Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Mercury Cougar & Ford Cougar (1999, 2000, 2001, 2002, 2003, 2004, 2002).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical components in the vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Check the appropriate fuses before replacing any electrical components. A blown fuse can be identified by a break in the wire within the fuse.
Notice
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse.
- Even after a fuse is replaced, it will continue to blow if the cause of the overload is not identified and corrected. If the fuse continues to blow, have the vehicle’s electrical system checked by your dealer or a qualified service technician.
Location
Passenger Compartment Fuse Box
The fuse panel is located on the driver’s side under the dashboard. To check or replace a fuse or a relay, open the fuse box by pulling down the lock release lever (1).
| № | A | Protected components |
|---|---|---|
| 19 | 7.5 | Mirror heater |
| 20 | 10 | Wipers |
| 21 | 40 | Power moonroof, Power windows |
| 22 | 7.5 | ABS/TCS |
| 23 | 15 | Turn signal lamps, Backup lamps, Speed control. Gearshift lever, A/C clutch, Blower motor, Bulb outage module (1999-2000) |
| 24 | 15 | Stop lamps, Speed control |
| 25 | 20 | Alarm system, Locking system |
| 26 | 7.5 | High beam, Low beam |
| 27 | 15 | Cigar lighter |
| 28 | 30 | Power seats |
| 29 | 30 | Rear window defroster |
| 30 | 7.5 | Engine management, Locking system, Instrument cluster |
| 31 | 7.5 | Panel dimmer, License plate lamps, Glove box lamp, Belt minder module (2001-2002) |
| 32 | - | - |
| 33 | 7.5 | Left-side lamps |
| 34 | 7.5 | Power mirrors, Clock, Interior lamps |
| 35 | 7.5 | Right-side lamps |
| 36 | 15 | Radio |
| 37 | 30 | Heater blower, Air conditioning |
| 38 | 7.5 | Air bags |
| R12 | Courtesy lamps | |
| R13 | Rear window defrost | |
| R14 | Blower motor | |
| R15 | Front wiper | |
| R16 | Ignition | |
| D2 | Reverse voltage protection | |
Advertisements
Engine Compartment Fuse Box
The power distribution box is located on the driver’s side of the engine compartment. To check or replace a fuse or a relay, remove the cover of the fuse box by releasing the latch (1) and lifting up.
| № | A | Protected components |
|---|---|---|
| 1 | - | - |
| 2 | 15 | 2001-2002: Alternator |
| 7.5 | 1999-2000: Alternator | |
| 3 | 20 | Fog lamps |
| 4 | - | - |
| 5 | - | - |
| 6 | 3 | Engine management |
| 7 | 20 | Hazard lamps, Horn, Multi-function switch |
| 8 | - | - |
| 9 | 15 | Fuel pump |
| 10 | - | - |
| 11 | 20 | Engine management (1999-2000), Ignition (1999-2000), Daytime running lamps |
| 12 | - | - |
| 13 | 20 | HEGO sensors |
| 14 | - | - |
| 15 | 7.5 | Right low beam |
| 16 | 7.5 | Left low beam |
| 17 | 7.5 | Right high beam |
| 18 | 7.5 | Left high beam, Instrument cluster, Front fog lamps |
| 39 | - | - |
| 40 | 20 | Ignition, Engine management (2001-2002), Starting (1999), Headlamp switch (1999-2000) |
| 41 | 20 | Engine management |
| 42 | 40 | Heater blower |
| 43 | - | - |
| 44 | - | - |
| 45 | 60 | Main power supply to vehicle electrical supply (Ignition relay) |
| 46 | - | - |
| 47 | - | - |
| 48 | - | - |
| 49 | 60 | Engine cooling fan |
| 50 | - | - |
| 51 | 60 | ABS |
| 52 | 60 | Timer module, Courtesy lamp, Rear window defrost, Fuses 25, 27, 28, 34 and 36 |
| R1 | Fuel pump | |
| R2 | Engine management | |
| R3 | Air conditioning | |
| R4 | Low beam | |
| R5 | High beam | |
| R6 | Horn | |
| R7 | Starter | |
| R8 | High speed engine cooling fan | |
| R9 | Engine cooling fan | |
| R10 | - | |
| R11 | Daytime running lamps | |
| D1 | 2000-2002: Starter relay | |
| 1999: Reverse voltage protection | ||
| D2 | Air conditioning | |
Advertisements