Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses Mercury Villager (1999, 2000, 2001, 2002).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical components in the vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Check the appropriate fuses before replacing any electrical components. A blown fuse can be identified by a break in the wire within the fuse.
Notice
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse.
- Even after a fuse is replaced, it will continue to blow if the cause of the overload is not identified and corrected. If the fuse continues to blow, have the vehicle’s electrical system checked by your dealer or a qualified service technician.
Instrument Panel Fuse Box
The fuse panel is located to the left of the steering wheel. Remove the panel cover to access the fuses. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
| № | Fuse | A | Description |
|---|---|---|---|
| 1 | Corner Lamps | 10 | Front Exterior Lamps |
| 2 | Heated Seat | 7.5 | Heated Seats |
| 3 | I/P Ilium | 7.5 | Interior Panel Illumination Lamps |
| 4 | Electron | 10 | Transaxle Control Module (TCM), Electronic Automatic Temperature Control (EATC) Module, Instrument Cluster, Rear Wiper Motor Assembly |
| 5 | Tail Lamp | 10 | Rear Exterior Lamps |
| 6 | Air Bag | 10 | Airbag Diagnostic Monitor |
| 7 | Audio | 10 | Radio, Rear Radio Control, CD Changer |
| 8 | Eng Cont | 10 | Powertrain Control Module, Oxygen Sensors |
| 9 | Room Lamp | 15 | Interior Lamps |
| 10 | Mirror | 7.5 | Smart Entry Control (SEC), Power Mirror Switch |
| 11 | Stop Lamp | 20 | Brake Pedal Position (BPP) Switch, Trailer Tow Control Unit |
| 12 | Cigar Lighter | 20 | Cigar Lighter |
| 13 | Hazard | 10 | Hazard Warning Flasher Switch, Anti-Theft Indicator |
| 14 | RR Pwr Plug | 20 | Rear Powerpoint |
| 15 | Rear Blower | 15 | Rear Blower Motor Relay, Rear Blower Motor |
| 16 | Wiper | 20 | Front Wiper/Washer Assembly |
| 17 | Rear Blower | 15 | Rear Blower Motor Relay, Rear Blower Motor |
| 18 | Rear Wiper | 10 | Rear Wiper/Washer Assembly |
| 19 | O2 Sensor | 7.5 | Oxygen Sensor |
| 20 | Audio | 7.5 | 1999-2000: Radio |
| Audio/Video | 15 | 2001-2002: Radio/Video System | |
| 21 | Turn | 10 | Hazard Warning Flasher Switch |
| 22 | Audio Amp | 20 | Subwoofer Amplifier |
| 23 | Front Blower | 20 | Front Blower Motor, Front Blower Motor/Speed Controller |
| 24 | Eng Cont | 7.5 | Powertrain Control Module, Lighting Control Module |
| 25 | Relays | 10 | Speed Control, Instrument Cluster, Rear Blower Motor, Data Link Connector #2, Cooling Fans |
| 26 | A/C Cont | 7.5 | Electronic Automatic Temperature Control (EATC) Module, A/C Relay, Front Climate Control Panel |
| 27 | Electron | 10 | Transmission Control, Lighting Control Module, ABS Control Module, Smart Entry Control (SEC)/Timer Module |
| 28 | Rear Defog | 20 | Rear Window Defrost |
| 29 | Front Blower | 20 | Front Blower Motor, Front Blower Motor/Speed Controller |
| 30 | Rear Defog | 20 | Rear Window Defrost |
| 31 | — | — | Not Used |
| 32 | Heated Mirror | 10 | Rear Window Defrost Switch, Power/Heated Mirrors |
Advertisements
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | Fuse | A | Description |
|---|---|---|---|
| 1 | FOG LAMP | 7.5 | 2001-2002: Fog Lamps |
| 2 | FUEL PUMP | 15 | Fuel Pump Relay |
| 3 | INJ | 10 | Powertrain Control Module (PCM), Injectors |
| 4 | SEC | 7.5 | Anti-Theft Relay, Smart Entry Control (SEC)/Timer Module |
| 5 | RAD | 7.5 | Radiator Fan Sensing |
| 6 | ECCS | 10 | Data Link Connector (DLC) #1, PCM Power Relay |
| 7 | — | — | Not Used |
| 8 | — | — | Not Used |
| 9 | ALT | 10 | Generator |
| 10 | ABS | 20 | ABS Control Module |
| 11 | — | — | Not Used |
| 12 | H/L RH | 15 | Lighting Control Module |
| 13 | HORN | 15 | Horn Relay |
| 14 | — | — | Not Used |
| 15 | H/L LH | 15 | Lighting Control Module |
| 16 | — | — | Not Used |
| 17 | — | — | Not Used |
| 18 | ABS | 40 | ABS Control Module |
| 19 | — | — | Not Used |
| 20 | PWR WND | 30 | Power Window Relay, Smart Entry Control (SEC)/Timer Module, Power Seats |
| 21 | RAD FAN LO | 20 | Low Speed Fan Control Relay |
| 22 | — | — | Not Used |
| 23 | IGN SW | 30 | Ignition Switch |
| 24 | — | — | Not Used |
| 25 | RAD FAN | 75 | High Speed Fan Control Relay |
| 26 | FR BLW | 65 | Front Blower Motor Relays |
| 27 | RR DEF | 45 | Rear Window Defroster Relay |
| 28 | ALT | 140 | Accessory Relay, Ignition Relay, Tail Lamp Relay, Fuse Junction Panel |
| 29 | MAIN | 100 | Generator |
Relay Box
The relay box is located in the engine compartment in front of the battery.
| № | Relay |
|---|---|
| 1 | Start Inhibit |
| 2 | Fuel Pump |
| 3 | Bulb Check |
| 4 | 1999-2000: Speed Control Hold |
| 2001-2002: Fog Lamp | |
| 5 | Anti-theft |
| 6 | Horn |
| 7 | A/C |
Advertisements