Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses Ford Mondeo Mk4 (2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Location
- The engine compartment
- The passenger compartment
- The luggage compartment
Passenger Compartment Fuse Box
The central fuse box is located below the glove box.
To access:
- Pinch the retaining clips to release the cover.
- Remove the cover.
- Turn the knob through 90 degrees and release the fuse box from the retaining bracket.
- Lower the fuse box cover and pull it towards you.
- Install in the reverse order.
Diagram 2007-2010
| № | A | Protected components |
|---|---|---|
| F1 | 5 | Rain sensor |
| F2 | 10 | SRS (airbag) supply |
| F3 | 5 | Yaw rate sensor (ESP) |
| F4 | 7.5 | Electronic feed, accelerator pedal supply, brown electronic fuse |
| F5 | 15 | Rear window wiper |
| F6 | 15 | Audio system (including voice control) |
| F7 | 7.5 | Steering wheel module |
| F8 | 5 | Instrument cluster |
| F9 | 15 | Main beam |
| F10 | 20 | Power sunroof |
| F11 | 7.5 | Reversing lamps |
| F12 | - | Not used |
| F13 | 15 | Front fog lamp |
| F14 | 15 | Windscreen washers |
| F15 | 10 | Adaptive cruise control (ACC) |
| F16 | - | Not used |
| F17 | 10 | Interior lamps |
| F18 | 5 | Engine immobiliser |
| F19 | 15 | Cigar lighter |
| F20 | - | Not used |
| F21 | 5 | Remote frequency receiver, Interior motion tan sensor |
| F22 | 20 | Fuel pump |
| 7.5 | Fuel pump (2.2L Duratorq) | |
| F23 | - | Not used |
| F24 | 5 | Ignition switch |
| F25 | 10 | Fuel filler flap |
| F26 | 5 | Battery backup sounder (alarm system), OBD II (board computer diagnostics) |
| F27 | 5 | Steering column unit, climate control module |
| F28 | 5 | Brake lamp switch |
Advertisements
Diagram 2010-2014
| № | A | Protected components |
|---|---|---|
| F1 | 7.5 | Steering wheel module |
| F2 | 5 | Cluster |
| F3 | 10 | Interior lamps |
| F4 | 5 | Engine immobiliser |
| F5 | 7.5 | Adaptive cruise control (ACC) |
| F6 | 5 | Rain sensor |
| F7 | 20 | Cigar lighter |
| F8 | 10 | Fuel filler flap unlock supply |
| F9 | 15 | Windscreen washers - rear |
| F10 | 15 | Windscreen washers - front |
| F11 | 10 | Luggage compartment release supply |
| F12 | 10 | Fuel filler flap lock supply |
| F13 | 20 | Fuel pump |
| 7.5 | Fuel pump (2.2L Duratorq-TDCi Stage V) | |
| F14 | 5 | Remote frequency receiver, Interior motion sensor |
| F15 | 5 | Ignition switch |
| F16 | 5 | Battery backup sounder (alarm system), OBD II (board computer diagnostics) |
| F17 | 5 | Steering wheel vibration actuator |
| F18 | 10 | SRS (airbag) supply |
| F19 | 7.5 | ABS, yaw rate sensor (ESP), electric parking brake (EPB), accelerator pedal supply |
| F20 | 7.5 | Electronic feed, electronic fuse, Auto-dimming mirror, lane departure warning |
| F21 | 15 | Radio supply |
| F22 | 5 | Brake lamp switch |
| F23 | 20 | Sunroof |
| F24 | 5 | Climate Control Module and Steering Column Unit supply |
Engine Compartment Fuse Box
| № | A | Protected components |
|---|---|---|
| F1 | 10 | 2010-2014: |
| AWF21: Transmission control module | ||
| 15 | 2010-2014: | |
| MPS6: Transmission control module | ||
| 10 | 2007-2010: Transmission control module | |
| F2 | 5 | Diesel: Glow plug monitoring, vaporiser glow plug monitoring (2010-2014: 2.0L Duratorq-TDCi Stage V и 2.2L Duratorq-TDCi Stage V) |
| F3 | 70 | 2.3L Duratec-HE and 2.2L Duratorq-TDCi automatic: Engine cooling fan - twin fan |
| 80 | Electric hydraulic power steering (EHPAS) (1.6L Duratec-16V Ti-VCT Stage V, 1.6L EcoBoost SCTi, 2.0L EcoBoost SCTi, 1.6L Duratorq-TDCi Stage V and 2.0L Duratorq-TDCi Stage V, 2,0L Duratorq-TDCi) | |
