Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Lincoln LS (1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical components in the vehicle are not working, a fuse may have blown. Check the appropriate fuses before replacing any electrical components.
Look carefully at the fuse – a broken wire within the fuse identifies blown fuses. If you are not sure or if it is too dark to see, try replacing the suspected fuse with one of the same value that you know is good.
In case if you do not have a spare fuse, in an emergency you can pull out fuses, which may be dispensable for normal driving (for example, audio system, cigarette lighter, OBD, seat heater, and the like), and use it if its amperage rating is the same.
Notice
- Always switch off the ignition system and the affected electrical circuit before replacing a fuse.
- Always disconnect the battery before servicing high current fuses.
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
- If the replaced fuses blows again – contact a qualified and equipped service center.
Passenger Compartment Fuse Box Diagram
The fuse panel is located on the right-hand side kick panel. Remove the panel cover to access the fuses. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
| № | A | Circuit Protected |
|---|---|---|
| 1 | 5 | Starter relay coil |
| 2 | 5 | Radio |
| 3 | 5 | ABS/TCS/AdvanceTrac® |
| 4 | 5 | Cluster, Powertrain Control Module (PCM) relay, Fuel pump relay, REM |
| 5 | 10 | 2003-2006: Restraints Control Module (RCM), Passenger Occupant Detection System (PODS) electronic control unit |
| 5 | 2000-2002: T/A switch, O/D cancel switch, Autolamp sensor, Heated seat modules, VCS (2002) | |
| 6 | 10 | OBD II |
| 7 | 5 | DDM, DSM, Anti-theft LED, Power mirror switch, Electric Park Brake switch, PCM (2000-2001), Security horn |
| 8 | 5 | Right front turn, Right front sidemarker, Right front park lamps, Right front repeater (2000-2003) |
| 9 | 15 | 2003-2006: Right front low beam/HID |
| 10 | 2000-2002: Right front low beam | |
| 10 | 5 | Left front turn, Left front sidemarker, Left front park lamps, Left front repeater (2000-2003) |
| 11 | 10 | Left front high beam |
| 12 | 5 | 2003-2006: Electrochromic mirror, Rain sensor (2003) |
| 2002: Headlamp leveling | ||
| 10 | 2000: Headlamp leveling | |
| 13 | 5 | Cluster |
| 14 | 5 | 2003-2006: DATC |
| 10 | 2000-2002: RCM, DATC | |
| 15 | 5 | 2000-2002: Spare |
| 2003-2006: O/D cancel, ABS/Traction-Assist switch | ||
| 16 | 5 | Heated seat controls, Climate control seat module (2003-2006), Electrochromic mirror (2000-2002), Rain sensor module (2000-2002) |
| 17 | 5 | RCM, Alternator warning lamp |
| 18 | 20 | Radio, CIA, Navigation unit (2003-2006) |
| 19 | 15 | Tilt/Tele motors |
| 20 | 10 | FEM, DATC, Cluster, REM, Brake shift interlock (2000-2002) |
| 21 | 10 | 2000-2002: Power folding mirrors |
| 7.5 | 2003-2006: Spare | |
| 22 | 10 | DDM, Driver door mirror (2002-2006) |
| 23 | 10 | Right front high beam |
| 24 | 5 | PATS |
| 25 | 15 | 2003-2006: Left front low beam/HID |
| 10 | 2000-2002: Left front low beam | |
| 26 | 5 | 2003-2006: Wiper module |
| 10 | 2001-2002: Wiper relay, Windshield washer | |
| 3 | 2000: Wiper relay | |
| 27 | 10 | Radio, Navigation unit (2003-2006), Cellphone (2000-2002), VCS (2002) |
| 28 | 5 | 2000-2001: Security horn |
| 2002-2006: Not Used (spare) | ||
| 29 | 5 | FEM, Reverse park assist (2003-2006), Trailer tow ignition sense (2000-2001), VEMS (2000-2001) |
| 30 | 5 | FEM, Passenger power mirror (2003-2006) |
| 31 | — | Not used |
| 32 | 20 | Cigar lighter |
| 33 | 10 | Switch backlighting, FEM (2002-2006) |
| 34 | 10 | Spare |
| 35 | 5 | Stop lamp signal |
| R1 | Accessory (cigar lighter, power point) | |
There is a 60A maxi fuse for the electric cooling fan located in a wiring harness behind the front passenger side trim panel under the dash panel. The trim panel must be removed and the carpet on the front passenger side must be lifted to access this fuse. See a qualified technician to have this fuse replaced, if necessary.
