Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses Volkswagen Crafter (2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Switch off the headlights, the ignition, and all electrical consumers.
- Open the appropriate fuse box.
- See diagrams below for details about which fuse to check.
- Remove the fuse using the plastic tweezers located on the fuse box cover.
- Check if the fuse is blown – if the thin metal strip inside is broken, the fuse has blown.
- If the fuse is blown, replace the fuse with a new fuse of the same amperage (same color and same imprint) and the same overall size.
- Replace the cover.
Notice
- Never replace a fuse with one that has a higher amp rating. Replace a blown fuse only with a fuse of the same amperage (same color and same imprint) and the same overall size.
- Never repair fuses.
- Never replace fuses with a metal strip, a paper clip, or a similar object.
- If a newly replaced fuse blows again after a short time, the electrical system should be checked by an authorized Volkswagen dealer or an authorized Volkswagen Service Facility.
Location
- Terminal 30 voltage supply fuse
- Fuse holder A -SB- Fuses
- Fuse holder B -SC- Fuses
- Fuse holder C -SA- Fuses
- Fuse holder D -SD- Fuses
- Single fuses under the driver seat
Fuse Holder SA
Located on the battery.
| № | A | Function/component |
|---|---|---|
| 1 | 80 | Automatic glow period control unit -J179- |
| 2 | 40 | Radiator fan control unit -J293- (only on models with A/C system) |
| 60 / 80 | radiator fan -V7- (only on models with A/C system) | |
| right radiator fan -V35- (only on models with air conditioning system) | ||
| 3 | 80 | Onboard supply control unit -J519- |
| Engine component current supply relay -J757- | ||
| Fuse holder C -SC- SC2, SC3, SC8 - SC10, SC16 | ||
| 4 | 150 | Auxiliary battery -A1- |
| Tipping mechanism fuse -S186- (before August 2006) | ||
| Fuse 1 (30) -S204- (after July 2006) | ||
| Fuse 2 (30) -S205- (after September 2006) | ||
| Main fuse for multiple equipment configurations -S245- (before August 2006) | ||
| Fuse holder D -SD- SD23 - SD25, SD28 (after September 2006 on models with second battery) | ||
| 5 | 150 | Terminal 15 voltage supply relay -J329- |
| Horn relay -J413- | ||
| Onboard supply control unit -J519- | ||
| Terminal 15 voltage supply relay 2 -J681- | ||
| Start/Stop operation fuse -S349- (after November 2011) | ||
| Fuse holder B -SB- SB1 - SB18 | ||
| Fuse holder C -SC- SC4 - SC7, SC11 - SC15, SC17 - SC25 | ||
| 6 | - | Terminal 15 relief relay -J404- |
| Voltage supply relay 1 -J701- (after November 2013) | ||
| Relief relay 2 for terminal 15 -J817- (only for models in the 3.8 t weight class) | ||
| Relief relay 3 for terminal 15 -J896- (after November 2011) | ||
| Fuse for heated front windscreen -S127- | ||
| Fuse 1 -S131- (after November 2011) | ||
| Fuse 1 (30) -S204- (before June 2006) | ||
| Fuse holder D -SD- SD10 - SD33, SD42 | ||
| 7 | 150 | Auxiliary air heater element -Z35- |
Advertisements
Fuse Holder SB
Located under the dashboard.
