Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Kia Sedona, Carnival (2006, 2007, 2008, 2009, 2010).
Checking and Replacing Fuses
A vehicle’s electrical system is protected from electrical overload damage by fuses. If any of your vehicle’s lights, accessories, or controls do not work, check the appropriate circuit fuse. If a fuse has blown, the element inside the fuse will be broken or melted. Check those fuses first that protect the failed component, but check all the fuses before deciding that a blown fuse is not the cause. Replace any blown fuses with another with the same amperage (same color) and check the component’s operation.
Notice
- Before changing a fuse, check the ignition key has been removed and that all the other electric devices have been turned off/disabled.
- Do not use a screwdriver or any other metal object to remove fuses because it may cause a short circuit and damage the system.
- Never replace a fuse with anything but another fuse of the same rating. A higher capacity fuse could cause damage and possibly a fire. Never install a wire or aluminum foil instead of the proper fuse even as a temporary repair. It may cause extensive wiring damage and a possible fire.
- If the replacement fuse blows, this indicates an electrical problem. Avoid using the system involved and immediately consult at a qualified service center.
- If you do not have a spare, use a fuse of the same rating from a circuit, you may not need for operating the vehicle, such as the cigarette lighter fuse.
Passenger Compartment Fuse Box
The fuse panel is located in the driver’s side panel bolster.
To check and replace a fuse:
- Turn the ignition switch and all other switches off.
- Open the fuse panel cover.
- Pull the suspected fuse straight out. Use the removal tool provided on the main fuse box in the engine compartment.
- Check the removed fuse; replace it if it is blown. Spare fuses are provided in the main fuse box in the engine compartment.
- Push in a new fuse of the same rating, and make sure it fits tightly in the clips.
| Fuse | A | Circuit Protected |
|---|---|---|
| ACC | 7.5 | POWER OUTSIDE MIRROR & MIRROR FOLDING SWITCH, AUDIO, DIGITAL CLOCK, MEDIA MODULE |
| P/OUTLET #2 | 15 | CIGARETTE LIGHTER & POWER OUTLET |
| START | 7.5 | BURGLAR ALARM RELAY, TRANSAXLE RANGE SWITCH, ECM (DSL) |
| AIRBAG IND | 7.5 | INSTRUMENT CLUSTER |
| ENG | 7.5 | ATM LEVER SWITCH, STOP LAMP SWITCH (GSL), INPUT SPEED SENSOR, OUTPUT SPEED SENSOR, TRANSAXLE RANGE SWITCH, PCM (GSL), VEHICLE SPEED SENSOR, ECM (DSL), TCM (DSL), BACK-UP LAMP SWITCH, FUEL FILTER WARNING SWITCH (DSL), CLUTCH SWITCH (2.7L), MASS AIR FLOW SENSOR (2.9L VGT) |
| IG1 | 7.5 | TRIP COMPUTER, BACK WARNING BUZZER, RHEOSTAT, ESP SWITCH, INSTRUMENT CLUSTER, MULTIFUNCTION SWITCH, GENERATOR, AMB SWITCH |
