Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Mercury Sable GS and LS (2000, 2001, 2002, 2003, 2004, 2005).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical components in the vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Check the appropriate fuses before replacing any electrical components. A blown fuse can be identified by a break in the wire within the fuse.
Notice
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse.
- Even after a fuse is replaced, it will continue to blow if the cause of the overload is not identified and corrected. If the fuse continues to blow, have the vehicle’s electrical system checked by your dealer or a qualified service technician.
Passenger Compartment Fuse Box Diagram
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
| № | A | Protected Circuits |
|---|---|---|
| 7 | 40 | 2000-2003: Rear Defrost |
| 20 | 2004-2005: Rear Defrost | |
| 8 | 40 | Blower Motor |
| 10 | 30 | Circuit Breaker: Power Seats, Delayed Accessory, Adjustable Pedals (2000-2004) |
| 11 | 15 | 2000-2003: Integrated Control Panel (ICP), Rear Washer Wiper Control, Front Washer, Cell Phone, Passenger Switch Illumination, GEM, Rear Wiper Motor |
| 10 | 2004-2005: Right Headlamp | |
| 12 | 10 | 2000-2003: Heated Mirrors, Rear Defrost Switch |
| 15 | 2004-2005: Highbeam Headlamps | |
| 13 | 20 | 2000-2003: Cigar Lighter, Auxiliary Power Point (2000) |
| - | 2004-2005: - | |
| 14 | - | - |
| 15 | 30 | 2000-2003: Front Wiper Motor |
| 10 | 2004-2005: Left Headlamp | |
| 16 | 15 | 2000-2003: Flasher and GEM Power, Integrated Control Panel (ICP) Power, RCC Memory, Cluster |
| 10 | 2004-2005: Foglamps | |
| 17 | 15 | Stop Lamp, Speed Control Deactivating Switch |
| 18 | 15 | 2000-2003: - |
| 2004-2005: Parklamps, PWM (Backlighting), Autolamps | ||
| 19 | 10 | 2000-2003: - |
| 2004-2005: Heated Mirrors, Rear Defrost Switch Indicator | ||
| 20 | 10 | 2000-2003: - |
| 2004-2005: Restraints (Air Bag Module/OCS Module) | ||
| 21 | 15 | 2000-2003: - |
| 2004-2005: Transmission Range Sensor (Transmission Position Switch) | ||
| 22 | 20 | 2000-2003: Deck Lid Release Solenoid, Lock/Unlock Relays |
| 15 | 2004-2005: Front Washer Pump, Electrochromatic Mirror, Compass, Cluster (RUN/ACC), Integrated Control Panel (ICP) logic, Rear Wiper (Wagon Only), Rear Washer (Wagon Only) | |
| 23 | 10 | 2000-2003: Air Bag Module, PATS Transceiver |
| 30 | 2004-2005: Front Wiper Motor | |
| 24 | 15 | 2000-2003: Foglamps, Transit Relay (2000-2002) |
| 2004-2005: - | ||
| 25 | 2 | 2000-2003: PCM relay, Fuel pump relay (2002-2003) |
| 20 | 2004-2005: Power Point | |
| 26 | 10 | 2000-2003: Mirrors, Power Antenna, Pulse Stretcher Module, Deck Lid Lamp, Battery Saver |
| 20 | 2004-2005: Power Locks, Liftgate (Wagon)/Trunk (Sedan) Release | |
| 27 | 10 | 2000-2003: Gauges and Warning Lamps, Integrated Control Panel (ICP), FFV Sender, GEM |
| 2004-2005: Anti-lock Brake System (ABS), Speed Control, Traction Control, Brake-shift Interlock, A/C Function Switch (Manual A/C Only), Temperature Blend Door (Manual A/C Only), Defrost Coil | ||
| 28 | 10 | 2000-2003: Blower Motor Relay Coil, EATC Logic, Puddle Lamps (2002-2003) |
| 15 | 2004-2005: Turn Signals, Back-up Lamps | |
| 29 | 15 | 2000-2003: Autolamps, Park Lamps (2002-2003), PWM (2002-2003), Headlamp Switch |
| 20 | 2004-2005: Cigar lighter | |
