Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Honda Insight (ZE1) (2000, 2001, 2002, 2003, 2004, 2005, 2006).
Checking and Replacing Fuses
All the electrical circuits in your car have fuses to protect them from a short circuit or overload.
If something electrical in your car stops working, the first thing you should check for is a blown fuse. Determine from the chart, or the diagram on the fuse box lid, which fuse or fuses control that component. Check those fuses first, but check all the fuses before deciding that a blown fuse is not the cause. Replace any blown fuses and check the component’s operation.
- Turn the ignition switch to LOCK (0). Make sure the headlights and all other accessories are off.
- Remove the cover from the fuse box.
- Check each of the large fuses in the under-hood fuse box by looking through the top at the wire inside. Removing these fuses requires a Phillips-head screwdriver.
- Check the smaller fuses in the under-hood fuse box and all the fuses in the interior fuse boxes by pulling out each fuse with the fuse puller provided in the under-hood fuse box.
- Look for a burned wire inside the fuse. If it is burned, replace it with one of the spare fuses of the same rating or lower.
If you cannot drive the car without fixing the problem, and you do not have a spare fuse, take a fuse of the same rating or a lower rating from one of the other circuits. Make sure you can do without that circuit temporarily (such as the accessory socket or radio).
If you replace the blown fuse with a spare fuse that has a lower rating, it might blow out again. This does not indicate anything wrong. Replace the fuse with one of the correct rating as soon as you can. - If the replacement fuse of the same rating blows in a short time, there is probably a serious electrical problem in your car. Leave the blown fuse in that circuit and have your car checked by a qualified technician.
Notice
- Replacing a fuse with one that has a higher rating greatly increases the chances of damaging the electrical system. If you do not have a replacement fuse with the proper rating for the circuit, install one with a lower rating.
- Never replace a broken fuse with anything other than a new fuse.
Passenger Compartment
- Fuse Box
- Daytime Running Lights (DRL) Control Unit
- Daytime Running Lights (DRL) Relay
Low Beam Cut Relay - 2002-2006: Air Fuel (A/F) Ratio Sensor Relay
- PGM-FI Main Relay
Reverse Relay - Supplemental Restraint System (SRS) Unit
- Keyless Door Lock Control Unit
- Climate Control Unit or Heater Control Panel
- Audio Unit
- Engine Control Module (ECM)
- Blower Motor High Relay
- CVT: Electronic Power Steering (EPS) Motor Relay
- M/T: Electronic Power Steering (EPS) Control Unit
CVT: Transmission Control Module (TCM) - M/T: Electronic Power Steering (EPS) Motor Relay
- CVT: Electronic Power Steering (EPS) Control Unit
- Immobilizer Receiver Unit
Advertisements
Instrument Panel Fuse Box Diagram
The interior fuse is underneath the dashboard on the driver’s side. Remove the storage pocket by swinging the lid down, pushing up, and pulling it straight out of its hinges.
| № | A | Protected Component |
|---|---|---|
| 1 | 10 | Supplemental Restraint System (SRS) Unit |
| 2 | 15 | Fuel Pump, Supplemental Restraint System (SRS) Unit |
| 3 | 20 | Windshield Washer Motor, Windshield Wiper Motor, Windshield Wiper Intermittent Relay |
| 4 | 7.5 | DC-DC Converter, Electrical Load Detector (ELD) Unit, Evaporative Emission Control (EVAP) Canister Vent Shut Valve, EVAP Purge Control Solenoid Valve, Secondary Heated Oxygen Sensor (HO2S), Vehicle Speed Sensor (VSS), Transmission Control Module (TCM) |
| 5 | 7.5 | Turn Signal Lights, Turn Signal/Hazard Relay |
| 6 | 7.5 | Electronic Power Steering (EPS) Control Unit, Gauge Assembly, Keyless Door Lock Control Unit, Power Window Control Unit (Power Window Master Switch), Power Window Relay, Shift Lock Solenoid |
| 7 | 15 | Ignition Coils |
| 8 | 20 | Passenger's Power Window Motor |
| 9 | 7.5 | Engine Control Module (ECM), Starter Cut Relay |
