Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota ProAce (2016, 2017, 2018).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Turn the engine switch off (with a smart key system – turn the “ENGINE START STOP” switch off) and turn off all electrical accessories.
- Open the fuse box cover.
- See diagrams below for details about which fuse to check.
- Remove the fuse.
- Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
- Replace the blown fuse with a new fuse of an appropriate amperage rating.
Notice
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
- Always use a genuine Toyota fuse or equivalent.
- Do not modify the fuses or fuse boxes.
- If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.
Passenger Compartment Fuse Box
The fuse panel is located on the lower dashboard (left-hand side). Unclip the cover by pulling at top left, then right.
| № | A | Protected components |
|---|---|---|
| F1 | 3 | Full: Ignition switch, Push starter ADML |
| 10 | ECO: Photochromic interior mirror, Fuel additive pump, DAEH, Knurled wheel ASR+, CTC clutch | |
| F2 | 3 | Full: Steering wheel angle sensor |
| F3 | 3 | Full: Instrumentation socket, Joystic Comelec |
| 5 | ECO: BSG TC | |
| F4 | 7.5 | Full: Instrumentation socket, Diagnostic socket, Brake dual-function switch, Centralized voltage maintenance device |
| 15 | ECO: Horn | |
| F5 | 5 | Full: Multifunction screen, Reversing camera, ECU's parking assistance |
| 20 | ECO: Screen wash pump front/rear | |
| F6 | 15 | Full: - |
| 20 | ECO: Screen wash pump front/rear | |
| F7 | 10 | Full: Audio amplifier, Rear BCC |
| 10 | ECO: Front 12V socket | |
| F8 | 20 | Rear windscreen wiper |
| F9 | 5 | Interior lamp |
| F10 | 30 | Front and rear external/ internal mass power engine locks + Fuel catch |
| F11 | 30 | Front and rear internal/external locks engine supply Fuel catch |
| F12 | 3 | Full: Alarm, APV alarm strain |
| 7.5 | ECO: CTC main stop, DMTC, Diagnostic socket | |
| F13 | 3 | Full: Module boiler control, Strain APV |
| 10 | ECO: Front mux, CRT, BCC, VTH, MCP | |
| F14 | 15 | Full: - |
| 5 | ECO: BTA, Alarm | |
| F15 | 5 | ECO: Diagnostic socket |
| F16 | 5 | Full: - |
| 3 | ECO: Stop switch, DMTR | |
| F17 | 10 | Full: 12V current socket trunk or load area |
| 5 | ECO: CMB | |
| F18 | 5 | Full: Autonomous telematics box |
| ECO: Passenger compartment coolant circuit heater | ||
| F19 | 5 | Full: Rastreador |
| 3 | ECO: BSG, HDC, VCI | |
| F20 | 15 | Full: Relay compartment fusebox 3 |
| F21 | 3 | Full: Nomadic lamp charging, card reader |
| ECO: Steering lock, Push DEM (ADML) | ||
| F22 | 3 | Full: Glove compartment lighting, Card reader |
| ECO: CDPL, CVM | ||
| F23 | 3 | Full: Platinum mirrors control gate driver, Taxi, Parking assistance with blind spot monitoring |
| 5 | ECO: Seat belt not fastened warning light displays | |
| F24 | 5 | Full: Generic servitude case, Module de communication sous volant (CV00) |
| ECO: AAS, Rear camera | ||
| F25 | 5 | Full: Projector corrector switch, Electrochromic rearview mirror |
| ECO: Air bag | ||
| F26 | 3 | Full: Instrumentation sockets, Driver and passenger unfastened indicator display, Strain APV |
| ECO: CAV | ||
| F27 | 3 | Full: Light rain sensor, Switch under the steering wheel |
