Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Kia Optima / Magentis (2000, 2001, 2002, 2003, 2004, 2005, 2006).
Checking and Replacing Fuses
A vehicle’s electrical system is protected from electrical overload damage by fuses. If any of your vehicle’s lights, accessories, or controls do not work, check the appropriate circuit fuse. If a fuse has blown, the element inside the fuse will be broken or melted. Check those fuses first that protect the failed component, but check all the fuses before deciding that a blown fuse is not the cause. Replace any blown fuses with another with the same amperage (same color) and check the component’s operation. If you do not have a spare, use a fuse of the same rating from a circuit, you may not need for operating the vehicle, such as the cigarette lighter fuse.
This vehicle has two fuse panels, one located in the driver’s side kick panel, the other in the engine compartment near the battery.
Notice
- Before changing a fuse, check the ignition key has been removed and that all the other electric devices have been turned off/disabled.
- Do not use a screwdriver or any other metal object to remove fuses because it may cause a short circuit and damage the system.
- Never replace a fuse with anything but another fuse of the same rating. A higher capacity fuse could cause damage and possibly a fire. Never install a wire or aluminum foil instead of the proper fuse even as a temporary repair. It may cause extensive wiring damage and a possible fire.
- If the replacement fuse blows, this indicates an electrical problem. Avoid using the system involved and immediately consult at a qualified service center.
- When replacing a blown fuse or relay, make sure the new fuse or relay fits tightly into the clips. Failure to tightly install the fuse or relay may cause damage to the wiring and electric systems.
Instrument Panel Fuse Box Diagram
To check and replace a fuse:
- Turn the ignition switch and all other switches off;
- Pull the suspected fuse straight out. Use the removal tool provided on the main fuse box in the engine compartment. Refer to the fuse panel chart on the fuse panel cover to identify the likely problem fuse or electrical circuit;
- Check the removed fuse; replace if it is blown;
- Push in a new fuse of the same rating, and make sure it fits tightly in the clips.
| № | A | Circuits Protected |
|---|---|---|
| 1 | 10 | Rear window defroster, Outside rear view mirror heater |
| 2 | 10 | Hazard light, Turn signal lights |
| 3 | 15 | Rear fog light |
| 4 | 10 | Air conditioning system |
| 5 | 10 | ETACS, Keyless entry system, Door lock system |
| 6 | 15 | Power door lock |
| 7 | 30 | 2001-2002: Power seat |
| 25 | 2003-2006: Driver power seat | |
| 8 | 15 | Remote trunk lid |
| 9 | 15 | Stop lights |
| 10 | 10 | Headlamp light |
| 11 | 10 | Air-bag |
| 12 | 10 | Turn signal lights |
| 13 | 10 | Air conditioning system |
| 14 | 15 | Power outlet |
| 15 | 15 | Seat heater |
| 16 | 15 | Air-bag |
| 17 | 10 | Backup lights |
| 18 | 10 | Cluster |
| 19 | 10 | Engine switch |
| 20 | 15 | - |
| 21 | 15 | 2003-2006: Window defroster |
| 22 | 25 | 2003-2006: Passenger power seat |
| 23 | 15 | - |
| 24 | 10 | Digtal clock |
| 25 | 10 | Position lights (LH), License plate lights, Tail lights (LH) |
| 26 | 10 | Audio |
| 27 | 20 | Wiper |
| 28 | 10 | Dome lights, Front door edge warning lights |
| 29 | 10 | Position lights (RH), License plate lights, Tail lights (RH) |
| 30 | 15 | Cigar lighter |
| 31 | 10 | Electronic power steering (EPS) |
| S | - | Shunt |
Advertisements
Engine Compartment Fuse Box Diagram
To check and replace a fuse:
- Turn the ignition switch and all other switches off;
- Remove the fuse box cover by turning the plastic knob located in the cover counterclockwise until the cover can be removed;
- Check the fuses. If one is blown, replace it with a new one of the same rating.
| № | A | Circuits Protected |
|---|---|---|
| 1 | 20 | Fuel pump |
| 2 | 15 | Headlights (Low beam) |
| 3 | 10 | ABS |
| 4 | 10 | Injector |
| 5 | 10 | Air conditioning compressor |
| 6 | 20 | ATM Relay |
| 7 | 30 | Engine control unit relay |
| 8 | 20 | Ignition coil |
| 9 | 15 | Oxygen sensor |
| 10 | 15 | Engine control unit |
| 11 | 10 | Horn |
| 12 | 15 | Headlights (High beam) |
| 13 | 20 | Headlamp washers |
| 14 | 15 | Day time running lamps |
| 15 | 15 | Front fog lights |
| 16 | - | Diode |
| 17 | 30 | - |
| 18 | 20 | - |
| 19 | 15 | - |
| 20 | 10 | - |
| 21 | - | Diode |
| 22 | 30 | Blower |
| 23 | 30 | Power fuse №2 |
| 24 | 20 | Power amplifier |
| 25 | 15 | Sunroof |
| 26 | 20 | Tail lights |
| 27 | 30 | Power fuse №1 |
| 28 | 10 | Engine control unit (ECU) |
| 29 | 30 | Rear window defroster |
| 30 | - | - |
| 31 | - | - |
| 32 | - | - |
| 33 | 20 | Condenser fan |
| 34 | 30 | 2001-2002: Power window |
| 40 | 2003-2006: Power window | |
| 35 | 30 | 2001-2002: ABS |
| 20 | 2003-2006: ABS | |
| 36 | 30 | Ignition switch |
| 37 | 30 | 2001-2002: ABS |
| 40 | 2003-2006: ABS | |
| 38 | 30 | Ignition switch |
| 39 | 30 | Radiator fan motor |
| R1 | Radiator fan (High speed №1) | |
| R2 | Condenser fan (High speed №2) | |
| R3 | Front fog lights | |
| R4 | Condenser fan (High speed №1) | |
| R5 | Condenser fan (Low speed) | |
| R6 | Horn | |
| R7 | Headlights (High beam) | |
| R8 | Starter | |
| R9 | Wiper motor | |
| R10 | Headlights (Low beam) | |
| R11 | Air conditioning compressor | |
| R12 | Radiator fan (High speed №2) | |
| R13 | Radiator fan (Low speed) | |
Advertisements