Advertisements
Engine Compartment Fuse Box
The front power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Circuit Protected |
|---|---|---|
| 1 | 10 | A/C clutch, Coolant control valve (2003-2006), Auxiliary coolant pump (2003-2006) |
| 2 | 10 | 2000: Windshield washer pump |
| 3 | 15 | Fog lamp |
| 4 | 20 | 2003-2006: Horn |
| 15 | 2000-2002: Horn | |
| 5 | 15 | 2003-2006: Fuel injectors, Electric cooling fan, Mass Air Flow (MAF) sensor |
| 20 | 2000-2002: Fuel injectors | |
| 6 | 15 | Transmission solenoid, EGR (2003-2006) |
| 7 | — | Not used |
| 8 | — | Not used |
| 9 | 5 | 2002: PCM KAPWR |
| 10 | 5 | 2002: IAC Solenoid |
| 11 | 15 | HEGOs |
| 12 | 15 | 2003-2006: Coil-on-plug |
| 10 | 2000-2002: Coil-on-plug | |
| 13 | 30 | Heated wiper park |
| 14 | 30 | ABS module |
| 15 | — | Not used |
| 16 | 30 | Blower motor |
| 17 | 20 | 2000-2002: Thermactor air pump (low emission vehicles only) |
| 18 | 40 | 2000-2002: PCM |
| 19 | 30 | 2003-2006: Electric park brake |
| 20 | 30 | Wiper motor |
| 21 | 30 | Starter solenoid |
| 22 | 40 | 2003-2006: ABS motor |
| 30 | 2000-2002: ABS motor | |
| 23 | — | Not used |
| 24 | — | Not used |
| R01 | 2000-2002: Wiper Hi/Lo | |
| R02 | 2000-2002: Wiper park | |
| R03 | Coil-on-plug and HEGOs | |
| R04 | 2003-2006: Right-hand HID headlamps | |
| 2000: Windshield washer | ||
| R05 | Auxiliary coolant pump | |
| R06 | 2003-2006: Left-hand HID headlamps | |
| 2000-2002: Horn | ||
| R07 | Fog lamps | |
| R08 | A/C clutch | |
| R09 | 2000-2002: Wiper Run/Acc | |
| R10 | Blower motor | |
| R11 | Not used | |
| R12 | Heated wiper park | |
| R13 | 2003-2006: Horn | |
| R14 | PCM power | |
| R15 | Starter motor | |
| D | PCM | |
Advertisements
Luggage Compartment Fuse Box
The rear power distribution box is located in the luggage compartment under the spare tire well cover. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Circuit Protected |
|---|---|---|
| 1 | 15 | Decklid release solenoid, Passenger door lock motors (2002-2006), Steering column lock (2003) |
| 2 | 10 | Right rear turn lamp, License plate lamp (2002-2006) |
| 3 | 5 | Left rear stop/tail lamp |
| 4 | 10 | Fuel door release solenoid, Decklid lamp (2003-2006) |
| 5 | 10 | Courtesy and map lamps, Radio antenna module (2003-2006) |
| 6 | 10 | Left rear turn and back-up lamps |
| 7 | 5 | Right rear stop/tail lamp |
| 8 | 5 | 2003-2006: Center high-mounted stop lamp |
| 10 | 2000-2002: Center high-mounted stop lamp | |
| 9 | 5 | Heated mirror |
| 10 | 20 | 2001-2006: Power point - console |
| 11 | 20 | 2003-2006: Rear heated seats |
| 15 | 2000-2002: Heated seats | |
| 12 | 20 | 2003-2006: Power point - ashtray |
| 5 | 2000-2002: Transit relay | |
| 13 | — | Not used |
| 14 | 10 | 2003-2006: Navigation unit |
| 5 | 2000-2002: Phone, CD, VEMS | |
| 15 | 5 | Alternator sense |
| 16 | 20 | Moonroof |
| 17 | 15 | Fuel pump |
| 18 | 20 | 2000-2006: Subwoofer amp |
| 30 | 2004-2006: THX amp, Subwoofer amp | |
| 19 | 20 | REM - Left rear window |
| 20 | 30 | 2003-2006: Front window motors |
| 20 | 2000-2002: DDM - Driver window | |
| 21 | 20 | Driver lumbar, Power seats |
| 22 | 20 | Ignition switch |
| 23 | 30 | SSP4 |
| 24 | 30 | SSP3 |
| 25 | 40 | P-J/B |
| 26 | 30 | 2003-2006: Climate control seat module |
| 20 | 2000-2002: FEM - Front passenger window | |
| 27 | 30 | SSP1 |
| 28 | 20 | Passenger lumbar, Power seats |
| 29 | 40 | 2003-2006: Rear defroster |
| 30 | 2000-2002: Rear defroster | |
| 30 | 20 | REM - Right rear window |
| 31 | 30 | 2003-2006: Powertrain main power |
| 20 | 2001-2002: Ignition switch (V6 manual trans) | |
| 32 | 30 | SSP2 |
| D01 | Not used | |
| D02 | Fuel pump motor | |
| R001 | SSP1 | |
| R002 | SSP4 | |
| R003 | Rear defroster | |
| R004 | SSP3 | |
| R005 | SSP2 | |
| R006 | Not used | |
| R007 | Fuel pump | |
Advertisements