| 5 | ECO: Heater control module | |
| F28 | 10 | Full: Front gear shift MCP- BCC, Front facade MUX, Audio- Head up display |
| 5 | ECO: Rastreador | |
| F29 | 5 | Full: Engine wiring housing (PSF1) |
| 20 | ECO: RD6, NAC, RCC | |
| F30A | 15 | Full: Audio APV strain |
| F30B | 15 | Full: Audio APV strain |
| F31 | 5 | Full: ECU's air bag |
| 15 | ECO: 2nd build audio system | |
| F32 | 5 | Full: Left and right sliding side door |
| 15 | ECO: Cigar lighter or 12V socket | |
| F33 | 15 | Full: Cigar lighter or 12V socket |
| F34 | 3 | Full: Housing generic servitude |
| 5 | ECO: Taxi unit, AAS with SAM, rear view mirror adjusting, Transformer APC body | |
| F35 | 5 | Full: Combinated ECU |
| ECO: Headlamp height adjustment, BCP, coolant temperature level, Diagnostic socket | ||
| F36 | 20 | Full: Audio |
| 5 | ECO: Glove box lighting, Reloads device, map-reading light | |
| R1 | Power + ACC | |
| R2 | Power + CAN | |
| R3 | Full: Rear screen wipe | |
| ECO: Supply +APC | ||
| R4 | Full: Engine front and rear extriors/interiors locks | |
| R9 | ||
| R4 | ECO: Rear wiper relay | |
| R5 | ECO: Windscreen wash pump | |
| R6 | ECO: Rear screen wash pump | |
| R7 | ECO: Horn | |
| R8 | ECO: Engine front and rear extriors/interiors locks | |
| R13 | ||
Advertisements
Fuse Box №2
| № | A | Protected components |
|---|---|---|
| F1 | 40 | Heated rear screen |
| F2 | 7.5 | Full: Heated mirror |
| 10 | ECO: Heated mirror | |
| F3 | 20 | Full: 230V Current socket |
| 30 | ECO: Electric front windows | |
| F4 | 15 | Full: Folding rearview mirror |
| 30 | Full: Folding rearview mirror, Si 2 LVE | |
| 20 | ECO: 12V socket, Kit APV 230V | |
| F5 | 30 | Full: - |
| 20 | ECO: BSG RQ | |
| F6 | 30 | Full: Front electric window engine |
| 10 | ECO: Fold-back mirrors | |
| F7 | 30 | Full: Heated seat |
| 10 | ECO: Fold-back mirrors | |
| F8 | 25 | Full: Audio amplifier |
| 40 | ECO: - | |
| F9 | 20 | Full: Dual screen wipe AR |
| 15 | ECO: 12V plug RG2 | |
| F10 | 15 | Full: 12V current socket |
| 3 | ECO: BSG | |
| F11 | 5 | Full: Trailer servitude generic case 7/13 tracks |
| 20 | Full: Trailer servitude generic case 7/13 tracks | |
| ECO: Heated cover, Double rear screen wiper | ||
| F12 | 30 | Full: Driver electrical seat |
| 20 | ECO: Heated seat or heated bench seat | |
| F13 | 40 | Full: - |
| F14 | 30 | Full: Passenger electrical seat |
| F15 | 25 | Full: - |
| F16 | 5 | Full: - |
| F17 | 10 | Full: - |
| F18 | 25 | Full: - |
| F19 | 7.5 | Full: - |
| F20 | 3 | Full: ECU's parking assistance |
| F21 | 3 | Full: Power left and right sliding side door |
| F22 | 20 | Full: 12V current socket glove box, Kit APV 230V |
| F23 | 3 | Full: Trailer servitude generic case |
| R1 | Full: Right folding mirror | |
| ECO: Rear screen + mirror demisting | ||
| R2 | Full: Left folding mirror | |
| ECO: Electric windows | ||
| R3 | Full: Heated mirror and rear | |
| ECO: Fold-back mirrors | ||
| R4 | ECO: Fold-back mirrors | |
| R5 | ECO: Heated cover | |
| R6 | ECO: 12V socket | |
| R7 | ECO: Heated seat | |
Engine Compartment Fuse Box
The fusebox is located in the engine compartment near the battery. Release the two latches A, and remove the cover.