| 10 | 20 | Power Window Control Unit (Power Window Master Switch), Driver's Power Window Motor |
| 11 | 7.5 | Audio Unit |
| 12 | 10 | Accessory Power Socket |
| 13 | - | - |
| 14 | 20 | 2002-2006: Air Fuel (A/F) Ratio Sensor, Engine Control Module (ECM) (Air Fuel (A/F) Ratio Sensor Relay) |
| 15 | 10 | Audio Unit, Climate Control Unit/Heater Control Panel Lights, Dash Lights, Gauge Lights, Front Parking Lights, Front Side Marker Lights, License Plate Light, Taillights |
| 16 | 7.5 | ABS Modulator-Control Unit, A/C Compressor Clutch Relay, Blower Motor Relay. Blower Motor High Relay, Climate Control Unit/Heater Control Panel, A/C Condenser Fan Relay, Fan Control Relay, Mode Control Motor, Radiator Fan Relay, Rear Window Defogger Relay, Recirculation Control Motor |
| 17 | 7.5 | Daytime Running Lights (DRL) Control Unit |
| 18 | 7.5 | Battery Condition Monitor (BCM) Module, Climate Control Unit/Heater Control Panel, Data Link Connector (DLC), Engine Control Module (ECM), Gauge Assembly, Motor Control Module (MCM) |
| 19 | 7.5 | Cargo Area Light, Ceiling Light/Spotlights |
| 20 | 10 | Audio Unit |
| 21 | 10 | Daytime Running Lights (DRL) Control Unit |
| 22 | 20 | Keyless Door Lock Control Unit |
| 23 | 7.5 | Hatch Opener Relay, Hatch Opener Actuator |
| 24 | 7.5 | Battery Module Fan, High Speed Battery Module Fan Control Relay, Ignition Hold Relay, Low Speed Battery Module Fan Control Relay, Motor Control Module (MCM) |
| 25 | - | - |
| 26 | 10 | Rear Window Washer Motor, Rear Window Wiper Motor |
| 27 | 7.5 | Back-Up Lights, Reverse Relay (CVT) |
| 28 | - | - |
| R1 | Taillight | |
| R2 | Starter Cut | |
| R3 | Power Window | |
| R4 | Turn Signal/Hazard | |
Engine Compartment
- Fuse Box
- Relay Box
- ABS Modulator-Control Unit
Advertisements
Engine Compartment Fuse Box Diagram
The under-hood fuse box is located in the engine compartment. To open it, push the tab as shown.
| № | A | Protected Component |
|---|---|---|
| 1 | 50 | Ignition Switch (BAT) |
| 2 | 80 | Battery, Power Distribution |
| 3 | 30 | ABS Modulator-Control Unit |
| 4 | 10 | Turn Signal/Hazard Relay, Turn Signal Lights |
| 5 | 15 | Low Speed Motor Power Inverter (MPI) Module Fan Control Relay, High Speed Motor Power Inverter Module (MPI) Fan Control Relay, PDU Fan Motor |
| 6 | 10 | ABS Modulator-control Unit, Engine Control Module (ECM), High Mount Brake Light, Taillights |
| 7 | 15 | PGM-FI Main Relay (IGP), Key Interlock Solenoid (CVT) |
| 8 | 15 | Left Headlight, High Beam Indicator Light, Daytime Running Lights Control Unit |
| 9 | - | - |
| 10 | 15 | Right Headlight, Daytime Running Lights Control Unit |
| 11 | 30 | Radiator Fan Motor |
| 12 | 40 | Blower Motor |
| 13 | 30 | Rear Window Defogger, Noise Condenser |
| 14 | 20 | ABS Modulator-Control Unit |
| 15 | 40 | Electronic Power Steering (EPS) Control Unit |
| 16 | 30 | Taillight Relay, Fuse (Passenger Compartment Fuse Box): № 14, 18, 19, 20, 21, 22, 23 |
| 17 | 40 | Power Window Relay, Fuse (Passenger Compartment Fuse Box): № 8, 10 |
| 18 | 7.5 | Battery Condition Monitor (BCM) Module, High Voltage Contactor, Motor Control Module (MCM), Voltage Converter Module |
| 19 | 20 | A/C Condenser Fan Motor, A/C Compressor Clutch |
| R1 | A/C Compressor Clutch | |
| R2 | Radiator Fan | |
| R3 | A/C Condenser Fan | |
| R4 | Blower Motor | |
| R5 | Horn | |
| R6 | Headlight №2 | |
| R7 | Headlight №1 | |
Advertisements
Engine Compartment Relay Box
| № | Relay |
|---|---|
| R1 | Rear Window Defogger |
| R2 | PGM-FI Main №2 (Fuel Pump) |
| R3 | Fan Control |
| R4 | Windshield Wiper Intermittent |
Luggage Compartment Relay Box
- High-Speed Battery Module Fan Control Relay
Low-Speed Battery Module Fan Control Relay - Motor Control Module (MCM)
- Battery Condition Monitor (BCM) Module
- Hatch Opener Relay
- Relay Box
| № | Relay |
|---|---|
| R1 | High Voltage Contactor Control Relay |
| R2 | Low Speed Motor Power Inverter (MPI) Module Fan Control Relay |
| R3 | High Speed Motor Power Inverter (MPI) Module Fan Control Relay |
| R4 | Ignition Hold |
Advertisements