Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Mondeo Mk5 (2014, 2015, 2016, 2017, 2018).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Instrument Panel Fuse Box Diagram
The fuse panel is located under the instrument panel to the left of the steering column (remove the finish trim piece to access).
| № | A | Protected components |
|---|---|---|
| 1 | 10 | Ambient lighting |
| Glove box lamp | ||
| Glove box lamp | ||
| Dome lamp | ||
| Luggage compartment lamp | ||
| 2 | 7.5 | Memory seat |
| Driver seat lower back support | ||
| Panoramic power sunshade (5-door only) | ||
| 3 | 20 | Driver door unlock |
| Fuel flap unlock | ||
| 4 | 5 | Not used (spare) |
| 5 | 20 | Not used (spare) |
| 6 | 10 | Not used (spare) |
| 7 | 10 | Not used (spare) |
| 8 | 10 | Anti-theft alarm horn |
| 9 | 10 | Not used (spare) |
| 10 | 5 | Power liftgate module |
| 11 | 5 | Combined security module |
| 12 | 7.5 | Front control integration module (climate and radio control) |
| 13 | 7.5 | Steering wheel column |
| Instrument cluster | ||
| Data link connector | ||
| 14 | 10 | Not used (spare) |
| 15 | 10 | Datalink gateway module |
| 16 | 15 | Child lock |
| Luggage compartment-liftglass release | ||
| 17 | 5 | Battery backed-up sounder |
| 18 | 5 | Ignition switch |
| Push button ignition switch | ||
| 19 | 7.5 | Passenger airbag deactivation indicator |
| 20 | 7.5 | Headlamp control module |
| 21 | 5 | Passenger compartment thermometer |
| Humidity sensor | ||
| 22 | 5 | Not used (spare) |
| 23 | 10 | Delayed accessory power |
| 24 | 20 | Central lock unlock |
| 25 | 30 | Driver door window |
| Driver door mirror | ||
| 26 | 30 | Front passenger door window |
| Front passenger door mirror | ||
| 27 | 30 | Moonroof |
| 28 | 20 | Amplifier |
| 29 | 30 | Rear driver side door window |
| 30 | 30 | Rear passenger side door window |
| 31 | 15 | Not used (spare) |
| 32 | 10 | Global positioning system module |
| Voice control (SYNC) | ||
| Information and entertainment display | ||
| Radio frequency receiver | ||
| 33 | 20 | Radio |
| 34 | 30 | Run/start bus (fuse #19, 20, 21, 22, 35, 36, 37, circuit breaker). |
| 35 | 5 | Restraints control module |
| 36 | 15 | Auto-dimming interior mirror |
| Front and rear heated seat module | ||
| Continuous control damping suspension | ||
| Lane keeping system | ||
| Auto high beam | ||
| Climate controlled seats | ||
| 37 | 15 | All wheel drive module |
| Heated steering wheel | ||
| 38 | 30 | Not used (spare) |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment. It has high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Protected components |
|---|---|---|
| 1 | 25 | RH front wiper motor |
| 3 | 15 | Rain sensor |
| Rear wipers | ||
| 5 | 20 | Power point 3 - Back of console |
| 7 | 20 | Powertrain control module |
| 8 | 20 | Powertrain control module |
| 10 | 20 | Power point 1 - driver front |
| 11 | 15 | Powertrain control module |
| 12 | 15 | Powertrain control module |
| 13 | 10 | Powertrain control module |
| 14 | 10 | Powertrain control module |
| 16 | 20 | Power point 2 - console |
| 17 | 20 | Trunk auxiliary power point (wagon only) |
| 18 | 10 | Powertrain control module |