Type 1 (ECO)
| № | A | Protected components |
|---|---|---|
| F1 | 40 | Air conditioning blower |
| F10 | 15 | Engine ECU |
| F11 | 20 | Engine ECU |
| F12 | 5 | Engine ECU, diagnostic socket, Fan unit, STT |
| F13 | 5 | BSI |
| F14 | 5 | Battery charge status unit |
| F15 | 20 | BSG |
| F16 | 15 | Front fog lamps |
| F17 | 5 | Diagnostic relay, BFRM |
| F18 | 10 | RH main beam |
| F19 | 10 | LH main beam |
| F2 | 60 | LHD: ESP ECU |
| 50 | RHD: ESP ECU | |
| F20 | 30 | Engine ECU, booster pump (if EP6FDT) |
| F21 | 30 | Starter motor |
| F22 | 40 | LHD: Gearbox MCP, power steering electropump unit |
| 30 | RHD: Gearbox MCP, power steering electropump unit | |
| F23 | 40 | Centralised voltage maintaining system |
| F24 | 40 | Passenger compartment fuse box (BFH5) |
| F25 | 40 | Passenger compartment fuse box (BFH3) |
| F26 | 15 | Gearbox MCP |
| F27 | 25 | BSI |
| F28 | 30 | Injector power supply SCR, NOx sensor |
| F29 | 40 | Windscreen wiper |
| F3 | 80 | Passenger compartment fuse box (BFH3) |
| F30 | 125 | Power steering electropump unit |
| F31 | 80 | Protection switching unit |
| F32 | 80 | BFM4 |
| F4 | 30 | ESP ECU |
| F5 | 50 | BSI |
| F6 | 60 | 2-speed cooling fan (GMV) control unit |
| F7 | 70 | BSI |
| F8 | 15 | Engine ECU (if DV6FUC or EP6FDT), booster pump (if DV6F or DW10F) |
| F9 | 15 | Engine ECU |
| PR | - | Engine ECU |
| PU | - | Engine ECU |
| MF1 | 80 | Pre-post heating |
| MF2 | 20 | BSG |
| MF3 | 20 | Headlamp wash |
| MF4 | 20 | BFRM |
| R1 | SCR unit module power supply | |
| R2 | Heated windscreen wash jets | |
| R3 | Heat pre-conditioning service | |
| R4 | Front fog lamps | |
| R5 | Air conditioning blower | |
| R6 | Starter motor | |
| R7 | Windscreen wiper | |
| R8 | Windscreen wiper | |
| R9 | Main beam headlamps | |
Advertisements
Type 2 (FULL)
| № | A | Protected components |
|---|---|---|
| F1 | 5 | - |
| F5 | 5 | - |
| F6 | 40 | - |
| F8 | 30 | Diesel Euro 6: Sensor NOX and SCR |
| F9 | 10 | - |
| F10 | 5 | - |
| F11 | 5 | - |
| F12 | 15 | Wiper, Manual gearbox, Ax6 III ECU |
| F13 | 20 | Coolant and passenger compartment heater |
| F14 | 5 | COMELEC Ax6 III ECU's |
| F15 | 15 | - |
| F16 | 15 | - |
| F17 | 10 | - |
| F18 | 5 | Brake dual-function switch |
| F19 | 5 | - |
| F1 | 15 | Control of Centralised Power Switch relay 1032, Diesel injectors |
| F2 | 5 | Control of cooling fan unit relay, Bike fan, unit |
| F3 | 5 | Steering relays, Centralized voltage maintenance device, Reversible alternator |
| F4 | 5 | Injector SCR |
| F5 | 15 | Pump driven gavage |
| F6 | 20 | Intake air flow meter, Solenoid Bypass interchange EGR |
| F7 | 10 | Diesel pump solenoid flow control, Proportional solenoid TGV |
| F8 | 10 | Water in diesel detector sensor Solenoid oil pump |
| F9 | 10 | Electronic immobilizer |
