Ford Ranger (2004-2012) Fuse Diagram


Fuse box diagram (fuse layout), location, and assignment of fuses and relays Ford Ranger (North America) (2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012).

Ford Ranger (2004-2012)

Checking and Replacing Fuses

Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.

To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.


  • Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
  • Always disconnect the battery before servicing high current fuses.
  • Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
  • Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
  • If a fuse blows again contact a qualified service center.

Passenger Compartment Fuse Box

The fuse panel is located under the right-hand side of the instrument panel behind the kick panel. A fuse puller tool is located near the lower right corner of the fuse box; this tool will assist you in pulling the fuses out for inspection, if necessary.

Passenger Compartment Fuse Box Location

Passenger Compartment Fuse Box Diagram

AProtected circuits
15Instrument panel dimmer switch
210Trailer tow park lamps
310Right low beam headlamp
410Left low beam headlamp
5302004-2007: Windshield wipers/washer
52008-2012: Windshield wiper module (run/accy)
610Radio (RUN/ACCY), Door switch illumination (2008-2012)
752004-2006: Headlamp illumination indicator
810Restraints Control Module (RCM), PADI (Passenger Air bag Deactivation Indicator), Occupant classification sensor (OCS; 2007-2012)
95Cluster air bag indicator
1010Cluster (RUN/START), 4x4 module (RUN/START)
1110Passenger compartment fuse panel (Logic power)
1215Center console subwoofer amplifier, Satellite radio
1315Horn, Interior lamps
1415High beam headlamp, High beam indicator (cluster)
1630Power windows
1715Turn signals/Hazards
18Not used
1920Center High-Mounted Stop Lamp (CHMSL)/Stop lamps
2010Anti-lock Brake System (ABS) module, Brake-shift interlock (2004-2007), Speed control module, Back-up lamps, Overdrive cancel switch, Electronic flasher (turn/hazard)
215Starter relay
2330Headlamps (low and high beam)
2622004-2006: Brake pressure switch
2007-2012: Redundant cruise switch
2710Climate control blower relay/blend doors, 4x4 module (2004-2006)
28154x4 module battery feed (B+)
2920Cigar lighter or power point, Diagnostic connector (OBD II)
305Power mirrors
3120Front park lamps, Rear park lamps, License plate lamps, Dimmer switch, Trailer tow park lamps
325Brake switch (logic)
335Instrument cluster battery feed (B+)
3420Power point
3515Power locks
152004-2007: One-touch down relay
25Accessory relay


Engine Compartment Fuse Box

The power distribution box is located in the engine compartment.

Engine Compartment Fuse Box Location

2.3L engine

Engine Compartment Fuse Box Diagram (2.3L)

3.0L and 4.0L engines

Engine Compartment Fuse Box Diagram (3.0L & 4.0L)

AProtected circuits
1502004: Passenger compartment fuse panel
402005-2012: Passenger compartment fuse panel
2402004-2007: Amplifier (Tremor audio system only)
3502004: Passenger compartment fuse panel
402005-2012: Passenger compartment fuse panel
4Not Used
550Passenger compartment fuse panel
6Not Used
7402004-2007: Starter
302008-2012: Starter
8Not Used
940Ignition switch
10Not Used
1130Powertrain Control Module (PCM), Engine sensors
12Not Used
1330Blower motor (climate control)
14Not Used
15302004: Anti-lock Brake System (ABS) (solenoids)
16Not Used
1740ABS (motor)
18Not Used
19202.3L engine: Engine fan
20Not Used
2110PCM keep alive power, Canister purge valve solenoid (2007-2012)
22Not Used
23202004-2006: Fuel pump
302007-2012: Fuel pump motor, Fuel injectors
24Not Used
2510A/C clutch solenoid
26Not Used
27204x4 module
28Not Used
29302008-2012: Wipers/washer
30Not Used
3115Fog lamps
32302005-2012: Anti-lock brake system (ABS) module
33Not Used
34Not Used
35Not Used
36Not Used
37Not Used
387.5Trailer tow (right turn)
39152007-2012: PCM power
40Not Used
41152004-2006: Heated Exhaust Gas Oxygen (HEGO) sensors, EVAP canister vent valve, Exhaust Gas Recirculation (EGR) stepper motor, Transmission
102007-2012: Automatic transmission
427.5Trailer tow (left turn)
43202007-2012: Engine fan relay coil, A/C relay coil, IAC, Mass air flow sensor, Heated exhaust gas oxygen sensor, Catalyst module sensor, Vapor management valve solenoid
44152007-2012: Ignition coil, Capacitor
45A2004-2007: Wiper HI/LO relay
45B2004-2007: Wiper Park/Run relay
46A2004-2006 (2.3 L): Fuel pump relay
2007-2012 (2.3 L): Fuel pump relay, Fuel injectors relay
3.0L and 4.0L engines: A/C clutch solenoid
46B2004-2007: Washer pump relay
472.3L engine: Engine fan relay
3.0L and 4.0L engines: PCM relay
482.3L engine: Starter relay
48A2004-2006 (3.0 L, 4.0 L): Fuel pump relay
2007-2012 (3.0 L, 4.0 L): Fuel pump relay, Fuel injectors relay
48B3.0L and 4.0L engines: Fog lamp relay
54Powertrain Control Module (PCM) relay
55Blower relay
563.0L and 4.0L engines: Starter relay
56A2.3L engine: A/C clutch solenoid relay
56B2.3L engine: Fog lamp relay