| 30 | 15 | 2000-2003: Horns and Horn Switch, OBD II Connector |
| 10 | 2004-2005: Courtesy Lighting, Battery Saver, Power Mirrors, Decklid Lamp, Power Antenna (Wagon Only), Pulse Stretching Module (Wagon Only) | |
| 31 | 10 | 2000-2003: - |
| 2004-2005: Blower Motor Relay Coil, Electronic Automatic Temperature Control (EATC) Logic, Puddle Lamp Relay Coil | ||
| 32 | 10 | 2000-2003: ABS, DRL Relay Coil, Speed Control Actuator, Traction Control Switch, AC Heater Selector Switch, Blend Door Actuator, Brake Shift Interlock, Rear Defroster Relay Coil (2002-2003) |
| 2004-2005: Cluster, Flex Fuel Module, ICP Logic, Passive Anti-theft Module (GEM power), Compass | ||
| 33 | 15 | 2000-2003: - |
| 2004-2005: Hazard Flasher, Cluster Power, ICP Power, EATC | ||
| 34 | 5 | 2000-2003: - |
| 2004-2005: GEM Logic | ||
| 35 | 10 | 2000-2003: - |
| 2004-2005: Backlighting, Ashtray Light (2005) | ||
| 36 | 15 | 2000-2003: Turn Signals, Back-up Lamps |
| 2 | 2004-2005: Powertrain Control Module (PCM) Relay, Fuel Pump Relay, A/C Clutch | |
| 37 | 15 | 2000-2003: Transmission Position Switch |
| 25 | 2004-2005: Autolamp, Daytime Running Lamps (DRL), Flash-to-pass, Headlamp switch | |
| 38 | 5 | 2000-2003: GEM Park Neutral Switch |
| 15 | 2004-2005: Horn, Diagnostic Connector (OBD II) | |
| 39 | - | - |
| 40 | - | - |
| 41 | - | - |
| 42 | - | - |
| 1 | Accessory Delay | |
| 2 | Driver One Touch Down | |
| 3 | Blower Motor | |
| 4 | Flasher | |
| 5 | - | |
| 6 | - | |
| 9 | Rear Defrost | |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Protected Circuits |
|---|---|---|
| 1 | 60 | Fuse Junction Panel |
| 2 | 30 | Powertrain Control Module (PCM) Relay |
| 3 | 60 | Fuse Junction Panel |
| 4 | 10 | 2000-2003: - |
| 2004-2005: | ||
| Circuit Breaker: Low Speed Cooling Fan | ||
| 5 | 40 | 2000-2003: - |
| 2004-2005: Cooling Fan (Main) | ||
| 6 | - | - |
| 7 | 40 | Starter Relay, Ignition Switch |
| 8 | 20 | 2000-2002: Transit Relay (Export Only), Rear Foglamps |
| 2003-2005: - | ||
| 9 | 40 | 2000-2003: Cooling Fan Relays |
| 20 | 2004-2005: Cooling Fan (Passenger Side) | |
| 10 | 20 | 2000-2003: - |
| 2004-2005: Cooling Fan (Driver Side) | ||
| 11 | 20 | 2000-2001: Thermactor Relay (FFV only) |
| 2002: - | ||
| 50 | 2003-2005: | |
| Sedan: Rear Defrost | ||
| 12 | - | - |
| 13 | 40 | Anti-Lock Brake Module Pump Feed |
| 14 | - | - |
| 15 | 20 | Anti-Lock Brake Module Valve Solenoid |
| 16 | 20 | Fuel Pump Relay |
| 17 | 20 | 2000-2001: Rear Control Unit, CD Changer, Cell Phone |
| 2002-2003: Cell Port | ||
| 2004-2005: CD | ||
| 18 | - | 2000: - |
| 20 | 2001-2003: Cigar Lighter | |
| 10 | 2004-2005: | |
| Vulcan: A/C clutch relay, PCM keep alive power | ||
| Duratec: - | ||
| 19 | 15 | 2000-2003: Right Headlamp |
| 2004-2005: - | ||
| 20 | - | - |
| 21 | 15 | 2000-2003: Left Headlamp |
| 2004-2005: - | ||
| 22 | 10 | Duratec: A/C Clutch Relay, PCM Keep Alive Power |
| 5 | Vulcan: Heated PCV valve | |
| 26 | 30 | 2000: Generator |
| 10 | 2001-2005: Generator | |
| 27 | 5 | Rear Control Unit, Antenna |
| 28 | 15 | HEGO Sensor Transmission Shift Solenoid, Canister Vent, A/C Clutch Relay, Thermactor Bypass Solenoid (2000-2001) |
| 23 | Starter Motor | |
| 24 | Low Speed Fan | |
| 25 | Wiper Speed | |
| 29 | Wiper Park | |
| 30 | Fuel Pump | |
| 31 | PCM Power | |
| 32 | High Speed Fan | |
| 33 | A/C Clutch | |
Advertisements