Toyota HiAce (H200) (2013-2018) Fuse Diagram

Advertisements

Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota HiAce (H200) (2013, 2014, 2015, 2016, 2017, 2018).

Toyota HiAce (H200) (2013-2018)

Checking and Replacing Fuses

The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.

  • Turn the engine switch off (with a smart key system – turn the “ENGINE START STOP” switch off) and turn off all electrical accessories.
  • Open the fuse box cover.
  • See diagrams below for details about which fuse to check.
  • Remove the fuse.
  • Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
  • Replace the blown fuse with a new fuse of an appropriate amperage rating.

Notice

  • Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
  • Always use a genuine Toyota fuse or equivalent.
  • Do not modify the fuses or fuse boxes.
  • If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.

Passenger Compartment

Left-hand drive

Passenger Compartment (LHD)

Right-hand drive

Passenger Compartment (RHD)

  1. Fuse Box
  2. Junction Block
  3. A/C Amplifier
  4. Transmission Control ECU
  5. Additional Fuse Box
  6. Airbag Sensor Assembly Center
  7. Junction Connector (CAN)
  8. RHD: Shift Lock Control ECU

 

Passenger Compartment Fuse Box Diagram

The fuse panel is located under the left side of the dashboard. Remove the cover.

Left-hand drive

Passenger Compartment Fuse Box Location (LHD)

Right-hand drive

Passenger Compartment Fuse Box Location (RHD)

Advertisements

 

Passenger Compartment Fuse Box Diagram

№FuseACircuit
1WIP FR25Front wiper and washer
2R/B INPANE20Power source
3ACCL INT LCK25
4WIP/WSH RR15Rear wiper and washer
5WSH FR10Front wiper and washer
6ECU-IG № 17.5ABS, shift lock
7GAUGE № 110Charging, clock, combination meter, cooling fan, entry and start system, front air conditioner, interior light, power slide door, power window, PTC heater (1KD-FTV, 2KD-FTV), rear window defogger, seat belt warning, wireless door lock control, multiport fuel injection system/sequential multiport fuel injection system
8OBD II7.5On-board diagnosis system
9STOP № 110Stop light, ABS, cruise control, multiport fuel injection system/sequential multiport fuel injection system, entry and start system, shift lock
10-- -
11DOOR30Door lock control, automatic light control, daytime running light, entry and start system, front fog light, headlight , headlight beam level control, illumination, interior light, key reminder, light reminder, power slide door, power window , rear fog light, taillight, wireless door lock control
12HTR RR15Rear air conditioner
13-- -
14FR FOG10Front fog light
15AM110Starting system
16TAIL10Taillight, front fog light, rear fog light, multiport fuel injection system/sequential multiport fuel injection system
17PANEL № 110Clock, combination meter, daytime running light, illumination, key reminder, light reminder, taillight
18A/C № 110Cooling fan (5L-E), front air conditioner, PTC heater (1KD-FTV, 2KD-FTV), rear air conditioner
19-- -
20-- -
21-- -
22-- -
23CIG15Cigarette lighter
24ACC № 17.5Audio system, remote control mirror
25ACC № 27.5Shift lock
26-- -
27-- -
28RR FOG10Rear fog light
29WELCAB15 -
30A/B15SRS, clock, combination meter
31MET IGN10ABS, back-up light, charging, clock, combination meter, daytime running light, entry and start system, front air conditioner, headlight, headlight beam level control (automatic), illumination, interior light, key reminder, light reminder, power slide door (LHD), PTC heater (1KD-FTV, 2KD-FTV), seat belt warning, srs, taillight, turn signal and hazard warning light, wireless door lock control (LHD), multiport fuel injection system/sequential multiport fuel injection system

Passenger Compartment Fuse Box Diagram

№FuseACircuit
1POWER30Power windows
2-- -
3ACC30Entry and start system
Relay
R1Ignition (IG1)
R2Heater (HTR)

Additional Fuse Box

It is below the glove box. Push the tab and remove the cover.

