Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Saab 9-5 (95) (1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009).
Checking and Replacing Fuses
The fuses are designed to melt during an overload to prevent damage to the wiring harness and electrical equipment.
If any lights, accessories, or other electrical controls do not operate, inspect the corresponding fuse. If a fuse has blown, replace it. To check if a fuse has blown, first remove it from the panel (A special tool for removing fuses is provided at the bottom of the fuse panel at the end of the instrument panel). If the filament is broken, the fuse has blown
- Turn the ignition switch to the “LOCK” position and turn off all electrical accessories.
- Remove the cover.
- Determine which fuse may be blown.
- Pull out the fuse with the fuse puller. Simply push the tool onto the fuse, squeeze and remove the fuse.
- Inspect the fuse. If it has blown, replace it with a spare fuse of the same rating.
- If the same fuse blows again, this indicates that its system has a problem. Contact your Saab dealer for repairs.
Wallet for Spare Bulbs and Fuses
To avoid the risk of short-circuiting and/or fire breaking out in the electrical system, the following advice should be heeded:
- Turn off the ignition switch and all electrical equipment before changing a fuse.
- Always consult an authorized Saab dealer before modifying or adding any electrical equipment. Failure to do so can result in the electrical system being damaged.
- Never replace a fuse with one having a higher/lower rating than specified. The color of the fuse indicates its amperage.
- If the same fuse blows repeatedly, have the electrical system checked by an authorized Saab dealer.
- If a MAXI fuse blows, it means that there is a major fault in the electrical system. Have the car checked without delay by an authorized Saab dealer.
Passenger Compartment Fuse Box
The fuse box is located at the end of the instrument panel on the driver’s side.
| № | A | Protected Component |
|---|---|---|
| A | 25 | 1997-1999: Trailer Lights |
| 30 | 2000-2009: Trailer Lights | |
| B | 10 | Transmission Control Module (TCM), Audio System (1997-1999) |
| C | 7.5 | Electrically Adjustable Door Mirror, DICE, Manual Beam Length Adjustment (2000-2009) |
| 1 | 15 | Brake Lights, Park Brake Shift Lock |
| 2 | 15 | Reversing Lights |
| 3 | 10 | Parking and Tail Lights, Left |
| 4 | 10 | Parking and Tail Lights, Right |
| 5 | 7.5 | DICE / TWICE |
| 6 | 30 | Electric Windows (Right), Trailer Charging (2002-2009) |
| 6B | 5 | 1997-2001: Brake Lights (Trailer) |
| 10 | 2002-2004: Brake Lights (Trailer) | |
| 7.5 | 2005-2009: Brake Lights (Trailer) | |
| 7 | 10 | Injectors, Turbo Bypass Solenoid Valve, Evaporative Emission Control (EVAP) Shut Off Solenoid Valve, EVAP Canister Purge Valve |
| 8 | 15 | Trunk Lighting, SID, Car Phone, Trunk Lock, Door Lighting, Saab Parking Assist (SPA), Engine Coolant Circulation Pump |
| 9 | 15 | Audio System, CD Changer, Data Link Connector |
| 10 | 15 | Memory Function, Power Mirror Memory (PMM), Heated Rear Seat, Sunroof, Fog Light |
| 11 | 30 | Electrically Adjustable Passenger Seat, Central Locking System (1997-2004), Navigation |
| 12 | 7.5 | Transmission Control Module (TCM) |
