Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Lincoln Zephyr (MKZ) (2005, 2006).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical components in the vehicle are not working, a fuse may have blown. Check the appropriate fuses before replacing any electrical components.
Look carefully at the fuse – a broken wire within the fuse identifies blown fuses. If you are not sure or if it is too dark to see, try replacing the suspected fuse with one of the same value that you know is good.
In case if you do not have a spare fuse, in an emergency you can pull out fuses, which may be dispensable for normal driving (for example, audio system, cigarette lighter, OBD, seat heater, and the like), and use it if its amperage rating is the same.
Notice
- Always switch off the ignition system and the affected electrical circuit before replacing a fuse.
- Always disconnect the battery before servicing high current fuses.
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
- If the replaced fuses blows again – contact a qualified and equipped service center.
Passenger Compartment Fuse Box Diagram
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses.
| № | A | Circuit Protected |
|---|---|---|
| 1 | 10 | Backup lamps, Electrochromatic mirror |
| 2 | 20 | Horns |
| 3 | 15 | Battery saver: Interior lamps, Puddle lamps, Trunk lamp, Glove box lamp, Rear power windows |
| 4 | 15 | Parklamps, License plate lamps |
| 5 | - | - |
| 6 | - | - |
| 7 | - | - |
| 8 | 30 | Rear window defroster |
| 9 | 10 | Heated mirrors |
| 10 | 30 | Starter coil, PCM |
| 11 | 15 | High beams |
| 12 | 7.5 | Delay accessories: Radio head units, Moonroof, Front power windows, Electrochromatic mirrors |
| 13 | 7.5 | Cluster, KAM-PCM, Analog clock, Climate control head units, Canister vent solenoid |
| 14 | 15 | Washer pump |
| 15 | 20 | Cigar lighter |
| 16 | 15 | Door lock actuator, Decklid lock solenoid |
| 17 | 20 | Subwoofer, THXII DSP module |
| 18 | 20 | Radio head units, OBDII connector |
| 19 | - | - |
| 20 | 7.5 | Power mirrors, DSP (THX/Navigation radio) |
| 21 | 7.5 | Stop lamps |
| 22 | 7.5 | Audio |
| 23 | 7.5 | Wiper relay coil, Cluster logic |
| 24 | 7.5 | OCS (Passenger's seat), PAD indicator |
| 25 | 7.5 | RCM |
| 26 | 7.5 | PATS Transceiver, Brake shift interlock solenoid, Brake pedal switch |
| 27 | 7.5 | Cluster, Climate control head units |
| 28 | 10 | ABS/Traction Control, Heated seats, Compass |
| C/B | 30 | Circuit Breaker: Rear power windows, Delayed accessory (SJB fuse 12) |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Circuit Protected |
|---|---|---|
| 1 | 60 | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 40 | Powertrain power |
| 3 | - | - |
| 4 | 40 | Blower motor |
| 5 | - | - |
| 6 | 40 | Rear window defroster, Heated mirrors |
| 7 | - | - |
| 8 | - | - |
| 9 | 20 | Wipers |
| 10 | 20 | ABS Valves |
| 11 | 30 | Heated seats, Passenger heated/cooled seat |
| 12 | 30 | Driver heated/cooled seat |
| 13 | - | - |
| 14 | 15 | Ignition switch |
| 15 | 10 | Memory module logic |
| 16 | 15 | Transmission |
| 17 | 20 | Console power point |
| 18 | 10 | Alternator sense |
| 19 | 40 | Logic feed to SJB (solid state devices) |
| 20 | 20 | THXII Amplifier #1 |
| 21 | 20 | THXII Amplifier #2 |
| 22 | - | - |
| 23 | 60 | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C Compressor clutch |
| 26 | 15 | LH HID Low beam |
| 27 | 15 | RH HID Low beam |
| 28 | - | - |
| 29 | 60 | Engine cooling fan |
| 30 | 30 | Fuel pump relay feed |
| 31 | 30 | Passenger power seat |
| 32 | 30 | Driver power seat |
| 33 | 20 | Moonroof |
| 34 | 30 | Driver Smart power window |
| 35 | 30 | Passenger Smart power window |
| 36 | 40 | ABS Pump |
| 37 | - | - |
| 38 | - | - |
| 39 | - | - |
| 40 | - | - |
| 41 | - | - |
| 42 | 15 | PCM non-emission related |
| 43 | 15 | Coil on plug |
| 44 | 15 | PCM emission related |
| 45 | - | - |
| 46 | 15 | Injectors |
| 62 | - | Circuit Breaker: Spare |
| 60 | Fuel pump | |
| 61 | - | |
| 47 | Fog lamps | |
| 48 | LH HID Low beam | |
| 49 | RH HID Low beam | |
| 50 | Wiper Park | |
| 51 | A/C Clutch | |
| 52 | - | |
| 53 | Wiper RUN | |
| 54 | - | |
| 55 | Fuel pump | |
| 56 | Blower motor | |
| 57 | PCM | |
| 58 | - | |
| 59 | - | |
Advertisements