Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota RAV4 (XA20) (2000, 2001, 2002, 2003, 2004, 2005).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Turn the engine switch off and turn off all electrical accessories.
- Open the fuse box cover.
- See diagrams below for details about which fuse to check.
- Remove the fuse.
- Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
- Replace the blown fuse with a new fuse of an appropriate amperage rating.
Notice
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
- Always use a genuine Toyota fuse or equivalent.
- Do not modify the fuses or fuse boxes.
- If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.
Passenger Compartment
Left-hand drive
Right-hand drive
- Fuse Box
- LHD: Taillight Relay
- Transponder Key Amplifier
- A/C Amplifier
- Engine and ECT ECU (A/T)
Engine ECU (M/T) - Passenger Side Junction Block
- Passenger Side Junction Block ECU
- Center Airbag Sensor Assembly
- Shift Lock ECU
- Turn Signal Flasher Relay
- Moon Roof Control SW and Relay
- Rear Wiper Motor and Relay
- Door Control Receiver
Passenger Compartment Fuse Box Diagram
The fuse panel is located behind the coin tray on the driver’s side of the dashboard.
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | STOP | 10 | Stop lights, high−mounted stoplight, anti−lock brake system, shift lock control system, multiport fuel injection system/sequential multiport fuel injection system, cruise control system |
| 2 | CIG | 15 | Cigarette lighter |
| 3 | POWER OUTLET | 15 | Power outlets |
| 4 | S-HTR | 10 | Seat heater |
| 5 | PANEL | 7.5 | Instrument panel light, gauges and meters, front fog lights, instrument panel light control, outside rear view mirror defoggers, air conditioning system |
| 6 | FR FOG | 15 | Front fog lights |
| 7 | HORN | 10 | Horn |
| 8 | TAIL | 7.5 | Tail lights, license plate lights, instrument cluster lights |
| 9 | TAIL&PANEL | 15 | "PANEL” and "TAIL” fuses |
| 10 | ACC | 7.5 | Car audio system, shift lock control system, clock, power rear view mirrors |
| 11 | DEF | 20 | Rear window defogger |
| 12 | GAUGE | 10 | Back−up lights, electric cooling fans, air conditioning system, automatic transmission indicator lights, charging system |
| 13 | OBD | 7.5 | On−board diagnosis system |
| 14 | IG2 | 10 | Discharge warning light, multiport fuel injection system/sequential multiport fuel injection system, starting system, SRS airbag system, gauges and meters |
| 15 | DOOR | 20 | Power door lock system |
| 16 | MIR HTR | 10 | Outside rear view mirror defoggers |
| 17 | RR WIP | 15 | Rear window wiper and washer |
| 18 | WIP | 25 | Windshield wipers and washer |
| 19 | ECU IG | 10 | Emergency flashers, gauges and meters, anti−lock brake system, SRS airbag system, shift lock control system, cruise control system, vehicle stability control system, traction control system |
| 20 | POWER | 30 | Electric moon roof, power windows |
| 21 | AM1 | 40 | Power outlets, rear window defogger, "ACC”, "CIG”, "ECU IG”, "GAUGE”, "RR WIP”, "S−HTR” and "WIP” fuses |
| R1 | Horn | ||
| R2 | Rear fog light (RR FOG) | ||
| R3 | Rear window defogger (DEF) | ||
| R4 | Power outlet (PWR OUTLET) | ||
| R5 | Power window (PWR) | ||
Advertisements
Engine Compartment
- Fuse Box
- Headlamp Cleaner Control Relay
- ABS Actuator and ECU
- LHD: Fusible Link Block
- RHD: Fusible Link Block
Engine Compartment Fuse Box Diagram
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | - | - | Short pin |
| 2 | ALT-S | 5 | Charging system |
| 3 | A/F | 20 | A/F sensor |
| RADIO №2 | 30 | Audio system | |
| 4 | EFI1 | 20 | Multiport fuel injection system/sequential multiport fuel injection system, automatic transmission fluid temperature sensor, "EFI2” and "EFI3” fuses |
| 5 | CUT | 30 | "RADIO” and "DOME” fuses |
| 6 | HAZ | 10 | Emergency flashers |
| 7 | EFI2 | 5 | Multiport fuel injection system/sequential multiport fuel injection system |
| 8 | ABS 2 | 30 | Anti-lock brake system, vehicle stability control system, traction control system, brake assist system |
| 9 | DOME | 10 | Clock, personal light, interior lights, air conditioning system, wireless remote control system, headlight high beam indicator light, gauges and meters, headlight high beam indicator light |
| 10 | MAIN | 30 | "H−LP RH” and "H−LP LH” fuses |
| 11 | EFI3 | 10 | Multiport fuel injection system/sequential multiport fuel injection system, emission control system |
| 12 | RADIO | 15 | Car audio system |
| 13 | A/C | 5 | Air conditioning system |
| 14 | IGN | 15 | Starting system, multiport fuel injection system/sequential multiport fuel injection system |
| 15 | - | - | - |
| 16 | - | - | - |
| 17 | ETCS | 10 | Electronic throttle control system |
| 18 | H−LP RH | 10 | Right−hand headlight |
| 19 | H−LP LH | 10 | Left−hand headlight |
| 20 | INJ | - | Multiport fuel injection system/sequential multiport fuel injection system |
| 21 | ST | 5 | Starting system |
| 22 | AM2 | 30 | Discharge warning light, multiport fuel injection system/sequential multiport fuel injection system, starting system, SRS airbag system and "IG2” fuse |
| 23 | HTR | 40 | Air conditioning system |
| 24 | H−LP CLN | 30 | Headlight cleaner |
| F−HTR | 30 | Fuel heater | |
| 25 | CDS | 30 | Electric cooling fan |
| 26 | ABS 1 | 40 | Anti-lock brake system |
| 50 | Anti-lock brake system | ||
| 27 | RDI | 30 | Electric cooling fan |
| R1 | Engine control unit (EFI MAIN) | ||
| R2 | Electric cooling fan (FAN №3) | ||
| R3 | Ignition (IG2) | ||
| R4 | Electric cooling fan (FAN №2) | ||
| R5 | Air fuel ratio sensor (A/F) | ||
| R6 | Electric cooling fan (FAN №2) | ||
| R7 | Fuel pump (C/OPN) | ||
| R8 | Heater (HTR) | ||
| R9 | Starter (ST) | ||
| R10 | Daytime running light (DRL) | ||
| R11 | Engine control unit | ||
| R12 | - | ||
Advertisements