Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Ford Scorpio Mk2 (1994, 1995, 1996, 1997, 1998).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Location
- The central junction box is located in the engine compartment on the driver’s side
- The battery junction box is on the passenger’s side.
The junction boxes contain the main fuses and relays. The circuits protected are identified by numbers on the junction box and additionally with symbols on the inside of the cover.
Central Junction Box
To check or renew a fuse or a relay unlock the catches (1) of the cover and lift it off.
| № | A | Circuits protected |
|---|---|---|
| 1 | 15 | Front fog lights, heated exterior mirrors |
| 2 | 5 | Parking light LHD, licence plate light |
| 3 | 10 | Exterior light switch |
| 4 | 10 | Dipped beam right-hand side, headlamp levelling |
| 5 | 10 | Dipped beam left-hand side |
| 6 | 30 | Electrically adjustable seats |
| 7 | 25 | Wiper motors, washer pumps |
| 8 | 5 | Radio |
| 9 | 15 | Horn |
| 10 | 10 | Main beam left-hand side |
| 11 | 10 | Main beam right-hand side |
| 12 | 5 | Parking light RHD |
| 13 | 20 | Ignition lock |
| 14 | 15 | Tail lights, direction indicators, brake lights |
| 15 | 7.5 | Rear fog lights |
| 16 | 7.5 | Electronics |
| 17 | 7.5 | Electronics |
| 18 | 10 | Dim/dipped light RHD |
| 19 | 20 | Headlamp washer |
| 20 | 20 | Heated rear window |
| 21 | 10 | Heated exterior mirrors |
| 22 | 20 | Door locking modules |
| 23 | 5 | Instrument panel light |
| 24 | 15 | Interior lights, audio systems |
| 25 | 30 | Power window |
| 26 | 30 | Power window front |
| 27 | 10 | Air bag, ABS |
| 28 | 30 | Power sunroof, power rear windows |
| 29 | 25 | Heater blower motor |
| R1 | Rear window wiper | |
| R2 | Intermittent wiping (windscreen) | |
| R3 | Dipped beam | |
| R4 | Heated rear window | |
| R5 | Heated rear window | |
| R6 | Main beam | |
| R7 | Dim/dip light (GB) | |
| R8 | Not used | |
| R9 | Fog light | |
| R10 | Horn | |
| R11 | Start inhibitor (automatic transmission) | |
| R12 | Rear door locking | |
| R13 | Bridge | |
| R14 | Daytime running lights (S, N, DK, SF) | |
Advertisements
Battery Junction Box
To check or renew a fuse or a relay unlock the catches (1) of the cover and lift it off.
| № | A | Circuits protected |
|---|---|---|
| 30 | 20 | Self-levelling suspension |
| 31 | 10 | EEC V PCM |
| 32 | - | Not used |
| 33 | 20 | Ignition timing |
| 34 | 15 | Engine management system |
| 35 | 30 | Air conditioning compressor |
| 36 | 10 | Power saver (battery) |
| 37 | 20 | Engine management system |
| 38 | 30 | Heated windscreen right-hand side |
| 39 | 30 | Cooling fan (1/1+2) |
| 40 | 20 | HO2S |
| 41 | 30 | Heated windscreen left-hand side |
| 42 | 15 | Fuel pump |
| 43 | 20 | Cigar lighter, electrically heated seats |
| 44 | 30 | Cooling fan (2) |
| 45 | 10 | Hazard flasher |
| 46 | 30 | ABS module |
| 47 | 30 | ABS module |
| I | 80 | Power supply central junction box |
| II | 60 | Power supply central junction box |
| III | 60 | Power supply central junction box |
| IV | 50 | Diesel glow plug |
| R16 | Power saver (battery) | |
| R17 | Fuel injection pump | |
| R18 | Heated windscreen | |
| R19 | Engine management system | |
| R20 | Self-levelling suspension | |
| R21 | Ignition lock | |
| R22 | Bridge | |
| R23 | Bridge | |
| R24 | Air conditioning | |
| R25 | Not used | |
Auxiliary Relays
| № | Circuits protected | Location |
|---|---|---|
| R26 | Heated seats | Centre console |
| R27 | Power sunroof | Sunroof |
| R28 | Heater blower motor | Retainer behind the glove compartment |
| R29 | Direction indicators | Adjacent to the steering column |
| R30 | ‘‘Trip’’ Switch (windows) | Driver’s door |
| R31 | Headlamp washer | Retainer behind the glove compartment |
| R32 | Diesel glow plug | Engine compartment |
| R33 | Rear window wiper interval | Adjacent to the steering column |
| R34 | Engine cooling fan | Engine compartment |
| R35 | Front fog lights (NL,S) | Underneath the instrument panel |
| R36 | Not used | - |
| R37 | Speed control system | Retainer behind the glovecompartment |
| R38 | Air compressor | Retainer behind the glovecompartment |
Advertisements