| 19 | 10 | Run-start electronic power assist steering |
| 20 | 10 | Headlamps |
| Headlamp switch | ||
| 21 | 15 | Transmission control module |
| Transmission oil pump | ||
| Hybrid electric vehicle inverter. | ||
| 22 | 10 | Air conditioner clutch solenoid |
| 23 | 15 | Blind spot monitor |
| Rear view camera | ||
| Adaptive Cruise Control | ||
| Pre-collision warning indicator | ||
| Voltage quality module | ||
| Air quality sensor | ||
| 24 | 10 | Not used |
| 25 | 10 | Anti-lock brake system |
| 26 | 10 | Powertrain control module |
| 27 | — | Not used |
| 28 | 10 | Rear washer pump |
| 29 | — | Not used |
| 30 | — | Not used |
| 31 | — | Not used |
| 34 | 15 | Electric steering column lock |
| 35 | — | Not used |
| 36 | — | Not used |
| 37 | — | Not used |
| 43 | — | Not used |
| 44 | 5 | Heated washer nozzle |
| 45 | — | Not used |
| 46 | 10 | Alternator |
| 47 | 10 | Brake on-off switch |
| 48 | 20 | Horn |
| 49 | 5 | Mass air flow monitor |
| 20 | Diesel: Fuel heater element | |
| 50 | 10 | Power transfer unit cooling fan |
| 51 | — | Not used |
| 52 | — | Not used |
| 53 | 10 | Power seats |
| 54 | 5 | Fuel operated heater remote control |
| 55 | 5 | Not used (spare) |
| 2 | Starter relay | |
| 4 | Blower motor relay | |
| 6 | Auxiliary heater relay | |
| 9 | Powertrain control module relay | |
| 15 | Run-start relay | |
| 32 | Electronic fan 1 relay | |
| 33 | A/C clutch relay | |
| 38 | Electronic fan 2 relay | |
| 39 | Electronic fan coil 2 and 3 relay | |
| 40 | Not used | |
| 41 | Horn relay | |
| 42 | Fuel pump coil relay | |
Advertisements
Bottom of the Power Distribution Box
There are fuses located on the bottom of the fuse box. To access the bottom of the fuse box, do the following:
- Release the two latches, located on both sides of the fuse box.
- Raise the inboard side of the fuse box from the cradle.
- Move the fuse box toward the center of the engine compartment.
- Pivot the outboard side of the fuse box to access the bottom side.
| № | A | Protected components |
|---|---|---|
| 56 | — | Not used |
| 57 | 20 | Diesel vaporizer |
| 58 | 30 | Fuel pump feed |
| 59 | 30 | Electronic fan 3 |
| 40 | Cooling fan (DW10F and 2.0L GTDI AU) | |
| 60 | 30 | Electronic fan 1 |
| 40 | Cooling fan (DW10F and 2.0L GTDI AU) | |
| 61 | 40 | Left-hand heated windshield element |
| 62 | 50 | Body control module 1 |
| 63 | 25 | Electronic fan 2 |
| 30 | Cooling fan (DW10F and 2.0L GTDI AU) | |
| 64 | 30 | Auxiliary heater. |
| 65 | 20 | Front heated seat |
| 66 | 40 | Right-hand heated windshield element. |
| 67 | 50 | Body control module 2 |
| 68 | 40 | Heated rear window |
| 69 | 30 | Anti-lock brake system valves |
| 70 | 30 | Passenger seat |
| 71 | 60 | Auxiliary heater. |
| 72 | 30 | Moonroof |
| 73 | 20 | Rear heated seats |
| 74 | 30 | Driver seat module |
| 75 | 30 | Auxiliary heater |
| 76 | 20 | Transmission oil pump |
| 77 | 30 | Climate control seat module |
| 78 | 40 | Trailer tow module |
| 79 | 40 | Blower motor |
| 80 | 30 | Power luggage compartment module |
| 81 | 40 | Inverter |
| 82 | 60 | Anti-lock brake system pump. |
| 83 | 25 | RH front wiper motor |
| 84 | 30 | Starter solenoid |
| 85 | 20 | Fuel fire heater |
Advertisements