Toyota RAV4 (XA40) (2013-2018) Fuse Diagram

Advertisements

Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota RAV4 (XA40) (2012, 2013, 2014, 2015, 2016, 2017, 2018).

Toyota RAV4 (XA40) (2013-2015)

Toyota RAV4 (XA40) (2015-2018)

Checking and Replacing Fuses

The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.

  • Turn the engine switch off (with a smart key system – turn the “ENGINE START STOP” switch off) and turn off all electrical accessories.
  • Open the fuse box cover.
  • See diagrams below for details about which fuse to check.
  • Remove the fuse.
  • Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
  • Replace the blown fuse with a new fuse of an appropriate amperage rating.

Notice

  • Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
  • Always use a genuine Toyota fuse or equivalent.
  • Do not modify the fuses or fuse boxes.
  • If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.

Passenger Compartment

Left-hand drive

Passenger Compartment (LHD)

Right-hand drive

Passenger Compartment (RHD)

  1. LHD: Interior Light Relay (DOME CUT)
  2. Headlight Leveling ECU
  3. Fuse Box / Main Body ECU
  4. Steering Lock Actuator
  5. Power Steering ECU
  6. Relay Box
  7. Navigation ECU
  8. 4WD ECU
  9. Clearance Warning ECU
  10. Driving Support ECU
  11. Network Gateway ECU
  12. Windshield Wiper Relay
  13. Engine Stop and Start ECU
  14. Shift Lock Control ECU (Floor Shift Lever Sub-Assembly)
  15. Airbag Sensor Assembly
  16. Junction Connector
  17. A/C Amplifier
  18. Junction Connector
  19. RHD: Double Lock Door Control Relay

 

Passenger Compartment Fuse Box Diagram

The fuse panel is located under the left side of the dashboard.

Left-hand drive

Passenger Compartment Fuse Box Location (LHD)

Additional fuses are behind the trim panel.

Passenger Compartment Fuse Box Location (LHD)

Right-hand drive

Passenger Compartment Fuse Box Location (RHD)

Advertisements

 

Passenger Compartment Fuse Box Diagram

Passenger Compartment Fuse Box Diagram

№FuseACircuit
1-- -
2STOP7.5Stop lights
3S/ROOF10Moon roof
4AM15"IG1 №1", "IG1 №2", "IG1 №3", "ACC" fuses
5OBD7.5On-board diagnosis system
6D/L №220Before Oct. 2015: Power door lock system (side doors), main body ECU
7FOG RR7.5Rear fog light
8D/L BACK10Power door lock system (back door)
9P/OUTLET №115Power outlets
10DOOR D20Driver’s door power window
11DOOR R/R20Right-hand rear door power window
12DOOR R/L20Left-hand rear door power window
13WIP RR15Rear window wiper
14WSH15Windshield washer, rear window washer
15GAUGE7.5Back-up lights, Blind Spot Monitor system, inside rear view mirror
16WIP FR25Windshield wipers
17SFT LOCK-ACC5Shift lock system ECU
18P/OUTLET №215Power outlets
19ACC7.5Power outlets, audio system, outside rear view mirrors, main body ECU, clock, electric current sensor
20PANEL7.5VSC OFF switch, instrument cluster (indicators and warning lights), BSM main switch, all-wheel drive lock switch, windshield wiper de-icer switch, multiport fuel injection system/sequential multiport fuel injection system, intuitive parking assist ECU, seat heater switches, power outlets, power back door switches, air conditioning system switches, rear window defogger switch, audio system, cup holder light, steering switches, driver module switch
21TAIL10Parking lights, tail lights, license plate lights, side marker lights, fog lights
22D/L №220From Oct. 2015: Power door lock system (side doors), main body ECU
23EPS-IG5Electric power steering
24ECU-IG №110Dynamic Torque Control AWD system ECU, steering sensor, instrument cluster (indicators and warning lights), shift control switch
25ECU-IG №25Main body ECU, wireless remote control, shift lock system ECU, smart key system, moon roof ECU, audio system, power back door ECU, tire pressure warning system, LDA system, Blind Spot Monitor system
26HTR-IG7.5Air conditioning system ECU, air conditioning system switches, rear window defogger switch
27S-HTR LH10Before Oct. 2015: Left-hand seat heater
S/HTR F/L10From Oct. 2015: Left-hand seat heater
28S-HTR RH10Before Oct. 2015: Right-hand seat heater
S/HTR F/R10From Oct. 2015: Right-hand seat heater
29IGN7.5Fuel pump, multiport fuel injection system/sequential multiport fuel injection system, stop lights, steering lock system ECU
30A/B7.5SRS airbag system ECU, front passenger occupant classification system ECU
31METER5Gauges and meters
32ECU-IG №37.5Alternator, anti-lock brake system/vehicle stability control ECU, windshield wiper de-icer switch, stop lights, "FAN №1", "FAN №2", "FAN №3", "HTR", "PTC", "DEF", "DEICER" fuses
1P/SEAT F/L30Left-hand power seat
2PBD30Power back door
3P/SEAT F/R30Right-hand power seat
4P/W-MAIN30Front power windows, power window main switch

