Kia Sedona, Carnival (2010-2014) Fuse Diagram

Fuse box diagram (fuse layout), location, and assignment of fuses and relays Kia Sedona and Carnival (VQ) (2010, 2011, 2012, 2013, 2014).

Kia Sedona, Carnival (2010-2014)

Checking and Replacing Fuses

A vehicle’s electrical system is protected from electrical overload damage by fuses. If any of your vehicle’s lights, accessories, or controls do not work, check the appropriate circuit fuse. If a fuse has blown, the element inside the fuse will be broken or melted. Check those fuses first that protect the failed component, but check all the fuses before deciding that a blown fuse is not the cause. Replace any blown fuses with another with the same amperage (same color) and check the component’s operation.

Notice

  • Before changing a fuse, check the ignition key has been removed and that all the other electric devices have been turned off/disabled.
  • Do not use a screwdriver or any other metal object to remove fuses because it may cause a short circuit and damage the system.
  • Never replace a fuse with anything but another fuse of the same rating. A higher capacity fuse could cause damage and possibly a fire. Never install a wire or aluminum foil instead of the proper fuse even as a temporary repair. It may cause extensive wiring damage and a possible fire.
  • If the replacement fuse blows, this indicates an electrical problem. Avoid using the system involved and immediately consult at a qualified service center.
  • If you do not have a spare, use a fuse of the same rating from a circuit, you may not need for operating the vehicle, such as the cigarette lighter fuse.

Location

Location

 

* RHD type is symmetrical (#2, #4)

  1. Engine compartment
  2. Driver’s side panel
  3. Rear cargo area panel
  4. ICM relay box
  5. Diesel box

Instrument Panel Fuse Box

The fuse panel is located in the driver’s side panel bolster.

Instrument Panel Fuse Box Location

To check and replace a fuse:

  1. Turn the ignition switch and all other switches off.
  2. Open the fuse panel cover.
  3. Pull the suspected fuse straight out. Use the removal tool provided on the main fuse box in the engine compartment.
  4. Check the removed fuse; replace it if it is blown. Spare fuses are provided in the main fuse box in the engine compartment.
  5. Push in a new fuse of the same rating, and make sure it fits tightly in the clips.

Advertisements

 

Instrument Panel Fuse Box Diagram

FuseACircuit Protected
DDM30Driver Door Module, Safety Power Window Motor
ADM30Passenger Door Module
AUDIO15Audio, Media Module
MEMORY7.5A/C Control Module, Digital Clock (W/O PAB Switch), Instrument Cluster, Trip Computer, Driver/Passenger Door Module Digital Clock & Telltail (With PAB Switch), Front Area Module, Driver Power Seat Module, Power Tail Gate Module Power Sliding Door Module LH/RH
VRS10VRS Switch, VRS Module
IG2-17.5Multifunction Switch, A/C Control Module, Electro Chromic Mirror, Rain Sensor, Relay Box, Front Heater Actuator Assembly
IG2-27.5Rear A/C Control Switch, Front Area Module, Power Tail Gate Module, Power Sliding Door Module LH/RH Driver Power Seat Module (With IMS), Driver Door Module, Passenger Door Module
OBD-II7.5Data Link Connector, Multipurpose Check Connector
ROOM7.5Vanity Lamp LH/RH, Map Lamp, A/C Control Module, Rear Room Lamp Switch, Over Head Console, Electro Chromic Mirror
K/LOCK7.5Key interlock solenoid
ILLUMI7.5Instrument Panel Module
AMP25Amp
SEAT WARMER20Seat Warmer Relay
SUNROOF25Sunroof Module
TPMS7.5Tire pressure monitoring system
PEDAL15Adjust Pedal Relay
P/OUTLET 115Cigarette Lighter & Power Outlet
ASS P/SEAT20Passenger Power Seat Module
DRV P/SEAT30Driver Power Seat Module
ACC7.5Power Outside Mirror Switch, Audio, Digital Clock (W/O PAB Switch), Media Module Digital Clock & Telltail (With PAB Switch)
P/OUTLET 215Cigarette Lighter & Power Outlet
START7.5Burglar Alarm Relay, Transaxle Range Switch (J3 AAT, G6EA A/T), ECM (J3 A/T), Start Relay (D4HB, J3 MAT, G6EA MAT), P/N Relay (G6DC)
AIRBAG IND7.5Instrument Cluster, Digital Clock & Telltail
ENG7.5ATM Lever Switch, Stop Lamp Switch (GSL), Input Speed Sensor (J3/G6EA), Output Speed Sensor (J3/G6EA) Glow Relay Module (D4HB), Transaxle Range Switch, PCM (GSL), Vehicle Speed Sensor (J3/G6EA), ECM (DSL), TCM (DSL) Fuel Filter Heater Relay (D4HB), Fuel Filter Warning Sensor (D4HB), Back-Up Lamp Switch (MAT), Clutch Switch (G6EA) Fuel Filter Warning Switch (J3), Mass Air Flow Sensor (J3), Mass Air Flow Sensor (D4HB)
IG17.5Trip Computer, Rheostat, ESP OFF Switch, Rear Parking Assist Buzzer, Instrument Cluster, Alternator Multifunction Switch (Except D4HB), AMB Switch (J3), Audio
ABS7.5ABS Control Module, ESP Control Module, Yaw Rate Sensor, Multipurpose Check Connector Steering Angle Sensor (D4HB/G6DC)
AIRBAG15SRS Control Module, PAB ONAOFF Switch
BLOWER10ECM (D4HB), PCM(G6DC)
Relay
Burglar Alarm Relay