| F4 | 60 | Glow plugs |
| F5 | 60 | Engine cooling fan (1.6L Duratorq-TDCi, 2.0L Duratorq-TDCi, 2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi (МКПП), 1.6L Duratec-16V Ti-VCT Stage V, 2.0L Duratec-HE, 2.3L Duratec-HE and 2.0L EcoBoost SCTi) |
| 70 | 1.6L EcoBoost SCTi: Engine cooling fan - twin fan | |
| F6 | 7.5 | 1.6L Duratorq-TDCi: HEGO sensor |
| 10 | 2010-2014: HEGO sensors 1, CMS sensor, Oxygen sensor (engine management) | |
| 2007-2010: HEGO sensors 1 (engine management), variable valve timing (engine management) | ||
| 20 | 2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi Stage V: Vaporiser glow plug | |
| F7 | 5 | Relay coils |
| F8 | 10 | Powertrain control module, Fuel metering unit, MAF sensor, fuel rail pressure control valve (engine management) |
| 20 | 2.0L EcoBoost SCTi and 2.0L Duratorq-TDCi Stage V: Powertrain control module | |
| 15 | 1.6L EcoBoost SCTi, 1.6L Duratorq-TDCi and 2.2L Duratorq-TDCi Stage V: Powertrain control module | |
| F9 | 10 | 2010-2014: MAF Sensor, Fuel Injectors, Variable Intake Valve, Variable Exhaust Valve, ignition coils (engine management) |
| 5 | 2,0L Duratorq-TDCi Stage V: Fuel pump vaporiser | |
| 7.5 | 2,2L Duratorq-TDCi Stage V: MAF Sensor, EGR bypass Valve , Fuel pump vaporiser | |
| 7.5 | 1.6L EcoBoost SCTi: Degas valve, TMAF sensor, active grille shutter, bypass valve, relay coil, auxiliary run on, water pump | |
| F10 | 10 | 2.0L Duratorq-TDCi, 1.6L Duratec-16V Ti-VCT Stage V: Powertrain control module |
| 2007-2010: Powertrain control module | ||
| 7.5 | 1.6L EcoBoost SCTi: Auxiliary run on, water pump | |
| F11 | 10 | 2010-2014: PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic Purge Valve, Swirl Control Valve, Variable Intake Valve, EGR Valve, IVVT Oil Control Valve (engine management), T.MAF sensor, variable exhaust timing valve, active grille shutter, cannister purge valve, turbo control valve, waste gate valve (engine management) |
| 2007-2010: Valves, MAF control (engine management) | ||
| 10 | 1.6L Duratorq-TDCi: Turbo control valve, MAF sensor, active grille shutter, EGR valve, VCV valve | |
| 5 | 2.0L Duratorq-TDCi Stage V: MAF sensor, Water in Fuel Sensor, Active grille shutter, inlet metering valve | |
| 7.5 | 2.2L Duratorq-TDCi Stage V: Fuel rail pressure, fuel metering unit, fuel pump vaporiser, active grille shutter | |
| 10 | 1.6L EcoBoost SCTi: Turbo control valve, variable intake timing valve, variable exhaust timing valve, cannister purge valve, electrical bypass valve | |
| F12 | 15 | 1.6L EcoBoost SCTi and 2.0L EcoBoost SCTi: Ignition coils |
| 10 | 2010-2014: Coil on Plug; Canister Purge Valve, Power Steering Pressure Switch (engine management) | |
| 2007-2010: Water in fuel sensor, coils, MAF (engine management, diesel engine) | ||
| 10 | 2.0L Duratorq-TDCi: EGR throttle, variable turbo control | |
| 5 | 2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi Stage V and 1.6L Duratorq-TDCi: Relay coils | |
| F13 | 15 | Air conditioning |
| F14 | 15 | 2.0L Duratorq-TDCi, 2.0L Duratorq-TDCi Stage V and 1.6L Duratorq-TDCi: Diesel filter heater |
| 10 | 2.2L Duratorq-TDCi Stage V: HEGO sensor | |
| F15 | 40 | Starter relay |
| F16 | 80 | Diesel auxiliary heater (PTC) |
| F17 | 60 | Central fuse box supply A |
| F18 | 60 | Central fuse box supply B |
| F19 | 60 | Rear fuse box supply C |
| F20 | 60 | Rear fuse box supply D |
| F21 | 30 | 2010-2014: Cluster/Audio/AC/FLR |