Relay Box

Relay Box

№Relay
R1LHD: Theft deterrent (S-HORN)
RHD: Interior lights (DOME CUT)
R2Rear fog light (FOG RR)

Advertisements

Engine Compartment

Engine Compartment

  1. Fuse Box
  2. ECM
  3. Glow Plug Controller
  4. Generator Control ECU
  5. From Oct. 2015: Cooling Fan ECU
  6. Headlight Cleaner Control Relay
  7. Transmission Control ECU
  8. Relay Box
  9. Injector Drive
  10. Continuously Variable Valve Lift Controller
  11. Brake Actuator
  12. Glow Plug Relay
  13. From Oct. 2015: Fuel Heater Relay

 

Engine Compartment Fuse Box

Push the tabs in and lift the cover off.

Engine Compartment Fuse Box Location

Diagram (Type 1)

Engine Compartment Fuse Box Diagram (Type 1)

№FuseACircuit
1EFI-MAIN №1202AR-FE: Multiport fuel injection system/sequential multiport fuel injection system, "EFI №1", "EFI №2" fuses
253ZR-FE, 3ZR-FAE: Multiport fuel injection system/sequential multiport fuel injection system, "EFI №1", "EFI №2" fuses
30Diesel: Multiport fuel injection system/sequential multiport fuel injection system, automatic transmission ECU, "EFI №3" fuses
2TOWING-B30Trailer
3STRG LOCK10Steering lock ECU
4ECU-B №210Air conditioning system ECU, gauges and meters, smart entry & start system, overhead module
5TURN&HAZ10Gauges and meters
6EFI-MAIN №2202AR-FE: Air flow sensor, fuel pump, rear O2 sensor
Diesel: "EFI №1", "EFI №2" fuses
153ZR-FE, 3ZR-FAE: Multiport fuel injection system/sequential multiport fuel injection system
7.5From Oct. 2015:
   2WW: Multiport fuel injection system/sequential multiport fuel injection system
7ST №220Before Oct. 2015: Starting system
D/L №130From Oct. 2015: Back door opener, combination meter, double locking, entry & start system, front fog light, front wiper and washer, headlight, immobiliser system, interior light, power back door, power window, rear fog light, seat belt warning, SRS, starting, steering lock, theft deterrent, tire pressure warning system, wireless door lock control
8ST30Starting system
ST №130Before Oct. 2015:
   3ZR-FAE From Apr. 2015: Starting system
9AMP30Before Oct. 2015: Audio system
AMP/BBC №330From Oct. 2015: Audio system
10ETCS10Multiport fuel injection system/sequential multiport fuel injection system
FUEL PMP30From Oct. 2015:
   2WW: Fuel pump
11S-HORN10Before Oct. 2015: Theft deterrent
BBC №230From Oct. 2015:
   without Telematics System: Stop & Start system ECU
MAYDAY7.5From Oct. 2015:
   with Telematics System: Mayday system
12IG215Multiport fuel injection system/sequential multiport fuel injection system, "METER", "IGN", "A/B" fuses
13AM27.5Starting system, "IG2" fuse
14ALT-S/ICS7.5Electric current sensor, alternator
15HORN10Horn
16EDU25Diesel: Multiport fuel injection system/sequential multiport fuel injection system
ST №220From Oct. 2015:
   3ZR-FAE: Starting system
S-HORN10From Oct. 2015:
   with Security Horn: Theft deterrent
17D/C CUT30"DOME", "ECU-B №1", "RADIO" fuses
18WIPER-S5Windshield wiper switch, electric current sensor, multiport fuel injection system/sequential multiport fuel injection system
19EFI №1103ZR-FE: Air flow meter, purge control VSV, ACIS VSV, rear O2 sensor, multiport fuel injection system/sequential multiport fuel injection system
3ZR-FAE: Multiport fuel injection system/sequential multiport fuel injection system
2AR-FE: Air flow meter, purge control VSV, ACIS VSV
1AD-FTV: Oil switching valve, EDU, ADD FUEL VLV, EGR cooler bypass VSV, clutch upper switch, Stop & Start system ECU, glow control unit, air flow meter
2AD-FTV, 2AD-FHV: EDU, ADD FUEL VLV, EGR cooler bypass VSV, clutch upper switch, air flow meter, VNT E-VRV
7.5From Oct. 2015:
