Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota RAV4 (SXA1 / XA10) (1994, 1995, 1996, 1997).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Turn the engine switch off and turn off all electrical accessories.
- Open the fuse box cover.
- See diagrams below for details about which fuse to check.
- Remove the fuse.
- Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
- Replace the blown fuse with a new fuse of an appropriate amperage rating.
Notice
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
- Always use a genuine Toyota fuse or equivalent.
- Do not modify the fuses or fuse boxes.
- If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.
Passenger Compartment
- Fuse Box
- Relay Box
- ABS ECU
- Fuse Box №2
- A/C Amplifier
- Door Lock Control Relay
- Cruise Control ECU
- Fuse Box №3
- Airbag Sensor Assembly
- Shift Lock ECU
- Engine Control Module
R1 – Rear Wiper Relay
Passenger Compartment Fuse Box Diagram
The fuse panel is located behind the cover on the driver’s side of the dashboard.
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | TAIL | 10 | Tail lights, parking lights, license plate lights, interior lights |
| 2 | GAUGE | 11 | Gauges and meters, service reminder indicators (except discharge and open door warning lights), back-up lights, air conditioning system, power windows, rear window defogger, center differential lock system, electronically controlled automatic transmission system |
| 3 | TURN | 7.5 | Turn signal lights |
| 4 | CIG & RAD | 15 | Cigarette lighter, clock, car audio system, power rear view mirrors |
| 5 | DEF-I/UP | 7.5 | Multiport fuel injection system/sequential multiport fuel injection system |
| 6 | IGN | 7.5 | Multiport fuel injection system/sequential multiport fuel injection system, discharge warning light |
| 7 | ECU-IG | 7.5 | Anti-lock brake system, electronically controlled automatic transmission system |
| 8 | WIPER | 20 | Windshield wipers and washer, rear window wiper and washer |
| 9 | - | - | - |
| 10 | SRS | 7.5 | SRS airbag system |
| 11 | OBD | 7.5 | On-board diagnosis system |
| 12 | STOP | 10 | Stop lights |
Advertisements
Relay Box
| № | Relay |
|---|---|
| R1 | Circuit Opening Relay |
| R2 | - |
| R3 | Turn Signal Flasher |
| R4 | - |
Fuse Box (№2)
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | POWER | 30 | Power windows, power door lock system |
| 2 | DEF | 30 | Rear window defogger |
| 3 | AM1 | 40 | "CIG & RAD”, "WIPER”, "GAUGE”, "ECU-IG”, "TURN”, "TAIL” and "PANEL” fuses |
| 4 | - | - | Noise Filter |
| R1 | Defogger | ||
| R2 | Power Main Relay | ||
| R3 | Taillight | ||
| R4 | Integration Relay | ||
Fuse Box (№3)
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | A/C | 7.5 | Air conditioning system |
| 2 | - | - | - |
| R1 | Heater | ||
Advertisements
Engine Compartment
- Fuse Box
- Relay Box
- ABS Relay
- Fusible Link Block
Engine Compartment Fuse Box Diagram
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | - | - | - |
| 2 | - | - | - |
| 3 | H-LP (LH) | 15 | Left-hand headlight |
| 4 | H-LP (RH) | 15 | Right-hand headlight |
| 5 | - | - | - |
| 6 | - | - | - |
| 7 | SPARE | 15 | Spare fuse |
| 8 | SPARE | 10 | Spare fuse |
| 9 | ALT-S | 5 | Charging system |
| 10 | - | - | - |
| 11 | HAZ-HORN | 15 | Emergency flashers, horns |
| 12 | EFI | 15 | Multiport fuel injection system/sequential multiport fuel injection system |
| 13 | DOME | 15 | Personal lights, open door warning light, clock |
| 14 | AM2 | 20 | Multiport fuel injection system/sequential multiport fuel injection system, charging system |
| 15 | CDS FAN | 30 | Electric cooling fan |
| 16 | RDI FAN | 30 | Electric cooling fan |
| 17 | - | - | - |
| 18 | MAIN № 1 | 30 | Starting system, headlights |
| 19 | ABS | 60 | -1997: Anti-lock brake system |
| 20 | - | - | - |
| R1 | Main | ||
| R2 | Headlights | ||
| R3 | Starter | ||
Advertisements
Relay Box
| № | Relay |
|---|---|
| R1 | EFI Main |
| R2 | Electric cooling fan (№1) |
| R3 | Horn |
| R4 | Electric cooling fan (№3) |
| R5 | Magnetic clutch (A/C) |
| R6 | Electric cooling fan (№2) |
Fusible Link Block
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | Main | 80 | "AM 2”, "HAZ-HORN”, "EFI”, "DOME”, "RADIO” and "ALT-S” fuses |
| 2 | ALT | 100 | Tail lights, "ABS”, "RADIO”, "HTR”, "AM 1”, "POWER”, "STOP” and "DEF” fuses |
| 3 | HTR | 50 | Air conditioning system |
Advertisements