Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota Fortuner (2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Turn the engine switch off (with a smart key system – turn the “ENGINE START STOP” switch off) and turn off all electrical accessories.
- Open the fuse box cover.
- See diagrams below for details about which fuse to check.
- Remove the fuse.
- Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
- Replace the blown fuse with a new fuse of an appropriate amperage rating.
Notice
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
- Always use a genuine Toyota fuse or equivalent.
- Do not modify the fuses or fuse boxes.
- If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.
Passenger Compartment
Left-hand drive
Right-hand drive
- Fuse Box
- 4WD Control ECU (Rear Diff. Lock)
- Magnet-Clutch Relay
- Turn Signal Flasher
- Junction Connector (CAN)
- Taillight Relay
- Engine ECU
- Door Lock Control Receiver
- Headlight Leveling ECU
- Theft Warning ECU
- Relay Box
- Transmission Control ECU
- A/C Control
- Transponder Key Amplifier
- Shift Lock Control ECU
- Airbag Sensor Assembly Center
- A/C Amplifier
Passenger Compartment Fuse Box Diagram
The fuse panel is located on the driver’s side of the dashboard. Remove the bottom dashboard to access fuses.
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | INJ | 15 | Multiport fuel injection system/sequential multiport fuel injection system |
| 2 | OBD | 7.5 | On-board diagnosis system |
| 3 | STOP | 10 | Stop lights, high mounted stoplight, multiport fuel injection system/sequential multiport fuel injection system, ABS, TRC, VSC and shift lock control system |
| 4 | TAIL | 10 | Instrument panel light, front fog lights, headlight beam level control system, front position lights, tail lights, license plate lights, multiport fuel injection system/sequential multiport fuel injection system, multi-information display, daytime running light system and automatic headlight system |
| 5 | PWR OUT | 15 | Power outlet |
| 6 | ST | 7.5 | Starting system, gauges and meters and multiport fuel injection system/sequential multiport fuel injection system |
| 7 | A/C | 10 | Air conditioning system |
| 8 | MET | 7.5 | Gauges and meters and DPF system |
| 9 | CIG | 15 | Cigarette lighter |
| 10 | ACC | 7.5 | Audio system, power outlet, clock, power rear view mirror control system, shift lock control system and multi-information display |
| 11 | IGN | 7.5 | Multiport fuel injection system/sequential multiport fuel injection system, SRS airbags and fuel pump |
| 12 | WIP | 20 | Windshield wiper and washer |
| 13 | ECU-IG & GAUGE | 10 | Air conditioning system, charging system, rear differential lock system, ABS, TRC, VSC, emergency flashers, turn signal lights, back-up lights, multiport fuel injection system/sequential multiport fuel injection system, shift lock control system, rear window defogger, headlights, door courtesy switches, power door lock system, wireless remote control system, steering sensor, daytime running light system, cruise control, headlight cleaners, seat heaters, outside rear view mirror defoggers, multi-information display and passenger’s seat belt reminder light |
| 1 | AM1 | 40 | Rear differential lock system, ABS, TRC, VSC, "ACC", "CIG", "ECU-IG & GAUGE", and "WIP" fuses |
| 2 | IG1 | 40 | "PWR", "S-HTR", "4WD", "DOOR", "DEF" and "MIR HTR" fuses |
| R1 | Power outlet (PWR OUT) | ||
| R2 | Heater (HTR) | ||
| R3 | Integration relay | ||
Advertisements
Additional Fuse Box
Open the glove box, press the glove box on both sides to disconnect the clamps.