| ABS | 7.5 | ABS CONTROL MODULE, ESP CONTROL MODULE, YAW RATE SENSOR, STEERING ANGLE SENSOR, MULTIPURPOSE CHECK CONNECTOR |
| AIRBAG | 15 | SRS CONTROL MODULE, PAB CUT OFF SWITCH |
| PEDAL | 15 | PEDAL ADJUST RELAY |
| P/OUTLET #1 | 15 | CIGARETTE LIGHTER & POWER OUTLET |
| ASS P/SEAT | 20 | PASSENGER POWER SEAT MODULE |
| DRV P/SEAT | 30 | LIMIT SWITCH, DRIVER POWER SEAT MODULE |
| OBD-II | 7.5 | DATA LINK CONNECTOR, MULTIPURPOSE CHECK CONNECTOR |
| ROOM | 7.5 | VANITY LAMP LH(RH), MAP LAMP, A/C CONTROL MODULE, REAR ROOM LAMP SWITCH, OVER HEAD CONSOLE |
| VRS | 10 | VRS SWITCH, VRS MODULE |
| ILLUMI | 7.5 | INSTRUMENT PANEL MODULE |
| AMP | 25 | AMP |
| SEAT WARMER | 20 | SEAT WARMER RELAY |
| SUNROOF | 25 | SUNROOF MODULE |
| AUDIO | 15 | STEP LAMP LH(RH), AUDIO, MEDIA MODULE |
| MEMORY | 7.5 | A/C CONTROL MODULE, DIGITAL CLOCK, INSTRUMENT CLUSTER, TRIP COMPUTER, DOOR MODULE, FRONT AREA MODULE, DRIVER POWER SEAT MODULE, POWER TAIL GATE MODULE |
| IG2 #1 | 7.5 | MULTIFUNCTION SWITCH, A/C CONTROL MODULE, ELECTRO CHROMIC MIRROR, RAIN SENSOR, RELAY BOX |
| IG2 #2 | 7.5 | DOOR MODULE, REAR A/C CONTROL SWITCH, FRONT AREA MODULE, POWER TAIL GATE MODULE DRIVER POWER SEAT MODULE |
| DDM | 30 | DRIVER DOOR MODULE, SAFETY POWER WINDOW MOTOR |
| ADM | 30 | PASSENGER DOOR MODULE |
Advertisements
Engine Compartment Fuse Box
To check and replace a fuse:
- Turn the ignition switch and all other switches off.
- Remove the fuse box cover by pressing the tab and pulling up.
- Check the removed fuse; replace it if it is blown. To remove or insert the fuse, use the fuse puller in the main fuse box in the engine compartment.
- Push in a new fuse of the same rating, and make sure it fits tightly in the clips.
| Fuse | A | Circuit Protected |
|---|---|---|
| FRT/RR WASHER | 10 | FRONT WASHER MOTOR RELAY, REAR WASHER MOTOR RELAY |
| STOP LAMP | 20 | STOP LAMP SWITCH |
| KEY SW #1 | 25 | IGNITION SWITCH |
| STOP SIGNAL | 7.5 | ABS CONTROL MODULE, ESP CONTROL MODULE, PCM (GSL), ECM (DSL), TCM (DSL) |
| A/C COMP | 7.5 | A/C COMP RELAY |
| ATM | 15 | ATM RELAY |
| FRT DEICER | 15 | WINDSHIELD DEFOGGER RELAY |
| HORN | 15 | HORN RELAY |
| ECU #1 | 10 | A/C COMP RELAY, PCM (GSL), MASS AIR FLOW SENSOR (GSL), STOP LAMP SWITCH (2.9L VGT), IMMOBILIZER MODULE, ECM (DSL), AIRCON RELAY (2.9L WGT), COOLING BOX (2.7L) |
| 02 DN | 10 | OXYGEN SENSOR (GSL) |
| ECU #2 | 15 | PCM (GSL), VARIABLE INTAKE MANIFOLD VALVE (GSL), COOLING FAN RELAY (3.8L), PCSV (GSL), OCV (GSL), ECM (DSL) |
| 02 UP | 10 | OXYGEN SENSOR (GSL) |
| IGN COIL | 20 | IGNITION COIL #1 - #6 (GSL), CONDENSER (GSL) |
| INJECTOR | 15 | INJECTOR #1 - #6 (GSL), PCM (GSL), INLET METERING VALVE (DSL), EGR SOLENOID VALVE (2.9L WGT), VGT CONTROL SOLENOID VALVE (2.9L VGT), INTAKE THROTTLE SOLENOID VALVE (DSL), ECM (DSL), MASS AIR FLOW SENSOR (2.9L WGT), DIESEL BOX (DSL) |