   2WW: Multiport fuel injection system/sequential multiport fuel injection system
20EFI №2103ZR-FAE: Air flow sensor, Air flow meter, purge control VSV, ACIS VSV, rear O2 sensor, Stop & Start system ECU
2AR-FE: Multiport fuel injection system/sequential multiport fuel injection system, key off pump module
3ZR-FE, 2AD-FTV, 2AD-FHV: Air flow sensor
15From Oct. 2015:
   2WW: Multiport fuel injection system/sequential multiport fuel injection system
21H-LP LH-HI10Left-hand headlight (high beam), headlight high beam indicator
22H-LP RH-HI10Right-hand headlight (high beam)
23EFI №37.5Multiport fuel injection system/sequential multiport fuel injection system, automatic transmission ECU
20From Oct. 2015:
   2WW: Multiport fuel injection system/sequential multiport fuel injection system
24-- -
25-- -
26RADIO20Audio system
27ECU-B №110Wireless remote control, steering sensor, main body ECU, door lock ECU, clock, power back door ECU, tire pressure warning system
28DOME10Engine switch light, interior lights, vanity lights, luggage compartment light, personal lights
29H-LP LH-LO10Before Oct. 2015:
   Halogen: Left-hand headlight (low beam), manual headlight leveling dial, headlight leveling system
From Oct. 2015: Left-hand headlight (low beam), manual headlight leveling dial, headlight leveling system
15Before Oct. 2015:
   HID: Left-hand headlight (low beam), manual headlight leveling dial, headlight leveling system
30H-LP RH-LO10Before Oct. 2015:
   Halogen: Right-hand headlight (low beam)
From Oct. 2015: Right-hand headlight (low beam)
15Before Oct. 2015:
   HID: Right-hand headlight (low beam)
31-- -
32-- -
33-- -
34-- -
35FUEL HTR50From Oct. 2015:
   2WW: Fuel heater
36BBC40Stop & Start system ECU
37VLVMATIC30VALVEMATIC system
EFI MAIN50From Oct. 2015:
   2WW: ABS, auto LSDcruise control, downhill assist control, dynamic radar cruise control, engine control, hill-start assist control, panoramic view monitor system, stop & start system, TRC, VSC
38ABS №230Vehicle stability control, anti-lock brake system
39ABS №250Vehicle stability control, anti-lock brake system
40H-LP-MAIN50"H-LP RH-LO", "H-LP LH-LO", "H-LP RH-HI", "H-LP LH-HI" fuses
41GLOW80Glow control unit
42EPS80Electric power steering
43ALT120Before Oct. 2015:
   Gasoline: "STOP", "S/ROOF", "AM1", "OBD", "D/L №2", "FOG RR", "D/L BACK", "P/OUTLET №1", "DOOR D", "DOOR R/R", "DOOR R/L", "WIP RR", "WSH", "GAUGE", "WIP FR", "SFT LOCK-ACC", "P/OUTLET №2", "ACC", "PANEL", "TAIL", "D/L №2", "EPS-IG", "ECU-IG №1", "ECU-IG №2", "HTR-IG", "S-HTR LH", "S-HTR RH", "IGN", "A/B", "METER", "ECU-IG №3" fuses
140Before Oct. 2015:
   Diesel, 3ZR-FAE From Apr. 2015: ↓
From Oct. 2015:
   Except 2WW: "ABS №1", "ABS №2", "RDI FAN", "FAN №1", "S/HTR R/L", "DEICER", "FOG FR", "S/HTR R/R", "CDS FAN", "FAN №2", "HTR", "STV HTR", "TOWING-ALT", "HWD №1", "HWD №2", "H-LP CLN", "DRL", "PTC HTR №1", "PTC HTR №2", "PTC HTR №3", "DEF", "NOISE FILTER", "STOP", "S/ROOF", "AM1", "OBD", "D/L №2", "FOG RR", "D/L BACK", "P/OUTLET №1", "DOOR D", "DOOR R/R", "DOOR R/L", "WIP RR", "WSH", "GAUGE", "WIP FR", "SFT LOCK-ACC", "P/OUTLET №2", "ACC", "PANEL", "TAIL", "D/L №2", "EPS-IG", "ECU-IG №1", "ECU-IG №2", "HTR-IG", "S-HTR LH", "S-HTR RH", "IGN", "A/B", "METER", "ECU-IG №3" fuses
Relay
R1Engine control unit (EFI-MAIN №2)
R2Ignition (IG2)
R3Diesel: Engine control unit (EDU)
Gasoline: Fuel pump (C/OPN)
2WW: Fuel pump (FUEL PMP)
R4Before Oct. 2015: Headlight (H-LP)
From Oct. 2015: Dimmer
R5Engine control unit (EFI-MAIN №1)
R6Before Oct. 2015: Dimmer
From Oct. 2015:
   Except 2AR-FE: Headlight (H-LP)
   2AR-FE: Headlight / daytime running light (H-LP/DRL)