| № | A | Function/component |
|---|---|---|
| 1 | 25 | Driver door control unit -J386- |
| 2 | 10 | Diagnostic connection -U31- |
| 3 | 25 | ABS control unit -J104- |
| 4 | 40 | ABS control unit -J104- |
| 5 | - | -Not used- |
| 6 | 7.5 | Evaluation unit for reducing agent level -G698- (from November 2008 to May 2009) |
| Reverse flow valve for reducing agent -N473- (from November 2008 to May 2009) | ||
| Pump for reducing agents -V437- (from November 2008 to May 2009) | ||
| -Not used- (from May 2009) | ||
| Supply unit for reducing agent metering system -GX19- (from November 2013) | ||
| NOx sensor control unit -J583- (from November 2013) | ||
| Relay 1 for voltage supply -J701- (from November 2013) | ||
| NOx sensor 2 control unit -J881- (from November 2013) | ||
| Relay for reducing agent metering system -J963- (from November 2013) | ||
| Pump for reducing agent -V437- (from November 2013) | ||
| 7 | 30 | Headlight washer system pump -V11- |
| 8 | 15 | Rotating light and siren system switch -E11- (from July 2006) |
| Switch for rotating light -E162- (from July 2006) | ||
| Alarm horn -H12- | ||
| Alarm system relay 1 -J460- | ||
| Siren system relay 2 -J645- (From July 2006) | ||
| 9 | 10 | Turn signal relay for roof mounted turn signals -J436- (from May 2007) |
| 10 | 15 | Radio -R- |
| Control unit with display for radio and navigation -J503- | ||
| 11 | 7.5 | Mobile telephone operating electronics control unit -J412- |
| Tachograph control unit -J621- | ||
| 12 | 30 | Heater/heat output switch -E16- |
| Fresh air blower relay -J13- | ||
| Fresh air blower control unit -J126- | ||
| Fresh air blower -V2- | ||
| 13 | 7.5 | Pre-selection clock -E111- |
| Remote control receiver for auxiliary coolant heater -R149- | ||
| 14 | 30 | Operating unit for centre dash panel -J819- |
| 15 | 10 | Load area illumination switch -E481- (to October 2008) |
| Not used | ||
| 16 | 10 | Heater/heat output switch -E16- |
| A/C control module -J301- | ||
| CD changer -R41- | ||
| 17 | 10 | Interior illumination switch -E599- |
| Rear interior lamp switch -E6- (from November 2012 to May 2013) | ||
| 18 | - | Not used |
Fuse Holder SC
Located under the dashboard.
| № | A | Function/component |
|---|---|---|
| 1 | 15 | Treble horn -H2- |
| 2 | 25 | Electronic ignition lock -D9- |
| El. steer. col. lock CU -J764- | ||
| 3 | 10 | Electronic ignition lock -D9- |
| Control unit in dash panel insert -J285- | ||
| Engine control unit -J623- (from May 2012) | ||
| 4 | 5 | Light switch -E1- |
| Operating unit for centre dash panel -J819- | ||
| 5 | 30 | Windscreen wiper motor -V- |
| 6 | 15 | Fuel system pressurisation pump -G6- |
| 7 | 5 | Steering column electronics control unit -J527- |
| 8 | 20 | Engine control unit -J623- |
| 9 | 20 | Fuse 6 on fuse holder B -SB6- (from November 2008 to May 2009) |
| 25 | Fuse holder D -SD- SD34 - SD36 (from May 2009 to November 2013) | |
| 10 | 10 | Air mass meter -G70- (from May 2012) |
| Evaluation unit for reducing agent level -G698- (from May 2012) | ||
| Heater element for crankcase breather -N79- (from May 2012) | ||
| Fuel pressure regulating valve -N276- | ||
| Exhaust gas recirculation cooler changeover valve -N345- (from May 2012) | ||
| Reverse flow valve for reducing agent -N473- (from May 2012) | ||
| Exhaust gas recirculation cooler pump -V400- (from May 2012) | ||
| Pump for reducing agent -V437- (from May 2012) | ||
| 11 | 15 | Relief relay 2 for terminal 15 -J817- (only for models in the 3.8 t weight class) |
| Fuse 1 on fuse holder D -SD1- | ||
| Fuse 2 on fuse holder D -SD2- | ||
| 12 | 10 | Airbag control unit -J234- |
| 13 | 15 | Glove compartment light switch -E26- |
