Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Fusion (2006, 2007, 2008, 2009).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Instrument Panel Fuse Box Diagram
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses.
| № | A | Circuits protected |
|---|---|---|
| 1 | 10 | Backup lamps (automatic transmission), Electrochromatic mirror |
| 2 | 20 | Horns |
| 3 | 15 | Battery saver: Interior lamps, Puddle lamps, Trunk lamp, Power windows |
| 4 | 15 | Parklamps, Side markers, License plate lamps |
| 5 | — | Not used |
| 6 | — | Not used |
| 7 | — | Not used |
| 8 | 30 | Rear window defroster |
| 9 | 10 | Heated mirrors |
| 10 | 30 | Starter coil, PCM |
| 11 | 15 | High beams |
| 12 | 7.5 | Delay accessories: Radio head units, Moon roof, Lock switch illumination, Electrochromatic mirrors, Ambient lighting |
| 13 | 7.5 | Cluster, Analog clock, Climate control head units |
| 14 | 15 | Washer pump |
| 15 | 20 | Cigar lighter |
| 16 | 15 | Door lock actuator, Decklid lock solenoid |
| 17 | 20 | Subwoofer |
| 18 | 20 | Radio head units, OBDII connector |
| 19 | 7.5 | Not used (Spare) |
| 20 | 7.5 | Power mirrors, Satellite radio module, All wheel drive |
| 21 | 7.5 | Stop lamps, CHMSL |
| 22 | 7.5 | Audio |
| 23 | 7.5 | Wiper relay coil, Cluster logic |
| 24 | 7.5 | OCS (Passenger’s seat), PAD indicator |
| 25 | 7.5 | RCM |
| 26 | 7.5 | PATS Transceiver, Brake shift interlock solenoid, Brake pedal switch, Automatic transmission relay coil, Reverse switch (back-up lamps for manual transmission) |
| 27 | 7.5 | Cluster, Climate control head units |
| 28 | 10 | ABS/Traction Control, Heated seats, Compass, Reverse sensing system |
| C/B | 30 | Circuit Breaker: Moon roof power, Delayed accessory (SJB fuse 12, power window) |
Advertisements
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment. It contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Diagram 2006
| № | A | Circuits protected |
|---|---|---|
| 1 | 60 | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 40 | Powertrain power |
| 3 | — | Not used |
| 4 | 40 | Blower motor |
| 5 | — | Not used |
| 6 | 40 | Rear window defroster, Heated mirrors |
| 7 | 40 | PETA Pump (PZEV engine only) |
| 8 | — | Not used |
| 9 | 20 | Wipers |
| 10 | 20 | ABS Valves |
| 11 | 20 | Heated seats |
| 12 | — | Not used |
| 13 | — | Not used |
| 14 | 15 | Ignition switch |
| 15 | — | Not used |
| 16 | 15 | Transmission |
| 17 | 20 | Console power point |
| 18 | 10 | Alternator sense |
| 19 | 40 | Logic feed to SJB (solid state devices) |
| 20 | — | Not used |
| 21 | — | Not used |
| 22 | — | Not used |
| 23 | 60 | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C Compressor clutch |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | — | Not used |
| 29 | 50 | Engine cooling fan |
| 30 | 30 | Fuel pump relay feed |
| 31 | — | Not used |
| 32 | 30 | Driver power seat |
| 33 | 20 | Moonroof |
| 34 | — | Not used |
| 35 | — | Not used |
| 36 | 40 | ABS Pump |
| 37 | — | Not used |
| 38 | — | Not used |
| 39 | — | Not used |
| 40 | — | Not used |
| 41 | — | Not used |
| 42 | 15 | PCM non-emission related |
| 43 | 15 | Coil on plug |
| 44 | 15 | PCM emission related |
| 45 | 5 | PETA Pump feedback (PZEV engine only) |
| 46 | 15 | Injectors |
| 62 | - | Circuit Breaker: Spare |
| 60 | Fuel pump | |
| 61 | Not used | |
| 47 | Fog lamps | |
| 48 | Not used | |
| 49 | Not used | |
| 50 | Wiper Park | |
| 51 | A/C Clutch | |
| 52 | Not used | |
| 53 | Wiper RUN | |
| 54 | Transmission (I4 engine only) | |
| 55 | Fuel pump | |
| 56 | Blower motor | |
| 57 | PCM | |
| 58 | PETA Pump (PZEV engine only) | |
| 59 | Not used | |
Advertisements
Diagram 2007-2009
| № | A | Circuits protected |
|---|---|---|
| 1 | 60 | SJB power feed (fuses 12, 13, 14, 15, 16, 17, 18, C/B) |
| 2 | 60 | SJB power feed (fuses 1, 2, 4, 10, 11) |
| 3 | 40 | Powertrain power, PCM relay coil |
| 4 | 40 | Blower motor |
| 5 | — | Not used |
| 6 | 40 | Rear window defroster, Heated mirrors |
| 7 | 40 | PETA Pump (PZEV) power feed |
| 8 | 40 | ABS pump |
| 9 | 20 | Wipers |
| 10 | 30 | ABS Valves |
| 11 | 20 | Heated seats |
| 12 | — | Not used |
| 13 | 10 | SYNC |
| 14 | 15 | Ignition switch |
| 15 | — | Not used |
| 16 | 15 | Transmission |
| 17 | 10 | Alternator sense |
| 18 | — | Not used |
| 19 | 40 | Logic feed to SJB (solid state devices) |
| 20 | — | Not used |
| 21 | — | Not used |
| 22 | 20 | Console power point |
| 23 | 10 | PCM KAM, FNR5 and canister vent solenoid |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C Compressor clutch |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 60 | Engine cooling fan |
| 29 | — | Not used |
| 30 | 30 | Fuel pump/injectors relay |
| 31 | — | Not used |
| 32 | 30 | Driver power seat |
| 33 | 20 | Moon roof |
| 34 | — | Not used |
| 35 | — | Not used |
| 36 | 1 | PCM diode |
| 37 | 1 | One Touch Integrated Start (OTIS) diode |
| 38 | — | Not used |
| 39 | — | Not used |
| 40 | — | Not used |
| 45 | 5 | PETA Pump (PZEV) feedback |
| 46 | 15 | Injectors |
| 47 | 15 | PCM class B |
| 48 | 15 | Coil on plug |
| 49 | 15 | PCM class C |
| 41 | Fog lamp relay | |
| 42 | Wiper park relay | |
| 43 | A/C clutch relay | |
| 44 | FNR5 transmission relay | |
| 50 | Not used | |
| 51 | Not used | |
| 52 | Blower relay | |
| 53 | Not used | |
| 54 | Fuel pump/injectors relay | |
| 55 | Wiper RUN relay | |
| 56 | Not used | |
| 57 | PCM relay | |
| 58 | PETA Pump (PZEV) | |
Advertisements