Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota Avensis (T250, T251) (2003, 2004, 2005, 2006, 2007, 2008, 2009).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Turn the engine switch off and turn off all electrical accessories.
- Open the fuse box cover.
- See diagrams below for details about which fuse to check.
- Remove the fuse.
- Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
- Replace the blown fuse with a new fuse of an appropriate amperage rating.
Notice
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
- Always use a genuine Toyota fuse or equivalent.
- Do not modify the fuses or fuse boxes.
- If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.
Passenger Compartment
Left-hand drive
Right-hand drive
- Fuse Box
- Integration Relay
- Circuit Opening Relay
- Rear Fog Light Relay
- Rear Window Defogger Relay
- Relay Box
- Turn Signal Flasher Relay
- Transponder Key Amplifier
- EPS ECU
- Transponder Key Computer
- Antenna Amplifier
- Junction Block
- Wiper Relay
- Door Control Receiver
- Headlight Beam Level Control ECU
- Engine and ECT ECU (A/T)
Engine ECU (M/T) - A/C Control Assembly
- Option Connector (Navigation ECU)
- Shift Lock Control ECU
- Airbag Sensor Assembly
- Navigation ECU
- Additional Fuse Box
- RHD: Theft Deterrent ECU
Passenger Compartment Fuse Box Diagram
LHD: The fuse panel is located behind the cover on the driver’s side of the dashboard.
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | IGN | 10 | SRS airbag system, gauge and meters, starting system, multiport fuel injection system/sequential multiport fuel injection system |
| 2 | S/ROOF | 20 | Sliding roof |
| 3 | RR FOG | 7.5 | Rear fog light |
| 4 | FR FOG | 15 | Front fog light, indicator light |
| 5 | AM1 | 25 | Starting system, "CIG", "RAD №1" fuses |
| 6 | PANEL | 7.5 | Instrument cluster lights, instrument panel lights, electronic controlled transmission, multi−information display, glove box light, console box light, headlight cleaner, front fog light, TOYOTA parking sssist |
| 7 | RR WIP | 20 | Rear wiper and washer |
| 8 | GAUGE2 | 7.5 | Back–up light, headlight leveling system, turn signal and hazard warning light |
| 9 | CIG | 15 | Cigarette Lighter |
| 10 | HTR | 10 | Seat heaters, air conditioning system |
| 11 | - | - | - |
| 12 | RAD №1 | 7.5 | Audio system, multi−information display, power rear view mirrors, gauge and meters, power outlet |
| 13 | PWR SEAT | 30 | Power seat |
| 14 | TAIL | 10 | Tail lights, parking lights, license plate lights, trunk light, automatic light control system, front fog light, rear fog light, |
| combination meter | |||
| 15 | OBD2 | 7.5 | On−board diagnosis system |
| 16 | P/POINT | 15 | Power Outlet |
| 17 | DOOR | 25 | Power door lock system |
| 18 | WIP | 25 | Front wiper and washer, headlight cleaner |
| 19 | ECU-IG | 7.5 | Electric cooling fans, charging system, ABS, vehicle stability control system, electric power steering |
| 20 | S-HTR | 20 | Seat heaters |
| 21 | GAUGE1 | 10 | Switch illumination, multi−information display, integration relay, gauge and meters, shift lock control system, electronic controlled transmission, auto anti-glare inside rear view mirror, windshield wipers, parking brake |
| 22 | STOP | 15 | Stop light, shift lock control system, ABS, high mounted stoplight, multiport fuel injection system/sequential multiport fuel injection system |
| R1 | - | - | |
| R2 | HTR | Heater | |
| R3 | SEAT HTR | Seat Heater | |
| R4 | IG1 | Ignition | |
| R5 | TAIL | Taillight | |
Advertisements
Additional Fuses
LHD: The fuse panel is located below the driver’s side of the dashboard.
