engine) | ||
| Charge pressure control solenoid valve -N75- (Only for vehicles with 1.4l Diesel engine) | ||
| Activated charcoal filter solenoid valve 1 -N80- (Only for vehicles with 1.2l and 1.4l Petrol engines) | ||
| 35 | 10 | Front and rear fog light switch -E23- |
| Front and rear fog light switch illumination bulb -L40- | ||
| Left headlight twin filament bulb -L1- | ||
| Dash panel insert -K- | ||
| Left headlight main beam bulb -M30- (Until November, 2006) | ||
| 36 | 10 | Front and rear fog light switch -E23- |
| Front and rear fog light switch illumination bulb -L40- | ||
| Left headlight twin filament bulb -L1- | ||
| Headlight range control regulator -E102- | ||
| Left headlight range control motor -V48- | ||
| Left headlight dipped beam bulb -M29- (Until November, 2006) | ||
| 37 | 10 | Reversing light switch -F4- |
| Left reversing light bulb -M16- | ||
| Right reversing light bulb -M17- | ||
| Onboard supply control unit -J519- | ||
| 38 | 5 | Clutch pedal switch -F36- |
| Brake pedal switch -F47- | ||
| Fuel pump relay -J17- | ||
| Dash panel insert -K- | ||
| 39 | 10 | Luggage compartment light -W3- |
| Onboard supply control unit -J519- | ||
| 40 | 10 | Brake light switch -F- |
| 41 | 10 | Horn or dual tone horn -H1- |
| Onboard supply control unit -J519- | ||
| 42 | 25 | Fresh air blower switch -E9- |
| 43 | 5 | Left side light bulb -M1- |
| Left tail light bulb -M4- (Until December, 2006) | ||
| Left brake and tail light bulb -M21- | ||
| Dash panel insert -K- | ||
| 44 | 10 | Injector, cylinder 1 -N30- |
| Injector, cylinder 2 -N31- | ||
| Injector, cylinder 3 -N32- | ||
| Injector, cylinder 4 -N33- (Only for vehicles with 1.4l Petrol engine) | ||
| Engine control unit -J623- | ||
| 45 | 10 | Lambda probe -G39- |
| Lambda probe after catalytic converter -G130- | ||
| 5 | Clutch pedal switch -F36- | |
| Brake pedal switch -F47- | ||
| Low heat output relay -J359- | ||
| High heat output relay -J360- | ||
| 46 | 10 | Right headlight twin filament bulb -L2- |
| Right headlight main beam bulb -M32- (Until November, 2006) | ||
| 47 | 10 | Right headlight twin filament bulb -L2- |
| Right headlight dipped beam bulb -M31- (Until November, 2006) | ||
| Right headlight range control motor -V49- | ||
| 48 | 20 | Cigarette lighter -U1- |
| Cigarette lighter illumination bulb -L28- |
Advertisements
Relay holder fuse
| № | A | Function / Component |
|---|---|---|
| A | 20 | Specific door window control fuse -S37- |
Heating resistance fuses
| № | A | Function / Component |
|---|---|---|
| A | 40 | Heating resistance Fuse 1 -S276- |
| B | 40 | Heating resistance Fuse 2 -S277- |
| C | 40 | Heating resistance Fuse 3 -S278- |
Advertisements