Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Iveco Daily III (2000, 2001, 2002, 2003, 2004, 2005, 2006).
Checking and Replacing Fuses
A fuse is an element for protecting the electrical system. A fuse will trip (i.e. it will blow) in the event of a failure or improper interventions in the electrical system.
If an electrical device is not working, check whether the respective fuse is blown. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Check those fuses first that protect the failed component, but check all the fuses before deciding that a blown fuse is not the cause. Replace any blown fuses with another with the same amperage (same color) and check the component’s operation.
Notice
- Before changing a fuse, check the ignition key has been removed and that all the other electric devices have been turned off/disabled.
- Never replace a broken fuse with anything other than a new fuse. Always use a fuse of the same colour.
- Never change a fuse with another amperage. This can cause damage to the electrical system and fire.
- If the fuse blows again, have the vehicle inspected at a qualified service center.
Location
The fuse box is located behind the trim panel on the driver’s side of the instrument panel.
Passenger Compartment Fuse Box Diagram
Advertisements
| № | Function | A |
|---|---|---|
| 1 | ID/TCA (.11): Thermal starter | 40 |
| 1 | UNIJET (.13-.15): Thermal starter | 80 |
| 1 | UNIJET F1A (.10-.12): Thermal starter, additional heater | 30 |
| 2 | Immobilizer/Warming/EDC | 5 |
| 3 | DDS device | 5 |
| 4 | Instrument cluster (+30) | 5 |
| 5 | Instrument cluster (+15) | 5 |
| 6 | Stalk unit (rear fog guard, flasher) | 5 |
| 7 | Stalk unit (low beams) | 10 |
| 8 | Stalk unit (high beams) | 15 |
| 9 | Stalk unit (side lights) | 15 |
| 10 | Windscreen wiper | 15 |
| 11 | Stalk unit (direction indicators/hazard warning lights) | 15 |
| 12 | Stalk unit (horns) | 15 |
| 13 | Reversing light | 5 |
| 14 | Side light, clearance, no. plate light | 5 |
| 15 | Side light cluster lighting | 5 |
| 16 | Left low beam headlamp | 10 |
| 17 | Right low beam headlamp | 10 |
| 18 | Left high beam headlamp | 10 |
| 19 | Right high beam headlamp/headlamp aming | 10 |
| 20 | Interior lighting/radio/cigar lighter | 10 |
| 20 | UNIJET F1A (.10-.12): Interior lighting/radio | 10 |
| 21 | Electric windscreen defrosting unit | 30 |
| 21 | UNIJET F1A (.10-.12): Cigar lighter | 15 |
| 22 | Heated fuel filter | 15 |
| 23 | EDC electronic control unit | 25 |
| 24 | EDC | 10 |
| 25 | Stop lights | 5 |
| 26 | 13-pin current socket | 15 |
| 27 | 13-pin current socket | 15 |
| 28 | 13-pin current socket | 10 |
| 29 | 38-pin diagnostic connector | 5 |
| 30 | Fog lamps | 10 |
| 31 | Climate control, additional heater, engine cooling | 5 |
| 31 | UNIJET F1A (.10-.12): Compressor, timer, engine fan | 10 |
| 32 | Climate control | 5 |
| 33 | Additional heater | 20 |
| 34 | Headlamp washer | 20 |
| 35 | Rear differential lock | 5 |
| 36 | ABS, EBD, ABD failure warning light | 5 |
| 37 | ABS | 5 |
| 39 | Heated mirrors | 10 |
| 39 | UNIJET F1A (.10-.12): Heated mirrors, heated rear-screen, heated windscreen | 10 |
| 40 | Power windows | 30 |
| 40 | UNIJET F1A (.10-.12): Power windows (left) | 20 |
| 41 | Heated rear-screen, heated windscreen | 10/20 |
| 42 | Self-levelling suspensions (Wabco) | 5 |
| 43 | Air bag failure warning light | 5 |
| 44 | Self-levelling suspensions (Wabco) | 40 |
| 45 | Air-bag | 5 |
| 46 | Solenoid valve for thermal starter | 5 |
| 46 | UNIJET F1A (.10-.12): Power windows (right) | 20 |
| 47 | Electric fuel pump | 10 |
| 48 | Door locking/alarm | 30 |
| 49 | Door locking/alarm | 5 |
| 50 | Rear differential lock | 30 |
| 51 | Total power takeoff | 10 |
| 52 | Front differential lock (4x4) | 30 |
| 53 | Self-levelling suspensions Techniek) | 30 |
| 54 | Electric hatch (van and 6+1) | 15 |
| 55 | Rototranslating door | 15 |
| 25035 | Switching on external lights | |
| 25003 | Switching on fog lamps | |
| 25006 | Switching on stop lights | |
| 25704 | Total power takeoff engagement control | |
| 25104 | Switching off Retarder with ABS on | |
| 25209 | Loads cut-off during starting | |
| 25222 | Thermal starter engagement enable | |
| 25223 | Thermal starter fan control | |
| 25307 | Climate control compressor engagement | |
| 25336 | Engine cooling | |
| 25337 | Climate control compressor disengagement | |
| 25340 | Compressor on signal | |
| 25620 | Fuel filter clogged signal | |
| 25705 | Diagnostics enable | |
| 25810 | Heated fuel filter circuit control | |
| 25811 | Advance variator control (KSB) | |
| 25818 | Heated windscreen switching on | |
| 25837 | Electric fuel pump switching on | |
| 25858 | EDC switching on | |
| 25926 | Suspension raising enable | |
| 25927 | Suspension lowering enable | |
| 25928 | Rear-screen heating switching on | |
| 61002A | Anti-retum from Trinary | |
| 61002В | Anti-retum from TGC (bus) | |
| 66010 | Timer for headlamp washer | |
Advertisements