Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Ford Transit (2014, 2015, 2016, 2017, 2018).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Engine Compartment Fuse Box
| № | A | Protected Component |
|---|---|---|
| F1 | 5 | 2.0L Diesel: Radio mute |
| 10 | 2.2L Diesel: Selective Catalytic Reduction | |
| F2 | 15 | 2.0L Diesel: Not used |
| 2.2L Diesel: Selective Catalytic Reduction | ||
| F3 | 15 | 2.0L Diesel: Not used |
| 2.2L Diesel: Selective Catalytic Reduction | ||
| F4 | 10 | 2.0L Diesel: Not used |
| 2.2L Diesel: Selective Catalytic Reduction | ||
| F5 | 3 | 2.0L Diesel: Not used |
| 2.2L Diesel: Diesel particulate filter vaporizer. Glow plug monitor. | ||
| F6 | 3 | 2.0L Diesel: Not used |
| F7 | 7.5 | 2.0L Diesel: Not used |
| 2.2L Diesel: Anti-lock brake system. Stability assist. Ignition | ||
| F8 | 20 | Cooling fan |
| F9 | 30 | 2.0L Diesel: Not used |
| 2.2L Diesel: Left-hand windshield wiper | ||
| F10 | 30 | 2.0L Diesel: Not used |
| 2.2L Diesel: Right-hand windshield wiper | ||
| F11 | 10 | 2.0L Diesel: Not used |
| 2.2L Diesel: Air conditioning clutch | ||
| F12 | 20 | 2.0L Diesel: Not used |
| 2.2L Diesel: Diesel particulate filter vaporizer glow plug | ||
| F13 | - | Not used |
| F14 | 3 | 2.0L Diesel: Not used |
| 2.2L Diesel: Selective Catalytic Reduction - ignition | ||
| F15 | - | Not used |
| F16 | - | Not used |
| F17 | - | Not used |
| F18 | 40 | 2.0L Diesel: Cooling fan 2 |
| 2.2L Diesel: Anti-lock brake system. Stability assist pump | ||
| F19 | 40 | 2.0L Diesel: Cooling fan (twin speed) |
| 60 | 2.0L Diesel: Cooling fan (single speed) | |
| F19 | 30 | 2.2L Diesel: Starter solenoid |
| F20 | 40 | 2.0L Diesel: Selective catalytic reduction relay feed |
| 60 | 2.2L Diesel: Glow plugs | |
| F21 | 40 | 2.0L Diesel: Glow plug module 2 |
| 60 | 2.2L Diesel: Ignition relay 3 | |
| F22 | 40 | 2.0L Diesel: Glow plug module 1 |
| 2.2L Diesel: Not used | ||
| F22 | - | Not used |
| F23 | 10 | 2.0L Diesel: Air conditioning clutch |
| 2.2L Diesel: Not used | ||
| F24 | 7.5 | 2.0L Diesel: Not used |
| 2.2L Diesel: Fuel injection pump | ||
| F25 | - | Not used |
| F26 | - | Not used |
| F27 | - | Not used |
| F28 | 5 | 2.0L Diesel: Crank case ventilation heater |
| 2.2L Diesel: Not used | ||
| F29 | 15 | 2.0L Diesel: Run on water pump |
| 2.2L Diesel: Not used | ||
| F30 | 60 | 2.0L Diesel: Powertrain control module relay |
| 40 | 2.2L Diesel: Cooling fan 1 | |
| F31 | 20 | 2.0L Diesel: Run-start 2 relay |
| 40 | 2.2L Diesel: Cooling fan 2 | |
| F32 | 20 | 2.0L Diesel: Fuel fired booster heater |
| 60 | 2.2L Diesel: Windshield dual wiper motors | |
| F33 | 20 | 2.0L Diesel: Not used |
| 2.2L Diesel: Start-Stop auxiliary water pump | ||
| F34 | - | Not used |
| F35 | 20 | 2.0L Diesel: Powertrain control module |
| 15 | 2.2L Diesel: Powertrain control system supply | |
| F36 | 20 | 2.0L Diesel: Vehicle power 5 |
| 15 | 2.2L Diesel: Sensor NOXI 2 | |
| F37 | 15 | 2.0L Diesel: Tank reductant. Exhaust gas recirculation valve |
| 7.5 | 2.2L Diesel: Volume Control Valve | |