Left-hand drive

Additional Fuse Box Location (LHD)

Right-hand drive

Additional Fuse Box Location (RHD)

Advertisements

 

Left-hand drive

Additional Fuse Box Diagram (LHD)

Right-hand drive

Additional Fuse Box Diagram (RHD)

№FuseACircuit
1-- -
2-- -
3-- -
4DRL10Daytime running light
5IGN №210Multiport fuel injection system/sequential multiport fuel injection system
6IGN №115Multiport fuel injection system/sequential multiport fuel injection system
7IG2-MAIN30Entry and start system
8H-LP RH-LO10LED: Right-hand headlight (Low), automatic light control, headlight beam level control (automatic)
9H-LP LH-LO10LED: Left-hand headlight (Low), automatic light control, headlight beam level control (automatic)
10H-LP RH-HI10LED: Right-hand headlight (High), headlight beam level control (automatic)
11H-LP LH-HI10LED: Left-hand headlight (High), headlight beam level control (automatic)
12SPARE-Spare fuse
13SPARE-Spare fuse
14SPARE-Spare fuse
15--LHD: -
16STOP №27.5Multiport fuel injection system/sequential multiport fuel injection system
17A/C №27.5Front air conditioner
18ST7.5Starting system, multiport fuel injection system/sequential multiport fuel injection system
19H-LP LH-HI10Halogen: Left-hand headlight (High)
20H-LP RH-HI10Halogen: Right-hand headlight (High)
21H-LP LH-LO10Halogen: Left-hand headlight (Low), headlight beam level control (manual)
22H-LP RH-LO10Halogen: Right-hand headlight (Low)
23ECU IG №27.5Automatic glare-resistant EC mirror, automatic light control, daytime running light, door lock control (LHD), entry and start system, front fog light, headlight, headlight beam level control, illumination, interior light, key reminder, light reminder, parking assist (rear view monitor), power slide door (LHD), rear fog light, taillight, wireless door lock control (LHD)
24GAUGE №210ABS, automatic glare-resistant EC mirror, back-up light, ECT and A/T indicator, parking assist (rear view monitor), power slide door (LHD), seat belt warning
25-- -
26-- -
27-- -
28-- -
29-- -
Relay
R1Dimmer
R2Headlight (HEAD)
R3 -
R4Rear fog light (FOG RR)
R5 -
R6Air conditioner compressor clutch (MG CLT)
R7PTC Heater (PTC №1)
R8 -
R9PTC Heater (PTC №2)
R10Horn
R11Starter (ST)

Passenger Compartment

  1. Door Control Relay (RH)
  2. Door Opening Relay (RH)
  3. Door Control Relay (Power Slide Door RH)
  4. Door Control Relay (Power Slide Door LH)
  5. Door Control Receiver
  6. Door Opening Relay (LH)
  7. Door Control Relay (LH)

Engine Compartment

Engine Compartment

  1. Fuse Box
  2. Additional Fuse Box
  3. 1TR-FE, 2TR-FE: Cooling Fan ECU №2
  4. Skid Control ECU with Actuator
  5. 1KD-FTV, 2KD-FTV, 5L-E: Cooling Fan ECU №2
  6. 1KD-FTV (EURO5): Injector Driver (EDU)
  7. 1KD-FTV, 2KD-FTV, 5L-E: Cooling Fan ECU №1
  8. 1TR-FE, 2TR-FE: Cooling Fan ECU №1
  9. Engine ECU
  10. 1TR-FE, 2TR-FE: Air Injection Control Driver
    1KD-FTV (Except EURO5), 2KD-FTV: Injector Driver (EDU)
  11. Glow Plug Controller

Advertisements

 

Engine Compartment Fuse Box Diagram

Push the tab and remove the cover.

