Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Mitsubishi Pajero, Montero, Shogun (1991, 1992, 1993, 1994, 1995, 1996, 1997, 1998, 1999).
Checking and Replacing Fuses
To prevent damage to the electrical system from short-circuiting or overloading, each individual circuit is equipped with a fuse.
Use the fuse location diagrams and the matching tables, to check the fuse that is related to the problem. Look through the clear side of the fuse to see if the metal wire inside is separated. If it is, the fuse is blown and should be replaced. Use a fuse puller (located in the passenger compartment fuse block lid) to remove the fuses. Clamp it on the fuse you wish to remove, and pull the fuse straight out from the fuse block. Insert a new fuse of the same capacity securely into the appropriate slot.
If the fuse is not blown, something else must be causing the problem. Have the system inspected by your authorized Mitsubishi Motors dealer or a repair facility of your choice
Notice
- Before replacing a fuse, always turn off the electrical item concerned to the fuse and turn the ignition switch to the “LOCK” position or put the operation mode in OFF.
- Do not repair fuses and never use a fuse with a capacity greater than the one listed or any substitute, such as wire, foil, etc. This would cause the circuit wiring to heat up and could cause a fire.
- If the replacement fuse blows again after a short time, have the electrical system checked by an authorized Mitsubishi Motors dealer or a repair facility of your choice to find and correct the cause.
Instrument Panel Fuse Box Diagram
The fuse block is located behind the lid in the instrument panel.
E. Intermittent Wiper Relay (Built-in Column Switch).
F. 4WD Indicator Relay or ABS Power Relay.
G. Engine Oil Level Relay / Engine Control Relay.
Engine Control Relay / Fuel Pump Relay.
H. RHD: Overdrive Control Relay.
I. LHD: Overdrive Control Relay.
J. Fuse Box.
K. Relay Box.
L. LHD: Headlamp Washer Relay / Wiper Deicer Relay.
M. RHD: Headlamp Washer Relay / Wiper Deicer Relay / Dim-Dip Lamp Relay №1-2-3.
Advertisements
Fuse Box Diagram
| № | A | Protected Component |
|---|---|---|
| 1 | 20 | Rear A/C Control Unit |
| 2 | 10 | Overdrive Control Relay, ELC-4 A/T Control Unit, Autocruise Control Uniе |
| 3 | 10 | DRL Control Unit, Blower Relay, Rear Heater Relay, Headlamp Washer Relay, Defogger Relay, Wiper Deicer Timer, Car Telephone |
| 4 | 10 | Radio, Clock, Accessory Socket Relay, Auto-Cruise Control Unit, Data Link Connector |
| 5 | 15 | Cigarette Lighter, Remote Control Mirror, Accessory Socket Relay |
| 6 | 15 | Door Lock Control Unit, Door Lock Relay |
| 7 | 10 | Variable Shock Absorber Control Unit, ABS Control Unit, 4WD Indicator Control Unit, 4WD Indicator Relay, Overdrive Relay, Variable Shock Absorber Control Unit, ABS Power Relay, Combination Mete |
| 8 | 10 | Power Window Relay, Heated Seat |
| 9 | 15 | Wiper and Washer, Rear Wiper & Washer, Sunroof |
| 10 | 10 | Horn, Auto-Cruise Control Unit, Rear Fog Lamp Relay, Dim-Dip Lamp Relay, DRL Relay |