Advertisements

 

Diagram (Type 2)

Engine Compartment Fuse Box Diagram (Type 2)

№FuseACircuit
1RADIO20Audio system
2ECU-B №110Wireless remote control, steering sensor, main body ECU, clock, power back door ECU, tire pressure warning system, driving position memory ECU
3DOME10Engine switch light, interior lights, vanity lights, luggage compartment light, personal lights
4-- -
5DEICER20Windshield wiper de-icer
6-- -
7FOG FR7.5Fog lights, fog light indicator
8AMP30Audio system
9ST30Starting system
10EFI-MAIN №120Multiport fuel injection system/sequential multiport fuel injection system, "EFI №1", "EFI №2" fuses
11-- -
12IG215Multiport fuel injection system/sequential multiport fuel injection system, "METER", "IGN", "A/B" fuses
13TURN&HAZ10Gauges and meters
14AM27.5Starting system, "IG2" fuse
15ECU-B №210Air conditioning system ECU, gauges and meters, front passenger occupant classification system ECU, smart key system
16STRG LOCK10Steering lock ECU
17D/C CUT30"DOME", "ECU-B №1", "RADIO" fuses
18HORN10Horn
19ETCS10Multiport fuel injection system/sequential multiport fuel injection system
20EFI-MAIN №220Air flow sensor, fuel pump, rear O2 sensor
21ALT-S/ICS7.5Electric current sensor
22MIR HTR10Outside rear view mirror defoggers, multiport fuel injection system/sequential multiport fuel injection system
23EFI №110Air flow meter, purge control VSV, ACIS VSV
24EFI №210Multiport fuel injection system/sequential multiport fuel injection system, key off pump module
25H-LP LH-HI10Left-hand headlight (high beam), headlight high beam indicator
26H-LP RH-HI10Right-hand headlight (high beam)
27-- -
28H-LP LH-LO10Left-hand headlight (low beam)
29H-LP RH-LO10Right-hand headlight (low beam)
30CDS FAN30Electric cooling fans
31HTR50Air conditioning system
32H-LP-MAIN50Daytime running lights, "H-LP RH-LO", "H-LP LH-LO", "H-LP RH-HI", "H-LP LH-HI" fuses
33PTC HTR №230PTC heater
34PTC HTR №130PTC heater
35DEF30Rear window defogger, "MIR HTR" fuse
36ABS №230Vehicle stability control
37RDI FAN30Electric cooling fans
38ABS №150Vehicle stability control
39EPS80Electric power steering
40ALT120"ABS №1", "ABS №2", "PTC HTR №1", "PTC HTR №2", "DEICER", "HTR", "RDI FAN", "CDS FAN", "FOG FR", "DEF" fuses
41WIPER-S5Windshield wiper switch, electric current sensor
42SPARE10Spare fuse
43SPARE20Spare fuse
44SPARE30Spare fuse
Relay
R1Engine control unit (EFI-MAIN №2)
R2Ignition (IG2)
R3Fuel pump (C/OPN)
R4Short Pin
R5Headlight (H-LP)
R6Engine control unit (EFI-MAIN №1)
R7Rear window defogger (DEF)
M1Daytime running lights module