| 13 | 20 | Audio System, Amplifier |
| 14 | 30 | Ignition System, Engine Control Module (Trionic), Mass Air Flow Sensor, Charge Air Solenoid Valve, Exhaust Gas Recirculation (EGR) Solenoid Valve, Direct Ignition (DI) Cassette, A/C Compressor |
| 15 | 15 | 1997-2001: Preheated Oxygen Sensor (Catalytic Converter) |
| 20 | Fuel Pump, Heated Oxygen Sensors, Heated Fuel Filter (Diesel) | |
| 16 | 20 | DICE (Direction Indicators) |
| 16B | 5 | 2000-2001: Road Toll Provision, OnStar |
| 7.5 | 2002-2009: Road Toll Provision, OnStar | |
| 17 | 20 | Engine Control Module (Trionic), Instrument Panel (MIU), DICE/TWICE |
| 18 | 7.5 | 1997-2001: Door Mirror Heating |
| 40 | 2002-2009: Door Mirror Heating, Rear Window Heating | |
| 19 | 20 | 1997-2001: Fuel Pump |
| 10 | 2002-2009: OnStar; Telematics, Car Phone | |
| 20 | 15 | Automatic Climate Control (ACC), Interior Lighting, Rear Fog Light, High Beam Flasher |
| 21 | 10 | Audio System, Rear View Mirror, Load Angle Sensor (with Xenon), Navigation, Cruise Control |
| 22 | 40 | 1997-2001: Ventilation Fan Motor, Secondary Air Injection (SAI) Pump (2000-2001) |
| 30 | 2002-2004: Ventilation Fan Motor | |
| 40 | 2005-2009: Ventilation Fan Motor | |
| 23 | 15 | 1997-2004: Sunroof |
| 15 | 2005-2009: Central Locking; Navigation; Door Mirror Memory | |
| 24 | 40 | 1997-2001: Heated Rear Window |
| 40 | 2002-2004 (3.0t): Secondary Air Injection Pump | |
| 20 | 2006-2009: Main Light Switch | |
| 25 | 30 | Electrically Adjustable Driver’s Seat, Fuel-Filler Flap |
| 26 | 7.5 | Driver Seat Memory (2002-2009), Mirrors Memory (2002-2009), Sunroof (2002-2009), Saab Parking Assist (SPA) (2002-2009), Seat-Belt Reminder (2002-2009), Automatic Climate Control (ACC) (2002-2009), Manual Climate Control (1997-1999), ABS Brakes (1997-2001), PSM |
| 27 | 10 | Engine Control Module, SID, Seat Belt Warning (1997-2001), Instrument Panel (MIU), DICE, Saab Parking Assist (SPA) (1997-2001) |
| 28 | 7.5 | Airbag (SRS) |
| 29 | 7.5 | Transmission Control Module (TCM) (1997-2004), ABS/TCS/ESP (2002-2009) |
| 30 | 7.5 | Starter Motor, Transmission Control Module (TCM) (2006-2009) |
| 31 | 7.5 | Cruise Control System; Headlamp Beam Adjustment; Automatic/Manual Climate Control (ACC/MCC), Water Valve, Front Fog Lights (2005-2009), Rain Sensor, Heat Exchanger Sovenoid Valve |
| 32 | 15 | 1997-2005: Ventilated Front Seats |
| 33 | 7.5 | Direction Indicator Switch |
| 34 | 30 | Cigarette Lighter (Front/Rear) |
| 35 | 15 | Daytime Running Light |
| 36 | 30 | Electric Windows (Left) |
| 37 | 30 | Windshield Wipers, Front Fog Lights (1997-1999) |
| 38 | 30 | Heated Front Seats |
| 39 | 20 | Limp-Home Solenoid (Automatic Transmission), OnStar (2002-2005), Telematics (2002-2005) |
Advertisements
Relay panel under the instrument panel
| № | Relay |
|---|---|
| A | - |
| B | Heated Rear Seats |
| C1 | - |
| C2 | Auxiliary Heater |
| D | 3.0 V6TiD: Secondary Air Injection Pump |
| E | Main (Engine Control Module) |
| F | Fuel Filler Flap |
| G | Petrol: Fuel Pump |
| Diesel: Preheating Diesel | |
| H | Ignition Switch |
| I | Rear Window / Door Mirrors Heating |
| J | 1997-2001: Revers Light |
| K | Starter |
| L1 | Limp-Home Function |
| L2 | Tailgate Motor |
Engine Compartment Fuse Box
Diagram 1997-2001
