Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Ford Taurus (1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse.
Notice
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Instrument Panel Fuse Box Diagram
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses.
| № | A | Protected Circuits |
|---|---|---|
| 7 | 40 | 1999-2002: Rear defrost grid feed |
| 2003-2007 | ||
| Rear defrost grid feed (wagon only) | ||
| Rear defrost relay coil feed (sedan only) | ||
| 20 | 2004-2005: | |
| Rear defrost grid feed (wagon only) | ||
| Rear defrost relay coil feed (sedan only) | ||
| 2006-2007: Rear defrost relay coil feed | ||
| 8 | 40 | Blower Motor |
| 10 | 30 | Circuit Breaker: Power Seats, Delayed Accessory, Adjustable Pedals (1999-2004) |
| 11 | 15 | 1999-2003: Integrated Control Panel (ICP), Rear Washer Wiper Control, Front Washer, Cell Phone, Passenger Switch Illumination, GEM, Rear Wiper Motor |
| 10 | 2004-2006: Right headlamp | |
| 2007: Left headlamp | ||
| 12 | 10 | 1999-2003: Heated Mirrors, Rear Defrost Switch |
| 15 | 2004-2007: Highbeam headlamps | |
| 13 | 20 | 1999-2003: Cigar Lighter, Auxiliary Power Point |
| 2004-2007: Not used | ||
| 14 | — | Not Used |
| 15 | 30 | 1999-2003: Front Wiper Motor |
| 10 | 2004-2006: Left headlamp | |
| 2007: Right headlamp | ||
| 16 | 15 | 1999-2003: Flasher and GEM Power, Integrated Control Panel (ICP) Power, RCC Memory, Cluster |
| 2004-2007: Not used | ||
| 17 | 15 | Stop Lamp, Speed Control Deactivating Switch |
| 18 | 15 | 1999-2003: Not Used |
| 2004-2007: Parklamps, PWM (backlighting), Autolamps | ||
| 19 | 10 | 1999-2003: Not Used |
| 2004-2007: Heated mirrors, Rear defrost switch indicator | ||
| 20 | 10 | 1999-2003: Not Used |
| 2004-2007: Restraints (air bag module/OCS module) | ||
| 21 | 15 | 1999-2003: Not Used |
| 2004-2007: Transmission range sensor (transmission position switch) | ||
| 22 | 20 | 1999-2003: Deck Lid Release Solenoid, Lock/Unlock Relays |
| 15 | 2004-2007: Front washer pump, Electrochromatic mirror, Compass, Cluster (RUN/ACC), Integrated Control Panel (ICP) logic, Rear wiper (wagon only), Rear washer (wagon only) | |
| 23 | 10 | 1999-2003: Air Bag Module, PATS Transceiver |
| 30 | 2004-2007: Front wiper motor | |
| 24 | 15 | 1999-2002: Transit Relay |
| 2003-2007: Not used | ||
| 25 | 2 | 1999-2003: PCM relay, Fuel pump relay (2002-2003) |
| 20 | 2004-2007: Power point | |
| 26 | 10 | 1999-2003: Mirrors, Power Antenna, Pulse Stretcher Module, Deck Lid Lamp, Battery Saver |
| 20 | 2004-2007: Power locks, Liftgate (wagon)/Trunk (sedan) release | |
| 27 | 10 | 1999-2003: Gauges and Warning Lamps, Integrated Control Panel (ICP), FFV Sender, GEM |
| 2004-2007: Anti-lock Brake System (ABS), Speed control, Traction control, Brake-shift interlock, A/C function switch (manual A/C only), Temperature blend door (manual A/C only), Defrost coil | ||
| 28 | 10 | 1999-2003: Blower motor relay coil, EATC logic, Puddle lamps (2002-2003) |
| 15 | 2004-2007: Turn signals, Back-up lamps | |
| 29 | 15 | 1999-2003: Autolamps, Park lamps (2002-2003), PWM (2002-2003), Headlamp switch |
| 20 | 2004-2007: Cigar lighter | |
| 30 | 15 | 1999-2003: Horns and Horn Switch, OBD II Connector |
| 10 | 2004-2007: Courtesy lighting, Battery saver, Power mirrors, Decklid lamp, Power antenna (wagon only), Pulse stretching module (wagon only) | |
| 31 | 10 | 1999-2003: Not Used |