| Cigarette lighter -U1- | ||
| 14 | 5 | Light switch -E1- |
| Control unit in dash panel insert -J285- | ||
| Diagnostic connection -U31- | ||
| 15 | 5 | Heater/heat output switch -E16- |
| Headlight range control regulator -E102- | ||
| Left headlight range control motor -V48- | ||
| Right headlight range control motor -V49- | ||
| 16 | 10 | Main switch for stop/start system -E101- |
| Gearbox neutral position switch -F365- | ||
| Oil level and oil temperature sender -G266- | ||
| Fuel pump relay -J17- | ||
| Continued coolant circulation relay -J151- | ||
| Automatic glow period control unit -J179- | ||
| Terminal 50 voltage supply relay -J682- | ||
| Starter relay 1 -J906- (after November 2013) | ||
| Starter relay 2 -J907- (after November 2013) | ||
| Charge pressure control solenoid valve -N75- | ||
| Coolant circuit valve -N214- | ||
| Exhaust flap valve -N220- (after November 2013) | ||
| Fuel metering valve -N290- | ||
| Exhaust gas recirculation cooler changeover valve -N345- | ||
| Lambda probe heater -Z19- | ||
| 17 | 10 | Airbag control unit -J234- |
| 18 | 7.5 | Brake light switch -F- (from July 2006 to November 2011) |
| Brake pedal switch -F63- (from July 2006 to November 2011) | ||
| Relief relay for terminal 15 -J404- | ||
| Voltage stabiliser -J532- (after November 2011) | ||
| Relay for special constructions, terminal 15 -J821- (after November 2011) | ||
| Relief relay 3 for terminal 15 -J896- (from November 2011) | ||
| 19 | 7.5 | Onboard supply control unit -J519- (Interior light) |
| 20 | 25 | Onboard supply control unit -J519- |
| 21 | 5 | Air mass meter -G70- |
| Engine control unit -J623- | ||
| 22 | 5 | Brake light switch -F- (before June 2006) |
| Brake pedal switch -F63- (before June 2006) | ||
| Lateral acceleration sensor -G200- (from July 2006) | ||
| Longitudinal acceleration sensor -G251- (from July 2006) | ||
| ABS control unit -J104- (From July 2006) | ||
| 23 | 25 | Starter -B- |
| Onboard supply control unit -J519- | ||
| 24 | 10 | -Reserve Kl. 15- |
| Battery regulation control unit -J840- (from May 2013) | ||
| 25 | 30 | -12-V socket -U5- |
Advertisements
Fuse Holder SD
Located under the driver seat.
until May 2011
| № | A | Function/component |
|---|---|---|
| 1 | 5 | Operating unit for window regulator in driver door -E512- |
| Heated rear window relay -J9- (before June 2006) | ||
| Relay 2 for heated rear window -J868- (From July 2006) | ||
| 2 | 30 | Rear left wing door window wiper motor -V92- |
| Rear window wiper motor in right wing door -V93- | ||
| 3 | 5 | Pre-selection clock -E111- |
| Gearbox neutral position switch -F365- | ||
| Display unit control unit -J146- | ||
| Mobile telephone operating electronics control unit -J412- (until May 2011) | ||
| Reversing camera -R189- | ||
| 4 | 7.5 | Working speed control switch -E261- (from July 2006) |
| Power take-off warning switch -F247- (from July 2006) | ||
| Relay for heated rear window -J9- (until June 2006) | ||
| Trailer detector control unit -J345- | ||
| Tachograph control unit -J621- (From July 2006) | ||
| 5 | 5 / 10 | Selector lever -E313- |
| Automated manual gearbox control unit -J514- | ||
| 6 | 5 | Battery regulation control unit -J840- (until May 2013) |
| Heater element for crankcase breather -N79- | ||
| 7 | 10 | Fuel filter heater -Z57- |
| 8 | 5 / 10 | Tilting mechanism button -E223- |
| Relay for special constructions, terminal 15 -J821- | ||
| 6-pin connector -T6ah- (from May 2007) | ||
| 7-pin connector -T7f- (Tail lift coupling point) | ||
| 9 | 15 | Switch for roof ventilator to ventilate loading area -E534- |
| Siren system relay -J408- | ||
| 10 | 25 | -Interface for external use- |