| 11 | 10 | Combination Meter, Motor Antenna Control Unit, Lighting Monitor Buzzer, Warning Lamp |
| 12 | 10 | Turn-Signal Lamp, Hazard Lamp, SRS Diagnosis Unit |
| 13 | 10 | Rear Heater Blower Motor |
| 14 | 15 | Accessory Socket Relay |
| 15 | 20 | Sunroof |
| 16 | 25 | Blower Motor |
| 17 | 15 | Stop Lamp, ABS, Auto-Cruise Control System |
| 18 | 15 | Back-Up Lamp, Rear Differential Lock Control Unit, SRS Diagnosis Unit |
| 10 | Back-Up Lamp, Rear Differential Lock Control Unit | |
| 19 | 10 | Engine Control Unit, ELC-4 A/T Control Unit, Room Lamp, Map Lamp, Cargo Space Lamp, Combination Meter, Radio, Clock, Door Lock Control Unit, Auto-Cruise Control Unit, ABS Control Unit, SRS Diagnosis Unit, Multi-Meter, Combination Meter, Car Telephone, Ignition Key Illumination Light Timer |
| R1 | Accessory Socket | |
| R2 | Blower Motor | |
Passenger Compartment Relay Box
| № | A | Protected Component |
|---|---|---|
| 1 | 15 | Sunroof |
| 2 | 20 | Defogger |
| 15 | LHD: Fog Lamp | |
| R1 | - | |
| R2 | Rear Heater | |
| R3 | Power Window | |
| R4 | Door Lock Control | |
| R5 | Defogger | |
| R6 | Rear Intermittent Wiper | |
| R7 | Turn and Hazard Flasher | |
Advertisements
Engine Compartment Fuse Box Diagram
A. ABS Motor Relay, ABS Valve Relay.
B. 1991 (Super Quick Glow): Glow Plug Relay №1 / Glow Plug Relay №2 / Condenser Fan Motor Relay / Starter Relay.
1991 (Auto Glow): Glow Plug Relay / Condenser Fan Motor Relay / Starter Relay.
Diesel (1993): A/C Compressor Capacity Control Relay / Glow Plug Relay / Condenser Fan Motor Relay / Starter Relay.
C. Fuse Box.
D. Horn Relay (1993) / Daytime Running Lamp Relay №1-2 / Daytime Running Lamp Control Unit / Condenser Fan Motor Relay (1991).
Advertisements
Fuse Box Diagram
| № | A | Protected Component |
|---|---|---|
| 1 | 15 | Fuel Line Heater |
| 2 | 10 | A/C Compressor |
| 3 | 25 | Condenser Fan Motor |
| 30 | Diesel (with Dual Air Conditioner): Condenser Fan Motor | |
| 4 | 10 | Rear Fog Lamp, Headlamp (with DRL) |
| 5 | 10 | Tail Lamp, DRL Control Unit, Clock, Headlamp (with DRL), License Plate Lamp, Headlamp Washer |
| 6 | 10 | Tail Lamp, License Plate Lamp, Fog Lamp |
| 15 | Tail Lamp, Fog Lamp (RHD) | |
| 7 | 10 | Upper Beam Indicator |
| 8 | 10 | Hazard Lamp |
| 9 | 60 | A/C, Fuse (Passenger Compartment): "1", "6", "13", "14", "16", "17", "19" |
| 10 | 100 | Alternator |
| 11 | 20 | MPI System, Immobilizer System or Intercooler Fan |
| 12 | 40 | Ignition Switch and Starting Circuit, Horn |
| 13 | - | - |
| 14 | 30 | Defogger, Door Mirror Heater, Wiper Deicer |
| 15 | 30 | Power Window, Power Seat |
| 16 | - | - |
| 17 | 30 | Condenser Fan Motor |
| 18 | 40 | Alternator, Headlamp Relay, Tail Lamp Relay |
| R1 | Rear Fog Lamp | |
| R2 | Tail Lamp | |
| R3 | Condenser Fan Motor | |
| R4 | A/C Compressor | |
| R5 | Headlamp | |
| R6 | Intercooler Fan Motor | |
| R7 | Alternator | |
Fuse Box №2
| № | A | Protected Component |
|---|---|---|
| 1 | 60 | ABS Circuit (Hydraulic Unit Power Source) |
| 2 | 20 | 1991-1993: ABS Control Unit, ABS Power Relay |
| 3 | 80 | Glow Control Circuit |
Advertisements