| F10 | 5 | - |
| F11 | 15 | Steering protection switch housing 3, Micro projector engine correction, Fuel additive pump Sliding side power door |
| F12 | 5 | Heating nozzle |
| F13 | 5 | Rastreador DMTR |
| F14 | 25 | Powerful pump mass Front and rear screen wash |
| F15 | 5 | Calculating ARTIV, Diagnostic socket, Clutch switch, Coolant level sensor, Power steering computer |
| F16 | 20 | Air conditioning pump group AR |
| F17 | 10 | Built in system interface |
| F19 | 30 | Front screen wipe |
| F20 | 15 | Pump power, Front and rear screen wash |
| F21 | 20 | Headlight washer pump |
| F22 | 15 | Sonor alarm |
| F23 | 15 | Right road lights |
| F24 | 15 | Left road lights |
| F25 | 30 | - |
| F26 | - | - |
| F27 | 5 | - |
| F28 | 5 | - |
| F29 | 30 | Starter |
| F30 | 30 | Diesel heater, Blow-by diesel heater |
| R1 | Diesel engine ECU | |
| R2 | Driving BSM | |
| R3 | Driving BSM | |
| R4 | Engine ECU, Steering relay CPC (1032), Centralized voltage maintenance device, Reversible alternator, Engine blower | |
| R5 | Engine ECU, Additive pump FAP (DV6C-DV6D) | |
| R6 | Supply + APC | |
| R7 | Starter | |
| R8 | Front screen wipe | |
| R9 | ||
| R10 | Front and rear screen wash pump | |
| R11 | Headlamp wash pump | |
| R12 | Sonor alarm | |
| R13 | - | |
| R14 | Left road lights | |
| R15 | Right road lights | |
| R16 | - | |
| R17 | - | |
| № | A | Protected components |
|---|---|---|
| F1 | 80 | Relay compartment fusebox 3 |
| F2 | 70 | Buil in system interface |
| F3 | 50 | ESP ECU's |
| F4 | 20 | Generic servitude case |
| F5 | 30 | ESP ECU's |
| F8 | 125 | Power steering electric pump |
| F9 | 125 | Fuses servitude platinum |
| F10 | 60 | Built-in system interface |
| F11 | 40 | Relay compartment fusebox 5 trailer |
| F12 | 60 | Relay compartment fusebox 3 |
| F13 | 60 | Relay compartment fusebox 2 |
| F16 | 70 | Pre -post heating box |
| F17 | 100 | Maxi fusebox 4 |
| F18 | 40 | AR Additional air conditioning group |
| F19 | 30 | Starter |
| 40 | Centralized voltage maintenance device | |
| F20 | 40 | Taxi Relay compartment fusebox 5 |
| F21 | 20 | Generic servitude case |
| F22 | 5 | Battery charge case |
| F23 | 60 | Control housing GMV |
| F24 | 40 | Air conditioning kicker AV |
| F25 | - | - |
| F26 | 30 | MCP or Ax6 III ECU's gearbox |
| F27 | 80 | Protection switching box 3 |
| № | A | Protected components |
|---|---|---|
| F36 | 20 | ECO: BSG |
| Full: Trailer servitude generic case / Caravan | ||
| 10 | Taxi: Taxi radio | |
| F37 | 20 | ECO: BSG |
| Full: Trailer servitude generic case / Caravan | ||
| 5 | Taxi: Taxi screen | |
| F38 | 20 | ECO: BSG |
| Full: Trailer servitude generic case / Caravan | ||
| 5 | Taxi: Taxi recorder | |
| F39 | 5 | Taxi: Taxi printer |
| F40 | 5 | Taxi: Taxi time recorder requirements |
Advertisements