| 11 | 15 | Relay for special constructions, terminal 15 -J821- |
| 12 | 10 | Relay for special constructions, terminal 61 -J822- |
| 13 | 30 / 10 | Evaporator blower control unit -J349- (from May 2007 to May 2011) |
| Turn signal relay for roof mounted turn signals -J436- (To May 2007) | ||
| 14 | 20 | Trailer detector control unit -J345- (Before August 2006) |
| 9-pin connector -T9b- (Preliminary set-up for trailer attachment from September 2006) | ||
| Trailer socket -U10- (From September 2006) | ||
| 15 | 25 | Trailer detector control unit -J345- |
| 16 | 7.5 | Parking aid control unit -J446- |
| Tyre Pressure Monitoring System control unit -J502- | ||
| 17 | 25 | Control unit for programmable special functions -J820- |
| 18 | 25 | Control unit for programmable special functions -J820- |
| 19 | 5 / 25 | Roof electronics control unit -J528- |
| 20 | 7.5 / 10 | Continued coolant circulation relay -J151- |
| Entry and footwell light relay -J348- (from May 2009) | ||
| 21 | 15 / 30 | Heated rear window relay -J9- |
| 22 | 15 | Heated rear window relay -J9- (before June 2006) |
| Relay 2 for heated rear window -J868- | ||
| 23 | 10 / 15 | Load area illumination switch -E481- (after November 2008) |
| 12 V socket 2 -U18- | ||
| 24 | 15 | 12 V socket 4 -U20- |
| 25 | 15 | 12 V socket 3 -U19- |
| 26 | 25 | Auxiliary heater control module -J364- |
| 27 | 20 / 25 | Auxiliary heater control module -J364- |
| Control unit 2 for supplementary heating -J824- | ||
| 28 | 30 / 40 | Evaporator blower control unit -J349- (before April 2007) |
| Gearbox hydraulic pump relay -J510- (from May 2007) | ||
| 29 | 15 | Automated manual gearbox control unit -J514- |
| 30 | 40 | Gearbox hydraulic pump relay -J510- (before April 2007) |
| Battery regulation control unit -J840- | ||
| 31 | 30 / 15 | Rear fresh air blower control unit -J391- |
| Left sliding door control unit -J558- | ||
| Rear fresh air blower -V80- | ||
| 32 | 5 | Battery monitoring control unit -J367- |
| 33 | 15 | Right sliding door control unit -J731- |
| 34 | 15 | Control unit for reducing-agent heater -J891- (from April 2009) |
| 35 | 15 / 3 | Control unit for reducing-agent heater -J891- (from April 2009) |
| 36 | - | Not used |
after May 2011
| № | A | Function/component |
|---|---|---|
| 1 | 5 | Operating unit for window regulator in driver door -E512- |
| Heated rear window relay 2 -J868- | ||
| 2 | 30 | Rear left wing door window wiper motor -V92- |
| Rear window wiper motor in right wing door -V93- | ||
| 3 | 5 | Pre-selection clock -E111- |
| Gearbox neutral position switch -F365- | ||
| Display unit -J145- | ||
| Reversing camera -R189- | ||
| 4 | 7.5 | Working speed control switch -E261- |
| Power take-off warning switch -F247- | ||
| Trailer detector control unit -J345- | ||
| Tachograph control unit -J621- | ||
| 5 | 5 / 10 | Selector lever -E313- |
| Automated manual gearbox control unit -J514- | ||
| Bonnet contact switch -F266- (from November 2011) | ||
| 6 | 5 / 10 | Heater element for crankcase breather -N79- |
| Battery regulation control unit -J840- (from May 2011 to May 2013) | ||
| 7 | 10 | Fuel filter heater -Z57- |
| 8 | 5 / 10 | Tilting mechanism button -E223- |
| Parking aid control unit -J446- (after May 2013) | ||
| Relay for special constructions, terminal 15 -J821- (until November 2011) | ||
| 6-pin connector -T6ah- | ||
| 7-pin connector -T7f- (Tail lift coupling point) | ||
| 9 | 15 | Switch for roof ventilator to ventilate loading area -E534- (before November 2011) |
| Siren system relay -J408- (before November 2011) | ||
| -nicht belegt (ab November 2011)- | ||
| 10 | 25 | -Schnittstelle für externe Nutzung- |
| 11 | 15 | Relay for special constructions, terminal 15 -J821- |