Additional Relay Box

Type 1

Additional Relay Box Location

Additional Relay Box (Type 1)

Advertisements

 

№FuseACircuit
1DRL5Daytime running lights
2TOWING-ALT30Trailer
3FOG FR7.5Front fog lights, front fog light indicator
4NOISE FILTER10Noise filter
5STV HTR25Power heater
6S/HTR R/R10From Oct. 2015: Seat heater (rear passenger's seat)
7DEICER20Windshield wiper de-icer
S/HTR R/L10From Oct. 2015: Seat heater (rear passenger's seat)
8CDS FAN №25From Oct. 2015:
   Diesel: Electric cooling fans
9-- -
10RDI FAN №25From Oct. 2015:
   Diesel: Electric cooling fans
11-- -
12-- -
13MIR HTR10Outside rear view mirror defoggers, multiport fuel injection system/sequential multiport fuel injection system
14-- -
15-- -
16-- -
17PTC HTR №150600W, 840W: PTC heater
30330W: PTC heater
18PTC HTR №250840W: PTC heater
30330W: PTC heater
19PTC HTR №350840W: PTC heater
30330W: PTC heater
20CDS FAN30Electric cooling fans
40From Oct. 2015:
   2WW: Electric cooling fans
FAN №250From Oct. 2015 Diesel:
   with Trailer Towing: Electric cooling fans
21RDI FAN30Electric cooling fans
40From Oct. 2015:
   2WW: Electric cooling fans
FAN №150From Oct. 2015 Diesel:
   with Trailer Towing: Electric cooling fans
22HTR50Air conditioning system
23DEF30Rear window defogger, "MIR HTR" fuse
24HWD №250Heated windshield defroster
25H-LP CLN30Headlight cleaner
26HWD №150Heated windshield defroster
Relay
R1Electric cooling fan (FAN №2)
R2Front fog lights (FOG FR)
R3Horn
R4Heater (HTR)
R5Daytime running lights (DRL)
R6Electric cooling fan (FAN №3)
R7Electric cooling fan (FAN №1)
R8Rear window defogger (DEF)
R9PTC heater (PTC HTR №1)
R10PTC heater (PTC HTR №2)
Heated windshield defroster (HWD №1)
R11PTC heater (PTC HTR №3)
Heated windshield defroster (HWD №2)
R12Stop lights (STOP LP)
R13Starter (ST), (ST №1)
R14Heated windshield defroster (DEICER)
Heated steering wheel (STRG HTR)
Heated windshield defroster / heated steering wheel (DEICER/STRG HTR)
R15From Oct. 2015:
   with Trailer towing + Diesel: Electric cooling fans (FAN №1)
   Rear seat heater (S/HTR R/L)
R16From Oct. 2015: Rear seat heater (S/HTR R/R)
R17From Oct. 2015:
   with Trailer towing + Diesel: Electric cooling fans (FAN №2)
   Washer nozzle heater (WSH NZL HTR)
R18Starter (ST №2)
R19330W: PTC heater (PTC HTR №1)
600W: PTC heater (PTC HTR №3)
R20PTC heater (PTC HTR №2)
Type 2

Additional Relay Box (type 2)

№Relay
R1Front fog lights (FOG FR)
R2Air conditioner compressor clutch (MG/CLT)
R3PTC heater (PTC HTR №2)
R4 -
R5Horn
R6Electric cooling fan (FAN №2)
R7PTC heater (PTC HTR №1)
R8Electric cooling fan (FAN №3)
R9Starter (ST)
R10Electric cooling fan (FAN №1)

 

Advertisements

Advertisements