| 2004-2007: Blower motor relay coil, Electronic Automatic Temperature Control (EATC) logic, Puddle lamp | ||
| relay coil | ||
| 32 | 10 | 1999-2003: ABS, DRL Relay Coil, Speed Control Actuator, Traction Control Switch, AC Heater Selector Switch, Blend Door Actuator, Brake Shift Interlock, Rear Defroster Relay Coil (2002-2003) |
| 2004-2007: Cluster, Flex fuel module, ICP logic, Passive anti-theft module (GEM power), Compass | ||
| 33 | 15 | 1999-2003: Not Used |
| 2004-2007: Hazard flasher, Cluster power, ICP power, EATC | ||
| 34 | 5 | 1999-2003: Not Used |
| 2004-2007: GEM logic | ||
| 35 | 10 | 1999-2003: Not Used |
| 2004-2007: Backlighting, Ashtray light (2005-2007) | ||
| 36 | 15 | 1999-2003: Turn Signals, Back-up Lamps |
| 2 | 2004-2007: Powertrain Control Module (PCM) relay, Fuel pump relay, A/C clutch | |
| 37 | 15 | 1999-2003: Transmission Position Switch |
| 25 | 2004-2007: Autolamp, Daytime Running Lamps (DRL), Flash-to-pass, Headlamp switch | |
| 38 | 5 | 1999-2003: GEM Park Neutral Switch |
| 15 | 2004-2007: Horn, Diagnostic connector (OBD II) | |
| 39 | — | Not Used |
| 40 | — | Not Used |
| 41 | — | Not Used |
| 42 | — | Not Used |
| 1 | Accessory Delay Relay | |
| 2 | Driver One Touch Down Relay | |
| 3 | Blower Motor Relay | |
| 4 | Flasher Relay | |
| 5 | Not Used | |
| 6 | Not Used | |
| 9 | Rear Defrost Relay | |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Protected Circuits |
|---|---|---|
| 1 | 60 | Fuse Junction Panel |
| 2 | 30 | Powertrain Control Module (PCM) Relay |
| 3 | 60 | Fuse Junction Panel |
| 4 | 10 | 1999-2003: Not Used |
| 2004-2007: | ||
| Circuit Breaker: Low Speed Cooling Fan | ||
| 5 | 40 | 1999-2003: Not Used |
| 2004-2007: Cooling Fan (Main) | ||
| 6 | — | 1999-2003: Not Used |
| 7 | 40 | Starter Relay, Ignition Switch |
| 8 | 20 | 1999-2002: Transit Relay (Export only) |
| 2003-2007: Not Used | ||
| 9 | 40 | 1999-2003: Cooling Fan Relays |
| 20 | 2004-2007: Cooling Fan (Passenger Side) | |
| 10 | 20 | 1999-2003: Not Used |
| 2004-2007: Cooling Fan (Driver Side) | ||
| 11 | 20 | 1999-2001: Thermactor Relay (FFV only) |
| 2002: Not Used | ||
| 50 | 2003-2007: Rear Defrost | |
| 12 | — | Not Used |
| 13 | 40 | Anti-Lock Brake Module Pump Feed |
| 14 | — | Not Used |
| 15 | 20 | Anti-Lock Brake Module Valve Solenoid |
| 16 | 20 | Fuel Pump Relay |
| 17 | 20 | 1999-2001:Rear Control Unit, CD Changer, Cell Phone |
| 2002-2003: Cell Port | ||
| 2004-2007: CD | ||
| 18 | 20 | 1999-2000: Not Used |
| 2001-2002: Cigar Lighter | ||
| 2003: Power point | ||
| 10 | 2004-2007: | |
| Vulcan engine: A/C clutch relay, PCM keep alive power | ||
| Duratec engine: Not Used | ||
| 19 | 15 | 1999-2003: Right Headlamp |
| 2004-2007: Not Used | ||
| 20 | — | Not Used |
| 21 | 15 | 1999-2003: Left Headlamp |
| 2004-2007: Not Used | ||
| 22 | 10 | Duratec engine: A/C Clutch Relay, PCM Keep Alive Power |
| 5 | Vulcan engine: Heated PCV valve | |
| 26 | 30 | 1999-2000: Generator |
| 10 | 2001-2007: Generator | |
| 27 | 5 | Rear Control Unit, Antenna |
| 28 | 15 | HEGO Sensor Transmission Shift Solenoid, Canister Vent, A/C Clutch Relay, Thermactor Bypass Solenoid (1999-2001) |
| 23 | Starter Motor Relay | |
| 24 | Low Speed Fan Relay | |
| 25 | Wiper Speed Relay | |
| 29 | Wiper Park Relay | |
| 30 | Fuel Pump Relay | |
| 31 | PCM Power Relay | |
| 32 | High Speed Fan Relay | |
| 33 | A/C Clutch Relay | |
Advertisements