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | DOOR | 25 | Power door lock system and power windows |
| 2 | DEF | 20 | Rear window defogger and multiport fuel injection system/sequential multiport fuel injection system |
| 3 | - | - | - |
| 4 | 4WD | 20 | Rear differential lock system, ABS, TRC and VSC |
| 5 | PWR | 30 | Power windows |
| R1 | Ignition (IG1) | ||
| R2 | Rear window defogger (DEF) | ||
- Rear Heater Relay
- Clearance Warning ECU
Engine Compartment
- Fuse Box
- Headlight Cleaner Control Relay
- RHD: Skid Control ECU with Actuator
- LHD: Injector Driver (EDU)
- Air Injection Control Driver
- Electric Cooling Fan Relay (CDS FAN)
- RHD: Injector Driver (EDU)
- LHD: Skid Control ECU with Actuator
Advertisements
Engine Compartment Fuse Box Diagram
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | - | 25 | Spare fuse |
| 2 | - | 15 | Spare fuse |
| 3 | - | 10 | Spare fuse |
| 4 | FOG | 15 | Front fog lights |
| 5 | HORN | 10 | Horn |
| 6 | EFI | 25 | Multiport fuel injection system/sequential multiport fuel injection system |
| 7 | - | - | - |
| 8 | H-LP RL | 20 | Before Jun. 2011: Right-hand headlight (Low) |
| 15 | From Jun. 2011: Right-hand headlight (Low) | ||
| 9 | H-LP LL | 20 | Before Jun. 2011: Left-hand headlight (Low) |
| 15 | From Jun. 2011: Left-hand headlight (Low) | ||
| 10 | H-LP RH | 20 | Before Jun. 2011: Right-hand headlight (High) and right-hand headlight (Low) |
| 15 | From Jun. 2011: Right-hand headlight (High) and right-hand headlight (Low) | ||
| 11 | H-LP LH | 20 | Before Jun. 2011: Left-hand headlight (High) and left-hand headlight (Low) |
| 15 | From Jun. 2011: Left-hand headlight (High) and left-hand headlight (Low) | ||
| 12 | ECU-IG №2 | 7.5 | Before Aug. 2013: Multiport fuel injection system/sequential multiport fuel injection system |
| 10 | From Aug. 2013: Multiport fuel injection system/sequential multiport fuel injection system | ||
| 13 | - | - | - |
| 14 | ECU-B | 7.5 | Before Aug. 2008: Door courtesy switches, power door lock system, wireless remote control system, steering sensor and headlights |
| 10 | From Aug. 2008: Door courtesy switches, power door lock system, wireless remote control system, steering sensor and headlights | ||
| 15 | RAD | 15 | Before Aug. 2013: Audio system |
| 20 | From Aug. 2013: Audio system | ||
| 16 | DOME | 7.5 | Interior lights, engine switch light, personal light, gauges and meters, clock, multi-information display, wireless remote control system, daytime running light system and fog light |
| 17 | A/F | 20 | Emission control system |
| 18 | ETCS | 10 | Multiport fuel injection system/ sequential multiport fuel injection system, electric throttle control system |
| 19 | ALT-S | 7.5 | Charging system |
| 20 | TURN-HAZ | 15 | Emergency flashers and turn signal lights |
| 21 | - | - | - |
| 22 | ECU-B №2 | 7.5 | Air conditioning system |
| 23 | DCC | 30 | "ECU-B", "DOME" and "RAD" fuses |
| 24 | PTC №1 | 50 | 1KD-FTV, 5L-E: Power heater |
| H-LP CLN | 50 | 1GR-FE: Headlight cleaners | |
| 25 | PWR SEAT | 30 | Power seat |
| 26 | CDS FAN | 30 | Electric cooling fan |
| 27 | ABS №1 | 40 | Before Aug. 2008: ABS, TRC and VSC |
| RR CLR | 40 | From Aug. 2008: Rear air conditioner | |
| 28 | FR HTR | 40 | Before Aug. 2009: Air conditioning system, "A/C" fuse |
| 50 | From Aug. 2009: Air conditioning system, "A/C" fuse | ||
| 29 | ABS №2 | 40 | ABS, TRC and VSC |
| 30 | RR CLR | 30 | Before Aug. 2008: Rear air conditioner |
| ABS №1 | 40 | From Aug. 2008: ABS, TRC and VSC | |
| 31 | ALT | 100 | Charging system, "PWR SEAT", "HLP CLN", "FR HTR", "AM1", "IG1", "PTC №1", "PTC №2", "PWR OUT", "STOP", "TAIL" and "OBD" fuses |
| 32 | GLOW | 80 | Engine glow system |
| 33 | BATT P/I | 50 | "FOG", "HORN" and "EFI" fuses |
| 34 | AM2 | 30 | Engine starter, "ST", "IGN", "INJ" and "MET" fuses |
| 35 | MAIN | 40 | "H-LP RH", "H-LP LH", "H-LP RL" and "H-LP LL" fuses |
| 36 | A/PUMP | 50 | 2TR-FE: Multiport fuel injection system/sequential multiport fuel injection system |
| H-LP CLN | 50 | 1KD-FTV: Headlight cleaners | |
| R1 | Dimmer (DIM) | ||
| R2 | HID: Headlight (H-LP) | ||
| Halogen: Electric cooling fan (CDS FAN) | |||
| R1 | Starter (ST) | ||
| R2 | 1GR-FE, 2TR-FE: Air fuel ratio sensor (A/F) | ||
| 1KD-FTV, 5L-E: Engine glow system (GLOW) | |||
| R3 | 1GR-FE, 2TR-FE: Fuel pump (F/PMP) | ||
Advertisements