| F38 | 10 | 2.0L Diesel: Engine junction box R1, R5, R10, and R15 relay coils |
| 7.5 | 2.2L Diesel: Mass air flow sensor | |
| F39 | 10 | 2.0L Diesel: Glow plug monitor. Nitrogen oxide sensor |
| 15 | 2.2L Diesel: Diesel pump vaporizer | |
| R1 | 2.0L Diesel: High-speed cooling fan | |
| 2.2L Diesel: Ignition | ||
| R2 | 2.0L Diesel: Not used | |
| 2.2L Diesel: Starter motor | ||
| R3 | Rear window wiper | |
| R4 | 2.0L Diesel: Air suspension | |
| 2.2L Diesel: Not used | ||
| R5 | Cooling fan | |
| R6 | 2.0L Diesel: Not used | |
| 2.2L Diesel: Windshield wiper - on and off | ||
| R7 | 2.0L Diesel: Not used | |
| 2.2L Diesel: Windshield wiper - low and high speed | ||
| R8 | Not used | |
| R9 | 2.0L Diesel: Starter motor | |
| 2.2L Diesel: Not used | ||
| R10 | Air conditioning clutch | |
| R11 | 2.0L Diesel: Not used | |
| 2.2L Diesel: Fuel vaporizer system glow plug | ||
| R12 | 2.0L Diesel: Not used | |
| 2.2L Diesel: Fuel injection pump | ||
| R13 | 2.0L Diesel: Selective catalytic reduction | |
| 2.2L Diesel: All-wheel drive pump | ||
| R14 | 2.0L Diesel: Not used | |
| 2.2L Diesel: Econetic | ||
| R15 | 2.0L Diesel: Low-speed cooling fan | |
| 2.2L Diesel: Low-speed and high-speed cooling fan | ||
| R16 | 2.0L Diesel: Run-start 2. All-wheel drive | |
| 2.2L Diesel: Selective Catalytic Reduction | ||
| R17 | 2.0L Diesel: Not used | |
| 2.2L Diesel: Powertrain control module | ||
| R18 | 2.0L Diesel: Powertrain control module | |
| 2.2L Diesel: High speed cooling fan | ||
Advertisements
Passenger Compartment Fuse Box
This is located behind the removable trim panel.
Diagram (2.0L Diesel)
| № | A | Protected Component |
|---|---|---|
| F1 | 60 | Windshield wiper motor relay |
| F2 | 40 | Blower motor |
| F3 | - | Not used |
| F4 | 40 | Heated rear window. Heated exterior mirrors |
| F5 | 40 | Trailer B+ supply |
| F6 | 40 | Auxiliary power point 2 |
| F7 | 40 | Auxiliary power point 1 |
| F8 | 20 | Horn |
| F9 | 15 | Rear window washer relay |
| F10 | 10 | R1, R2, R3, R4, R5, R10, R17 relay coils |
| F11 | - | Not used |
| F12 | - | Not used |
| F13 | 20 | Cigar lighter |
| F14 | 20 | Instrument panel auxiliary power point |
| F15 | 50 | Voltage quality module. Body control module |
| F16 | 25 | Anti-lock brake system module. Electronic stability program valves control |
| F17 | 5 | Powertrain control module battery positive voltage relay coil |
| F18 | 10 | Brake lamp |
| F19 | 15 | Locking cargo relay |
| F20 | 5 | Fuel fired booster heater |
| F21 | 15 | Automatic transmission control unit |
| F22 | 25 | Automatic transmission oil pump |
| F23 | 20 | Heated rear window left-hand side |
| F24 | 10 | Heated exterior mirrors |
| F25 | 7.5 | Driver door unlock |
| F26 | 7.5 | Passenger door unlock |
| F27 | - | Not used |
| F28 | 20 | Not used |
| F29 | 40 | Rear blower motor |
| F30 | 20 | Rear auxiliary power point |
| F31 | 20 | Heated rear window left-hand side |
| F32 | 60 | Run-start relay |
| F33 | 60 | Fuel pump relay |
| F34 | 40 | Heated rear window left-hand side |
| F35 | 40 | Heated rear window right-hand side |