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | - | - | - |
| 2 | P-RR P/W | 20 | Power window |
| 3 | P-FR P/W | 20 | Power window |
| 4 | D-RR P/W | 20 | Power window |
| 5 | D-FR P/W | 20 | Power window |
| 6 | ECU-B 1 | 7.5 | Multi–mode manual transmission |
| 7 | FUEL OPN | 10 | Fuel filler door opener |
| 8 | FR DIC | 20 | Front window deicer, "MIR HTR" fuse |
| 9 | - | - | - |
| 10 | DEF I/UP | 7.5 | Air conditioning system |
| 11 | ST | 7.5 | Multiport fuel injection system/sequential multiport fuel injection system, multi-information display, starting system |
| 12 | MIR HTR | 10 | Outside rear view mirror defogger |
| 13 | RAD №2 | 15 | Audio system, multi-information display |
| 14 | DOME | 7.5 | Interior light, personal lights, foot lights, door courtesy lights, trunk light, vanity lights |
| 15 | ECU-B 2 | 7.5 | Air conditioning system, wireless door lock control |
| 16 | PWR SEAT | 30 | Power seat |
Relay Box
| № | Relay |
|---|---|
| R1 | Front window deicer (FR DEICER) |
| R2 | Power Outlet (P/POINT) |
| R3 | Front Fog Light (FR FOG) |
| R4 | Starter (ST) |
Sedan
Liftback
Wagon
- Telephone Microphone Amplifier
- Moon Roof Control Relay and Motor
- Rear Wiper Motor and Relay
Advertisements
Engine Compartment
1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE
1CD-FTV
- Electronic Driver Unit
- Additional Fuse Box
- Fuse Box
- Headlight Control ECU LH
- Relay Box
- Headlight Cleaner Control Relay
- Headlight Control ECU RH
- Skid Control ECU with Actuator (with VSC)
- Skid Control ECU with Actuator (without VSC)
- Glow Plug Relay
- Power Heater Assembly
Engine Compartment Fuse Box Diagram
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | - | - | - |
| 2 | VSC | 25 | 1CD–FTV: ABS, VSC |
| ABS | 25 | 1CD–FTV: ABS | |
| 3 | - | - | - |
| 4 | - | - | - |
| 5 | - | - | - |
| 6 | ALT-S | 7.5 | Charging system |
| 7 | DCC | 30 | "ECU-B №2", "DOME", "RAD №2" fuses |
| 8 | AM2 | 30 | Starting system, "ST", "IGN" fuses |
| 9 | HAZARD | 10 | Turn signal and hazard warning light |
| 10 | F-HTR | 25 | 1CD–FTV: Fuel heater |
| 11 | HORN | 15 | Horn |
| 12 | EFI | 20 | Multiport fuel injection system/sequential multiport fuel injection system, "EFI №1", "EFI №2" fuses |
| 13 | PWR HTR | 25 | 1CD–FTV:Power heater |
| 14 | RR DEF | 30 | Rear windshield defogger |
| 15 | MAIN | 40 | Headlight cleaner, headlight, "H-LP HI LH", "H-LP HI RH", "H-LP LH", "H-LP RH" fuses |
| 16 | AM1 №1 | 50 | 1CD–FTV: "ACC", "CIG", "RAD №1", "ECU-B №1", "FL P/W", "FR P/W", "RL P/W", "RR P/W" |
| 17 | H/CLN | 30 | Headlight Cleaner |
| 18 | HTR | 40 | Air conditioner, heater |
| 19 | CDS | 30 | Electric cooling fan |
| 20 | RDI | 40 | 1CD–FTV, 1ZZ-FE, 3ZZ-FE: Electric cooling fan |
| 30 | 1AZ-FE, 1AZ-FSE: Electric cooling fan | ||
| 21 | VSC | 50 | 1CD–FTV: ABS, VSC |
| ABS | 40 | 1CD–FTV: ABS | |
| 22 | IG2 | 15 | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: Starting system, multiport fuel injection system/sequential multiport fuel injection system |
| 23 | THROTTLE | 10 | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: Electronic throttle control system |
| ETCS | 10 | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: Electronic throttle control system | |