Engine Compartment Fuse Box

It is near the battery.

Engine Compartment Fuse Box Location

To check and replace a fuse:

  1. Turn the ignition switch and all other switches off.
  2. Remove the fuse box cover by pressing the tab and pulling up.
  3. Check the removed fuse; replace it if it is blown. To remove or insert the fuse, use the fuse puller in the main fuse box in the engine compartment.
  4. Push in a new fuse of the same rating, and make sure it fits tightly in the clips.

Advertisements

 

Engine Compartment Fuse Box Diagram

FuseACircuit Protected
FUEL HEATER30Fuel Filter Heater Relay (D4HB)
ABS 140ABS Control Module, ESP Control Module
ABS 220ABS Control Module, ESP Control Module
FRT WIPER30Front Wiper On Relay
KEY SW 230Start Relay, Ignition Switch
RAM 150Rear Area Module (Fuse: RR P/OTLT-RH 15A, Fuel Door 15A, RR P/WIN-LH 25A, RR P/WIN-RH 25A, Luggage 7.5A)
RAM 250Rear Area Module (Fuse: RR DEFOG 25A, RR D/LOCK 20A, P/Quarter 10A, Power Tail Gate 30A, RR Wiper 15A)
RAM 350Rear Area Module (Fuse: PSD-LH 30A, PSD-RH 30A)
IPM 150Instrument Panel Module (Fuse: DDM 30A, ILLUMI 7.5A, Seat Warmer 20A, OBD-II 7.5A, Sunroof 25A)
FRT BLOWER40Front Blower Relay
RR BLOWER30Rear Blower Relay
IPM 350Instrument Panel Module (Fuse: AMP 25A, Room 7.5A, DRV P/Seat 30A, ASS P/Seat 20A, Audio 15A, Memory 7.5A)
IPM 250Instrument Panel Module (Fuse: P/Outlet 1 15A, Pedal 15A, ADM 30A)
1FRT/RR WASHER10Front Washer Motor Relay, Rear Washer Motor Relay
3IG27.5-
4B/A HORN10Burglar Horn Relay
5STOP LAMP20Stop Lamp Switch, Stop Signal Relay
6FUEL HEATER20Fuel Filter Heater (J3)
7KEY SW 125Ignition Switch
8STOP SIGNAL7.5ABS Control Module, ESP Control Module, PCM (GSL), ECM (DSL), TCM (J3)
9A/C COMP7.5A/C COMP Relay
10ATM15ATM Relay (J3/G6EA), TCM (D4HB), P/N Relay (G6DC)
11FRT DEICER15Front Deicer Relay
12HORN15Horn Relay
13ECU 110A/C COMP Relay, PCM (GSL), Mass Air Flow Sensor (G6EA), Stop Lamp Switch (D4HB/J3), Immobilizer Module, ECM (J3), Coolinq Box (G6EA), Diesel Box (D4HB), Crankshaft Position Sensor (D4HB)
1402 DN10Oxygen Sensor (GSL), Lambda Sensor (D4HB)
15ECU 215PCM (GSL), Variable Intake Manifold Valve (GSL), Fuel Pressure Regulator Valve (D4HB), ECM (J3) Cooling Fan Relay (G6DC), Purge Control Solenoid Valve (GSL), Oil Control Valve (GSL), Immobilizer Module (D4HB)
1602 UP10Oxygen Sensor (GSL), Rail Pressure Regulator Valve (D4HB)
17IGN COIL20Ignition Coil #1 - #6 (GSL), Condenser (GSL), ECM (D4HB)
18INJECTOR15Injector #1 - #6 (GSL), PCM (GSL), Inlet Metering Valve (J3), EGR Cooling Bypass Solenoid Valve (D4HB) VGT Control Solenoid Valve (J3), Electrical VGT Actuator (D4HB), Diesel Box (DSL), ECM (J3)
19P/TRAIN7.5Main Relay, PCM (GSL), TCM (J3)
20BATT SNSR15Battery Sensor (D4HB/G6DC)
21FUEL PUMP15Fuel Pump Relay
Relay
Engine Control Relay
A/C COMP Relay
IG 2 Relay
Fuel Pump Relay
Start Relay
Front Deicer Relay
Horn Relay
Front Washer Motor Relay
Rear Washer Motor Relay
ATM Relay
Front Wiper On Relay
Front Wiper LO/HI Relay