| F36 | 50 | Body control module feed RP1 |
| F37 | 50 | Body control module feed RP2 |
| F38 | 60 | Standard relay box feed BB4 |
| F39 | 20 | Heated seats |
| F40 | 5 | Powertrain control module ignition |
| F41 | 5 | Fuel fired booster heater relay coil |
| F42 | 5 | Headlamp leveling |
| F43 | 5 | Transmission control module |
| F44 | 10 | Air suspension. Voltage quality module. Rear climate control. Light detection and ranging system. Front and rear view cameras. Adaptive cruise control |
| F45 | 20 | Cornering lamps |
| F46 | 5 | Heated rear window. Heated exterior mirror relay |
| F47 | 5 | Anti-lock brake system module |
| F48 | 10 | Camper interface connector 1 |
| F49 | 20 | Rear window wiper |
| F50 | 5 | Rain sensor module. Rear window wiper |
| F51 | 25 | Windshield wiper motor |
| F52 | 25 | Windshield wiper motor |
| F53 | - | Not used |
| F54 | - | Not used |
| F55 | 40 | Anti-lock brake system module. Electronic stability control |
| F56 | 30 | Power slide step |
| F57 | 30 | Driver power seat |
| F58 | 20 | Front fog lamp |
| F59 | 30 | Starter motor solenoid |
| F60 | 15 | Trailer tow battery charge |
| F61 | 15 | Double lock left-hand side |
| F62 | 15 | Double lock right-hand side |
| F63 | 15 | Central lock left-hand side |
| F64 | 15 | Central lock right-hand side |
| F65 | 20 | Fuel pump |
| F66 | 40 | Heated fuel filter |
Advertisements
Diagram (2.2L Diesel)
| № | A | Protected Component |
|---|---|---|
| F1 | 10 | Airbag module |
| F2 | 20 | Heated rear window |
| F3 | 10 | Heated exterior mirrors |
| F4 | - | Not used |
| F5 | - | Not used |
| F6 | 5 | Tachograph |
| F7 | 10 | Battery sensor |
| F8 | 40 | AC power outlet socket |
| F9 | - | Not used |
| F10 | 30 | Driver power seat |
| F11 | 30 | Passenger power seat |
| F12 | 30 | Power step |
| F13 | - | Not used |
| F14 | 5 | Tracking and blocking control module |
| F15 | 40 | Powertrain control module battery relay |
| F16 | 40 | Powertrain control module power relay |
| F17 | - | Not used |
| F18 | 30 | Anti-lock brake system valves. Stability assist valves |
| F19 | 5 | Tachograph |
| F20 | 5 | Heated exterior mirror relay. Heated windshield relay |
| F21 | - | Not used |
| F22 | 15 | Passenger compartment fuse panel |
| F23 | 7.5 | Air conditioning control module |
| F24 | 5 | Headlamp leveling |
| F25 | 7.5 | Interior lighting |
| F26 | 10 | Heated exterior mirrors |
| F27 | 20 | Heated front seats |
| F28 | 20 | Cornering lamps |
| F29 | 10 | Rear parking aid camera. Lane keeping system. Electro mirror |
| F30 | 5 | Adaptive cruise control |
| F31 | - | Not used |
| F32 | 10 | Interior lighting |
| F33 | 20 | All wheel drive module |
| F34 | 20 | Rear window wiper |
| F35 | 5 | Power folding mirrors |
| F36 | 20 | Horn |
| F37 | 7.5 | SYNC module |
| F38 | 5 | Blower motor. Horn relay. Windshield wiper relay |
| F39 | 7.5 | Remote keyless entry. Battery. Power windows. Rear heating, ventilation and air conditioning |
| F40 | 40 | Front blower motor |
| F41 | 40 | Rear blower motor |