| № | A | Protected Component |
|---|---|---|
| 1 | 60 | ABS |
| 2 | - | - |
| 3 | 15 | Horn |
| 4 | 10 | 1997-1999: Headlamp Wipers |
| 30 | 2000-2001: Rear Window Wiper | |
| 5 | 15 | Fog Lights (Front Spoiler) |
| 6 | 30 | Radiator Fan (High Speed) |
| 7 | 15 | Low Beam Headlight (Right) |
| 8 | 15 | High Beam Headlight (Right) |
| 9 | 15 | Low Beam Headlight (Left) |
| 10 | 15 | High Beam Headlight (Left) |
| 11 | 10 | Headlamp Washers, Headlight Beam-Length Adjustment |
| 12 | ? | 1997-1999: Spotlights |
| 13 | 15 | Autochecking of Headlights |
| 14 | 10 | A/C Compressor, Car Alarm Siren |
| 15 | 30 | 1997-1999: Radiator Fan |
| 40 | 2000-2001: Right Radiator Fan | |
| 16 | 10 | 2.0t, 2.3t: Vacuum Pump |
| 17 | - | - |
| 18 | - | - |
| R1 | Washer Fluid Pump | |
| R2 | Low Beam Headlight (Dipped Beam) | |
| R3 | High Beam Headlight (Main Beam) | |
| R4 | 1997-1999: Extra Lights | |
| R5 | Horn | |
| R6 | 2.0t, 2.3t: Vacuum Pump | |
| R7 | Rear Intermittent Wiper | |
| R8 | Radiator Fan (Low Speed) | |
| R9 | Left Radiator Fan (High Speed) | |
| R10 | A/C Compressor | |
| R11 | Fog Lights | |
| R12 | Headlamp Wipers (Parking Position) | |
| R13 | Windshield Wipers (Intermittent Function) | |
| R14 | Right Radiator Fan (High Speed) | |
| R15 | Autochecking of Headlights | |
Advertisements
Diagram 2002-2009
| № | A | Protected Component |
|---|---|---|
| 1 | 40 | Radiator Fan (High Speed) |
| 2 | 60 | 2002-2004: ABS/TCS/ESP |
| 40 | 2005-2009: ABS/ESP | |
| 3 | 30 | 2005-2009: ABS/ESP |
| 4 | 7.5 | Load Angle Sensor (with Xenon Headlights) |
| 5 | 15 | Auxiliary Heater |
| 6 | 10 | A/C Compressor, Car Alarm Siren |
| 7 | 15 | Autochecking of Headlights, Headlamp Flasher |
| 8 | - | - |
| 9 | 20 | Headlight Washers |
| 10 | 15 | High Beam Headlight (Left) |
| 11 | 15 | Low Beam Headlight (Left) |
| 12 | 15 | High Beam Headlight (Right) |
| 13 | 15 | Low Beam Headlight (Right) |
| 14 | 30 | Radiator Fan (High Speed) |
| 15 | 15 | Fog Lights (Front Spoiler) |
| 16 | 30 | Rear Window Wiper, Headlamp Washer Pump |
| 17 | 15 | Horn |
| 1 | Autochecking of Headlights, Headlamp, High Beam Flasher | |
| 2 | Headlight Washer | |
| 3 | Front Fog Lights | |
| 4 | Rear Window Wiper | |
| 5 | Auxiliary Heater | |
| 6 | - | |
| 7 | Rain Sensor | |
| 8 | Radiator Fan (Low Speed) | |
| 9 | Radiator Fan (High Speed) | |
| 10 | A/C Compressor | |
| 11 | Right Radiator Fan (High Speed) | |
| 12 | Horn | |
| 13 | Extra Lights (Spotlights) | |
| 14 | High Beam Headlight | |
| 15 | Low beam Headlight | |
| 16 | - | |
| 17 | Windshield Wipers | |
Fusible Link Block
The Maxi fuses are housed in the fuse box under the hood.
These fuses can be checked in the same way as the other fuses. The Maxi fuses are designed to protect the car’s electrical system from being damaged. Each Maxi fuse protects a number of electrical circuits and functions and therefore has a higher rating (amperage) than the standard fuses. No spare Maxi fuses are supplied with the car.
| № | A | Circuit Protected |
|---|---|---|
| 1 | 60 | +30 Supply |
| 2 | 60 | +30 Supply |
| 3 | 60 | +30 Supply |
| 4 | 60 | Ignition Switch, +30 Voltage, +15 Voltage, +54 Voltage, +X Voltage, +B Voltage |
| 5 | 60 | Ignition Switch Relay, +54 Voltage |
Advertisements