| 12 | 10 | Relay for special constructions, terminal 61 -J822- |
| 13 | - | Not used |
| 14 | 20 | 9-pin connector -T9b- (Preliminary set-up for trailer attachment) |
| Trailer socket -U10- | ||
| 15 | 25 | Trailer detector control unit -J345- |
| 16 | 7.5 | Parking aid control unit -J446- |
| Tyre Pressure Monitoring System control unit -J502- | ||
| 17 | 25 | Control unit for programmable special functions -J820- |
| 18 | 25 | Control unit for programmable special functions -J820- |
| 19 | 5 / 25 | Roof electronics control unit -J528- |
| 20 | 7.5 / 10 | Continued coolant circulation relay -J151- |
| Entry and footwell light relay -J348- | ||
| 21 | 30 | Heated rear window relay -J9- |
| 22 | 15 | Heated rear window relay 2 -J868- |
| 23 | 10 / 15 | Load area illumination switch -E481- |
| 12 V socket 2 -U18- | ||
| 24 | 15 | 12 V socket 4 -U20- |
| 25 | 15 | 12 V socket 3 -U19- |
| 26 | 25 | Auxiliary heater control module -J364- |
| 27 | 20 / 25 | Auxiliary heater control module -J364- |
| Control unit 2 for supplementary heating -J824- | ||
| 28 | 40 / 30 | Gearbox hydraulic pump relay -J510- |
| Starter relay 1 -J906- | ||
| 29 | 15 | Automated manual gearbox control unit -J514- |
| 30 | 5 | Battery regulation control unit -J840- |
| 31 | 30 / 15 | Left sliding door control unit -J558- (from May 2012) |
| Rear fresh air blower control unit -J391- | ||
| Rear fresh air blower -V80- | ||
| 32 | 5 | Battery monitoring control unit -J367- |
| 33 | 15/30/7,5 | Not used |
| Right sliding door control unit -J731- (from May 2012) | ||
| Lockout relay 1 for transfer box -J1010- (from January 2012) | ||
| Lockout relay 2 for transfer box -J1011- (from January 2012) | ||
| Lockout relay 3 for transfer box -J1012- (from January 2012) | ||
| Compressed air compressor -V534 - (From January 2012) | ||
| 34 | 15 / 7.5 | Control unit for reducing-agent heater -J891- |
| Transfer box differential lock switch -F99- (from January 2012) | ||
| Rear axle drive unit differential lock switch -F100- (from January 2012) | ||
| Front axle drive unit differential lock switch -F101- (From January 2012) | ||
| 35 | 15 / 3 | Control unit for reducing-agent heater -J891- |
| Compressed air compressor protection control unit -J1013- (From January 2012) | ||
| 36 | 5 | Not used (to January 2012) |
| Compressed air compressor pressure switch -F503- (From January 2012) | ||
| 37 | - | Not used |
| 38 | - | Not used |
| 39 | 7.5 / 15 | Switch for roof ventilator to ventilate loading area -E534- (after November 2011) |
| Siren system relay -J408- (from November 2011) | ||
| 40 | - | Not used |
| 41 | - | Not used |
| 42 | 30 | Evaporator blower control unit -J349- |
| 43 | - | Not used |
| 44 | - | Not used |
| 45 | - | Not used |
| 46 | - | Not used |
| 47 | - | Not used |
| 48 | - | Not used |
| 49 | - | Not used |
| 50 | - | Not used |
| 51 | - | Not used |
| 52 | - | Not used |
| 53 | - | Not used |
| 54 | - | Not used |
| 55 | - | Not used |
| 56 | - | Not used |
Advertisements
Terminal 30 voltage supply fuse
In the line section between the alternator and the starter.
Fuses for special vehicles (after May 2013)
Under driver seat.
- A – Tipping mechanism fuse -S186- Up to August 2006
- A – Fuse 1 (30) -S204- (Retarder/Second battery)
- A – Fuse 2 (30) -S205- after September 2006 (Tail lift/three-way tipper/Retarder)
- A – Main fuse for multiple equipment configurations -S245- Up to August 2006
- A – Fuse 1 (30) -S204- (Retarder/Second battery)
- A – Fuse 2 (30) -S205- (Tail lift/three-way tipper/Retarder)
- A – Daytime running lights fuse -S220- (Achleitner only)
- B – Fuse 1 -S131- (Compressed air compressor)
Advertisements