| F42 | 30 | Heated rear window |
| F43 | 30 | Trailer socket |
| F44 | 60 | Auxiliary power points |
| F45 | - | Not used |
| F46 | 30 | Power windows |
| F47 | 20 | Cigar lighter socket |
| F48 | 20 | Rear auxiliary power points |
| F49 | 20 | Front auxiliary power points |
| F50 | 60 | Ignition relay 1 |
| F51 | 60 | Ignition relay 2 |
| F52 | 40 | Left-hand heated windshield element |
| F53 | 40 | Right-hand heated windshield element |
| R1 | Fuel fired booster heater | |
| R2 | Auxiliary power points | |
| R3 | Not used | |
| R4 | Ignition 2 | |
| R5 | Power windows | |
| R6 | Ignition 1 | |
| R7 | Horn | |
| R8 | Not used | |
| R9 | Front blower motor | |
| R10 | Rear blower motor | |
| R11 | Heated rear window. Heated exterior mirrors | |
| R12 | Left-hand heated windshield element | |
| R13 | Right-hand heated windshield element | |
Pre-fuse Box
This is located under the driver’s seat.
2.2L Diesel
2.0L Diesel
| № | A | Protected Component |
|---|---|---|
| F1 | 470 | Engine compartment fuse box. Starter motor. Alternator |
| F2 | 100 | Passenger compartment fuse box. Body control module fuse box |
| F3 | 40 | 2.0L Diesel: Direct current (DC/AC) inverter |
| 2.2L Diesel: Powertrain control module. Anti-lock brake system | ||
| F4 | 200 | 2.0L Diesel: Secondary relay box feed 1 |
| 2.2L Diesel: Passenger compartment fuse panel | ||
| F5 | 100 | 2.0L Diesel: Secondary relay box feed 2 |
| 2.2L Diesel: Passenger compartment fuse panel | ||
| F6 | 100 | Cabin heater |
| F7 | 80 | Heated windshield relay |
| F8 | 100 | 2.0L Diesel: Passenger compartment fuse box. Secondary relay box feed 5 |
| 2.2L Diesel: Engine junction box | ||
| F9 | 100 | 2.0L Diesel: Secondary relay box feed 3 |
| 2.2L Diesel: Passenger compartment fuse panel | ||
| F10 | 100 | 2.0L Diesel: Secondary relay box feed 4 |
| F10 | 60 | 2.2L Diesel: Passenger compartment fuse panel supply |
| F11 | 100 | 2.0L Diesel: Powertrain control module relay |
| F11 | 60 | 2.2L Diesel: Passenger compartment fuse panel supply |
| F12 | 60 | Auxiliary power point 1 |
| F13 | 60 | Auxiliary power point 2 |
| F14 | 60 | Auxiliary power point 3 |
| F15 | 60 | 2.0L Diesel: Rear climate control |
| F16 | 100 | 2.0L Diesel: Not used |
| F17 | 60 | 2.0L Diesel: Camper |
2.0L Diesel
| № | A | Protected Component |
|---|---|---|
| F1 | 3 | Exterior light switch. Water heater switch. Auxiliary power switch |
| F2 | 20 | Power supply |
| F3 | 20 | R1 power |
| F4 | 20 | R2 power |
| F5 | 15 | R3 power |
| F6 | 15 | R4 power |
| F7 | 15 | R5, R6 power |
| F8 | 10 | R7 power |
| F9 | 20 | Radio transmitter |
| F10 | 5 | Ignition switch relay |
| F11 | 15 | Ignition switch relay |
| F12 | - | Not used |
| R1 | Beacon relay | |
| R2 | Ignition relay | |
| R3 | Auxiliary power point 2. Water heater | |
| R4 | Interior lamp relay | |
| R5 | Auxiliary power point 1. Direction indicator (left hand side) | |
| R6 | Direction indicator (right hand side) | |
| R7 | Interior lighting | |
Advertisements
Body Control Module
This is located behind the removable trim panel.