| 24 | A/F | 20 | 1AZ-FSE, 1AZ-FE: Air fuel ratio sensor |
| 25 | - | - | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: - |
| 26 | - | - | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: - |
| 27 | EMPS | 50 | 1ZZ-FE, 3ZZ-FE: Electric power steering |
| R1 | EFI MAIN | 1CD–FTV: Engine control unit | |
| R2 | EDU | 1CD–FTV: Engine control unit | |
| R3 | FAN №3 | 1CD–FTV: Electric cooling fan | |
| R4 | FAN №1 | Electric cooling fan | |
| R5 | FAN №2 | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: Electric cooling fan | |
| R6 | - | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: - | |
| R7 | FAN №3 | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: Electric cooling fan | |
| R8 | - | 1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE: - | |
| R9 | EMPS | 1ZZ-FE, 3ZZ-FE: Electric power steering | |
Advertisements
Relay Box
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | H-LP HI LH | 10 | Left-hand headlight (high beam) |
| 2 | H-LP HI RH | 10 | Right-hand headlight (high beam), gauge and meters |
| 3 | H-LP LH | 15 | Left-hand headlight (low beam) |
| 4 | H-LP RH | 15 | Right-hand headlight (low beam) |
| R1 | HORN | Horn | |
| R2 | F-HTR | Fuel Heater | |
| R3 | H-LP | Headlight | |
| R4 | DIM | Dimmer | |
| R5 | FAN №2 | Electric cooling fan | |
Additional Fuse Box (1CD-FTV)
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | - | - | - |
| 2 | HTR2 | 50 | Power heater |
| 3 | HTR1 | 50 | Power heater |
| 4 | GLOW | 80 | Glow plug |
| 5 | ALT | 140 | IG1 Relay, TAIL Relay, SEAT HTR Relay, "H-LP CLN", "AM1 №1", "RDI", "CDS", "VSC" (50A), "VSC" (25A), "ABS" (40A), "ABS" (25A), "H/CLN", "RR DEF", "GLOW", "HTR NO1", "HTR NO2", "RFGHTR", "AM1 №2", "RR FOG", "S/ROOF", "STOP", "P/POINT", "FR FOG", "OBD2", "DOOR" fuses |
| R1 | - | - | |
| R2 | HTR2 | Power heater | |
| R3 | HTR1 | Power heater | |
Additional Fuse Box (1AZ-FSE, 1AZ-FE, 1ZZ-FE, 3ZZ-FE)
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | EFI №1 | 10 | Multiport fuel injection system/sequential multiport fuel injection system |
| 2 | EFI №2 | 7.5 | Emission control system |
| 3 | VSC | 25 | ABS, VSC |
| ABS | 25 | ABS | |
| 4 | ALT | 100 | 1ZZ-FE, 3ZZ-FE: "AM1 №1", "H-LP CLN", "ABS" (25A), "VSC" (25A), "ABS" (40A), "VSC" (50 A), "CDS", "RDI", "HTR", "RR DEF", "RR FOG", "FR FOG", "AM1", "DOOR", "STOP", "OBD2", "S/ROOF", "PWR SEAT", "P/POINT", "TAIL", "PANEL", "RR WIP", "ECU-IG", "WIP", "GAUGE2", "GAUGE1", "HTR" ,"S-HTR" fuses |
| 120 | 1AZ-FSE, 1AZ-FE: "AM1 №1", "H-LP CLN", "ABS" (25A), "VSC" (25A), "ABS" (40A), "VSC" (50 A), "CDS", "RDI", "HTR", "RR DEF", "RR FOG", "FR FOG", "AM1", "DOOR", "STOP", "OBD2", "S/ROOF", "PWR SEAT", "P/POINT", "TAIL", "PANEL", "RR WIP", "ECU-IG", "WIP", "GAUGE2", "GAUGE1", "HTR" ,"S-HTR" fuses | ||
| 5 | VSC | 50 | ABS, VSC |
| ABS | 40 | ABS | |
| 6 | AM1 №1 | 50 | "PWR SEAT", "FR DIC", "FUEL OPN", "ECU-B 1", P-RR P/W", "P-FR P/W", "D-RR P/W", "D-FR P/W" fuses |
| 7 | H-LP CLN | 30 | Headlight cleaner |
| R1 | INJ | Injector | |
| R2 | EFI | Engine control unit | |
| R3 | IG2 | Ignition | |
| R4 | A/F | Air fuel ratio sensor | |
Advertisements