| P/TRAIN | 7.5 | MAIN RELAY, BURGLAR HORN RELAY, PCM (GSL), TCM (DSL), GENERATOR (2.9L WGT) |
| FUEL PUMP | 15 | FUEL PUMP RELAY |
| ABS #1 | 40 | ABS CONTROL MODULE, ESP CONTROL MODULE |
| ABS #2 | 20 | ABS CONTROL MODULE, ESP CONTROL MODULE |
| FRT WIPER | 30 | FRONT WIPER ON RELAY |
| KEY SW #2 | 30 | START RELAY, IGNITION SWITCH |
| FRT BLOWER | 40 | FRONT BLOWER RELAY |
| RR BLOWER | 30 | REAR BLOWER RELAY |
| IPM #1 | 50 | INSTRUMENT PANEL MODULE |
| IPM #2 | 50 | INSTRUMENT PANEL MODULE |
| IPM #3 | 50 | INSTRUMENT PANEL MODULE |
| RAM #1 | 50 | REAR AREA MODULE |
| RAM #2 | 50 | REAR AREA MODULE |
| RAM #3 | 50 | REAR AREA MODULE |
| IG2 | 7.5 | |
| FUEL HEATER | 20 | FUEL FILTER HEATER (DSL) |
Advertisements
Additional box (Diesel)
Cooling box (2.7 L)
Main Fuse
If the main fuse is blown, it must be removed as follows:
- Disconnect the negative battery cable.
- Remove the nuts shown in the picture above.
- Replace the fuse with a new one of the same rating.
- Reinstall in the reverse order of removal.
| Fuse | A | Circuit Protected |
|---|---|---|
| ALT | 150 | Generator |
| C/FAN | 60 | Cooling fan |
Advertisements
Luggage Compartment Fuse Box
The rear cargo area fuse panel is behind the left-side trim panel.
To check and replace a fuse:
- Turn the ignition switch and all other switches off.
- Open the fuse panel cover.
- Pull the suspected fuse straight out. Use the removal tool provided on the main fuse box in the engine compartment.
- Check the removed fuse; replace it if it is blown. Spare fuses are provided in the main fuse box in the engine compartment.
- Push in a new fuse of the same rating, and make sure it fits tightly in the clips.
| Fuse | A | Circuit Protected |
|---|---|---|
| PSD-LH | 30 | POWER SLIDING DOOR MODULE LH |
| PSD-RH | 30 | POWER SLIDING DOOR MODULE RH |
| RR DEFOG | 25 | RR DEFOG RELAY, REAR DEFOGGER |
| POWER TAIL GATE | 30 | POWER TAIL GATE MODULE |
| P/QUARTER | 10 | QUARTER GLASS OPEN RELAY LH, QUARTER GLASS CLOSE RELAY LH, QUARTER GLASS OPEN RELAY RH, QUARTER GLASS CLOSE RELAY RH, QUARTER GLASS MOTOR LH, QUARTER GLASS MOTOR RH |
| RR WIPER | 15 | REAR WIPER RELAY, REAR WIPER MOTOR |
| RR D/LOCK | 20 | S/DOOR LOCK RELAY, S/DOOR UNLOCK RELAY, SLIDING DOOR LOCK ACTUATOR, TAIL GATE LOCK ACTUATOR |
| RR P/OTLT-LH | 15 | REAR POWER OUTLET LH |
| RR P/OTLT-RH | 15 | REAR POWER OUTLET RH |
| FUEL DOOR | 15 | FUEL FILLER RELAY, FUEL FILLER ACTUATOR |
| RR P/WIN-LH | 25 | S/DOOR WINDOW RELAY (UP) LH, S/DOOR WINDOW RELAY (DN) LH, SLIDING DOOR POWER WINDOW MOTOR LH |
| RR P/WIN-RH | 25 | S/DOOR WINDOW RELAY (UP) RH, S/DOOR WINDOW RELAY (DN) RH, SLIDING DOOR POWER WINDOW MOTOR RH |
| LUGGAGE | 7.5 | LUGGAGE LAMP, POWER TAIL GATE ON/OFF SWITCH |
Advertisements