Advertisements

 

Additional fuse box

Diesel 2.2L (D4HB)

Additional fuse box (Diesel 2.2L)

FuseACircuit Protected
C/FAN HI 130C/FAN HI 1 Relay
PTC 140PTC 1 Relay
GLOW 160Glow Relay Module
PTC 240PTC 2 Relay
C/FAN LOW30C/FAN LOW Relay
PTC 340PTC 3 Relay
Relay
CRD74-1C/FAN HI 1 Relay
CRD74-2C/FANHI2 Relay
CRD75C/FAN LOW Relay
CRD71PTC 1 Relay
CRD72PTC 2 Relay
CRD73PTC 3 Relay
Diesel 2.9L

Additional fuse box Diesel 2.9L

FuseACircuit Protected
PTC 110ECM (PTC 1 Relay 'ON' Input)
GLOW 1 CHECK10ECM (Glow 1 Relay 'ON' Input)
H/BURNER20Heating Burner
C/FAN HI 130C/FAN HI 1 Relay
PTC 140PTC 1 Relay
GLOW 160Glow 1 Relay
PTC 240PTC 2 Relay
C/FAN LOW30C/FAN LOW Relay
PTC 340PTC 3 Relay
Relay
CJD74-1C/FAN HI 1 Relay
CJD74-2C/FAN HI2 Relay
CJD75C/FAN LOW Relay
CJD69Glow 1 Relay
CJD71PTC 1 Relay
CJD72PTC 2 Relay
CJD73PTC 3 Relay

Main Fuse

Main Fuse

If the main fuse is blown, it must be removed as follows:

  1. Disconnect the negative battery cable.
  2. Remove the nuts shown in the picture above.
  3. Replace the fuse with a new one of the same rating.
  4. Reinstall in the reverse order of removal.
FuseACircuit Protected
ALT150
200
Generator
C/FAN60Cooling fan

Advertisements


Luggage Compartment Fuse Box

The rear cargo area fuse panel is behind the left-side trim panel.

Luggage Compartment Fuse Box Location

To check and replace a fuse:

  1. Turn the ignition switch and all other switches off.
  2. Open the fuse panel cover.
  3. Pull the suspected fuse straight out. Use the removal tool provided on the main fuse box in the engine compartment.
  4. Check the removed fuse; replace it if it is blown. Spare fuses are provided in the main fuse box in the engine compartment.
  5. Push in a new fuse of the same rating, and make sure it fits tightly in the clips.

Luggage Compartment Fuse Box Diagram

FuseACircuit Protected
POWER TAIL GATE30Power Tail Gate Module
PSD-RH30Power Sliding Door Module RH
PSD-LH30Power Sliding Door Module LH
RR DEFOG25RR Defog Relay, Rear Defogger
P/QUARTER10Quarter Glass Open Relay LH, Quarter Glass Close Relay LH, Quarter Glass Open Relay RH Quarter Glass Close Relay RH, Quarter Glass Motor LH, Quarter Glass Motor RH
LUGGAGE7.5Luggage Lamp, Power Tail Gate On/Off Switch
RR P/OTLT-RH15Rear Power Outlet RH
RR P/OTLT-LH15Rear power outlet LH
FUEL DOOR15Fuel Filler Relay, Fuel Filler Actuator
RR WIPER15Rear Wiper Relay, Rear Wiper Motor
RR D/LOCK20S/Door Lock Relay, S/Door Unlock Relay, Sliding Door Lock Actuator, Tail Gate Lock Actuator
RR P/WIN-RH25S/Door Window Relay (UP) RH, S/Door Window Relay (DN) RH, Sliding Door Power Window Motor RH
RR P/WIN-LH25S/Door Window Relay (UP) LH, S/Door Window Relay (DN) LH, Sliding Door Power Window Motor LH
Relay
RR Defog Relay
Quarter Glass Open Relay LH
Quarter Glass Close Relay LH
Quarter Glass Open Relay RH
Quarter Glass Close Relay RH
Rear Wiper Relay
S/Door Lock Relay
S/Door Unlock Relay
Fuel Filler Relay
S/Door Window Relay (UP) LH
S/Door Window Relay (DN) LH
S/Door Window Relay (UP) RH
S/Door Window Relay (DN) RH