Engine Compartment Fuse Box Location

Engine Compartment Fuse Box Diagram

№FuseACircuit
1-- -
2-- -
3ST40Entry and start system
4DOOR RR30Door closer (slide door), power slide door
5A/PMP501TR-FE, 2TR-FE: Multiport fuel injection system/sequential multiport fuel injection system
6ETCS101TR-FE, 2TR-FE: Electronic throttle control system, multiport fuel injection system/sequential multiport fuel injection system
7EFI №210Multiport fuel injection system/sequential multiport fuel injection system
8PSD RH25Power slide door
9A/C №37.5Rear air conditioner
10EFI №3101TR-FE, 2TR-FE, 1KD-FTV: Multiport fuel injection system/sequential multiport fuel injection system
11P/OUTLET15Power outlets
12-- -
13PTC №250PTC heater
14PTC №150PTC heater
15HTR FR40Front air conditioner, PTC heater
16CLR RR30Rear air conditioner
17DEF50Rear window defogger
18MIR HTR15Outside rear view mirror defoggers
19A/F HTR15Multiport fuel injection system/sequential multiport fuel injection system
20EFI №1251KD-FTV, 2KD-FTV, 5L-E: Multiport fuel injection system/sequential multiport fuel injection system
21EFI №1201TR-FE, 2TR-FE: Multiport fuel injection system/sequential multiport fuel injection system
EDU251KD-FTV, 2KD-FTV, 5L-E: Multiport fuel injection system/sequential multiport fuel injection system
22-- -
23P/I №180Passenger compartment additional fuse box
24FAN №160Electric cooling fan
25ALT150Charging system, "J/B", "DEF", "HTR FR", "CLR RR", "PTC №1", "PTC №2" fuses
26J/B100Passenger compartment fuse box
27FAN №260Electric cooling fan
28GLOW801KD-FTV, 2KD-FTV, 5L-E: Engine glow system
29P/I №260"A/F HTR", "EFI №1", "EDU" fuses
30-- -
Relay
R1Rear air conditioner (CLR RR)
R2Electric cooling fan (FAN №1)
R3Electric cooling fan (FAN №2)
R4Rear window defogger (DEF)
R51KD-FTV, 2KD-FTV, 5L-E: Engine glow system (GLOW)
R61KD-FTV, 2KD-FTV, 5L-E: -
R71KD-FTV, 2KD-FTV, 5L-E: -

Additional Fuse Box

Additional Fuse Box Diagram

№FuseACircuit
1ABS SOL25ABS
2HORN15Horn
3ALT-S7.5Charging
4DEF30Rear window defogger
5RADIO15Audio system
6DOME №210Interior light
7DOME №110ABS, back-up light, clock, combination meter, daytime running light, multiport fuel injection system/sequential multiport fuel injection system, entry and start system, escape hammer buzzer system, front air conditioner, headlight (LED), headlight beam level control (automatic), illumination, interior light, key reminder light reminder, power slide door, PTC heater (1KD-FTV, 2KD-FTV), seat belt warning, SRS, taillight, turn signal and hazard warning light, wireless door lock control
8D/C CUT30"RADIO', "DOME №1", "DOME №2" fuses
9AM27.5Door closer (slide door),entry and start system, power slide door
10TVSS15Power source
11TRN&HAZ15Turn signal and hazard warning light, clock, combination meter
12STRG LOCK10Entry and start system
13PSD LH25Power slide door
14ECU-B10Engine immobiliser system, entry and start system, front air conditioner, power slide door, PTC heater (1KD-FTV, 2KD-FTV), wireless door lock control
15HEAD40Headlight (halogen), automatic light control, headlight beam level control (manual)
16DOOR R/L30Door closer (slide door), power slide door
17DOOR BK30Door closer (back door)
18ABS MTR40ABS
19AM230Multiport fuel injection system/sequential multiport fuel injection system

 

Advertisements

Advertisements