Diagram (2.0L Diesel)
| № | A | Protected Component |
|---|---|---|
| F1 | - | Not used |
| F2 | 7.5 | Power exterior mirrors. Driver door window |
| F3 | 20 | Unlock function (driver and passenger) |
| F4 | 5 | Not used |
| F5 | 20 | Not used |
| F6 | 10 | Not used |
| F7 | 10 | Not used |
| F8 | 10 | Battery back-up sounder |
| F9 | 10 | Not used |
| F10 | 5 | Not used |
| F11 | 5 | Intrusion sensor. Rear air conditioning |
| F12 | 7.5 | Climate control. Hazard flasher switch |
| F13 | 7.5 | Steering column. Instrument cluster. Data link connector |
| F14 | 10 | Not used |
| F15 | 10 | Data link connector |
| F16 | 15 | Unlock function (left/right sliding doors) |
| F17 | 5 | Battery back-up sounder |
| F18 | 5 | Ignition switch |
| F19 | 7.5 | Passenger airbag status indicator. Passenger airbag status switch |
| F20 | 7.5 | Tachograph |
| F21 | 5 | Auxiliary heater |
| F22 | 5 | Not used |
| F23 | 10 | Accessory delay. Direct current (DC/AC) inverter |
| F24 | 20 | Central locking system. Double locking system |
| F25 | 30 | Not used |
| F26 | 30 | Not used |
| F27 | 30 | Not used |
| F28 | 20 | Not used |
| F29 | 30 | Not used |
| F30 | 30 | Not used |
| F31 | 15 | Not used |
| F32 | 10 | GPS. Voice Control. SYNC module. Display. Adaptive cruise control. Remote receiver |
| F33 | 20 | Radio. SYNC module |
| F34 | 30 | Ignition run-start relay pre-fuse. Parking aid. Heater control. Lane keeping system camera. Restraints control module. Central control panel. Passenger airbag status indicator. Tachograph. Auxiliary heater. Steering wheel module |
| F35 | 5 | Restraints control module |
| F36 | 15 | Parking aid. Lane keeping system camera. Steering wheel module |
| F37 | 20 | Not used |
| F38 | 30 | Power windows (Circuit breaker) |
Diagram (2.2L Diesel)
| № | A | Protected Component |
|---|---|---|
| F1 | 15 | Central locking system 2 |
| F2 | 15 | Central locking system 1 |
| F3 | 15 | Ignition switch. Auxiliary battery relay |
| F4 | 5 | Parking aid module |
| F5 | 5 | Rain sensor module. Autolamp module |
| F6 | 15 | Windshield washer pump |
| F7 | 7.5 | Exterior mirrors |
| F8 | 15 | Front fog lamps |
| F9 | 10 | Right-hand high beam |
| F10 | 10 | Left-hand high beam |
| F11 | 25 | Right-hand exterior lamps. Left-hand side lamps |
| F12 | 20 | Anti-theft alarm. Battery back-up sounder |
| F13 | 15 | Data link connector. Auxiliary power point relay. Interior lighting |
| F14 | 25 | Daytime running lamps. Direction indicators. Rear fog lamps |
| F15 | 25 | Right-hand side lamps. Left-hand exterior lamps. Central high mounted brake lamp |
| F16 | 20 | Audio control |
| F17 | 7.5 | Heater control. Instrument cluster. Blower motor |
| F18 | 10 | Headlamp switch. Steering wheel module |
| F19 | 5 | Front control/display interface module |
| F20 | 5 | Passive anti-theft system and ignition. Ignition |
| F21 | 3 | Audio front control module. Accessory relay |
Advertisements