| F22 | 30 | Windscreen wiper module |
| F23 | 30 | 2010-2014: Heated rear window |
| 25 | 2007-2010: Heated rear window | |
| F24 | 30 | Headlamp washer |
| F25 | 30 | ABS valves |
| F26 | 40 | ABS pump |
| F27 | 25 | Heater blower |
| F28 | 40 | Heater blower |
| F29 | – | Not used |
| F30 | 5 | 2010-2014: ABS 30 feed |
| F31 | 15 | Horn |
| F32 | 5 | Fuel fired heater - remote control |
| F33 | 5 | Light switch module, engine compartment fuse box coils |
| F34 | 40 | Heated windscreen (left-hand side) |
| F35 | 40 | Heated windscreen (right-hand side) |
| F36 | 15 | 2010-2014: Rear wiper 15 feed |
| 5 | 2007-2010: ABS | |
| F37 | 7.5 | 2010-2014: Heated front washer jets/FLR + FSM KL15 |
| 10 | 2007-2010: Heated front washer jets | |
| F38 | 10 | 2010-2014: PCM/TCM/EHPAS 15 feed |
| 5 | 2007-2010: Adaptive cruise control (ACC) | |
| F39 | 15 | Adaptive front lighting system (AFS) |
| F40 | 5 | 2010-2014: Headlamp levelling / AFS module |
| F41 | 20 | Instrument panel |
| F42 | 5 | 2010-2014: Cluster IP |
| 10 | 2007-2010: Engine control module, transmission control module, electric hydraulic power steering (EHPAS) 15 feed | |
| F43 | 15 | 2010-2014: Audio/BVC module/DAB module |
| 5 | 2007-2010: Headlamp levelling, adaptive front lighting system (AFS) | |
| F44 | 5 | 2010-2014: Automatic AC / Manual AC |
| 20 | 2.5L Duratec-HE: Vacuum pump | |
| F45 | 5 | 2010-2014: FLR (Start Stop) |
| 15 | 2007-2010: Rear window wiper |
Advertisements
Luggage Compartment Fuse Box
The rear fuse block is located behind the cover on the left-hand side of the luggage compartment.
4-door and 5-door
- Remove the cover.
- Remove the relevant fuse box cover.
Wagon
- Release the catches.
- Remove the cover.
- Remove the relevant fuse box cover.
| № | A | Protected components |
|---|---|---|
| FA1 | 25 | Door module (left-hand front) (window up/down, central locking, electric folding mirror, heated mirror) |
| FA2 | 25 | Door module (right-hand front) (window up/down, central locking, electric folding mirror, heated mirror) |
| FA3 | 25 | Door module (left-hand rear) (window up/down) |
| FA4 | 25 | Door module (right-hand rear) (window up/down) |
| FA5 | 10 | Rear locking (without rear door modules) |
| FA6 | 15 | Auxiliary power socket |
| FA7 | 5 | Relay coils |
| FA8 | 20 | 2010-2014: Keyless vehicle module |
| 2007-2010: Steering column lock | ||
| FA9 | 5 | 2010-2014: Relay coils VQM (Start Stop) |
| FA10 | 30 | 2007-2010: Electric driver's seat |
| FA11 | 20 | Accessories, trailer module |
| FA12 | 30 | 2010-2014: Electric driver's seat |
| FB1 | 5 | 2007-2010: Parking aid module |
| FB2 | 15 | Suspension module |
| FB3 | 15 | Heated driver's seat |
| FB4 | 15 | Heated front passenger seat |
| FB5 | 15 | Left-hand rear heated seat |
| FB6 | - | Not used |
| FB7 | 15 | Right-hand rear heated seat |
| FB8 | 5 | 2010-2014: Parking aid, BLIS |
| FB9 | 30 | Electric front passenger seat |
| FB10 | 10 | Anti-theft alarm horn |
| FB11 | – | Not used |
| FB12 | – | Not used |
| FC1 | - | Not used |
| FC2 | - | Not used |
| FC3 | - | Not used |
| FC4 | - | Not used |
| FC5 | 20 | 2010-2014: Keyless vehicle |
| 7.5 | 2007-2010: CD changer, rear seat entertainment system | |
| FC6 | - | Not used |
| FC7 | 5 | Seat memory function module |
| FC8 | 7.5 | 2010-2014: Rear seat entertainment/CD Changer |
| 20 | 2007-2010: Keyless entry | |
| FC9 | 20 | 2010-2014: Audio amplifier |
| FC10 | 10 | 2010-2014: Sony audio system |
| FC11 | – | Not used |
| FC12 | – | Not used |
Advertisements