Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Focus Mk2 (2004, 2005, 2006, 2007, 2008, 2009, 2010).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
The fuse panel is located below the glove box.
To access:
- Remove the screws in the instrument panel trim underneath the glove compartment and lower the trim panel.
- Loosen the screws.
- Lower the fuse box and pull it towards you.
Diagram 2004-2007
| № | A | Protected components |
|---|---|---|
| 37 | 10 | Left-hand headlight (high beam) |
| 38 | 10 | Right-hand headlight (high beam) |
| 39 | 20 | Cigar lighter, rear auxiliary power socket |
| 40 | 20 | Sliding roof |
| 41 | 20 | Door module (passenger door) |
| 42 | 7.5 | Outside rear view mirror defoggers |
| 43 | 10 | Electronic modules (battery supply) |
| 44 | 10 | OBD II (board computer diagnostics) |
| 45 | 10 | Daytime running lights |
| 46 | 10 | Instrument cluster, GEM module |
| 47 | 15 | Washer pump, heated washer nozzles |
| 48 | 20 | Low beam headlights, daytime running lights |
| 49 | 15 | Headlight switch |
| 50 | 20 | Windshield wiper |
| 51 | 15 | Fuel pump |
| 52 | 25 | Rear window defroster |
| 53 | 7.5 | Parking lamps, side lamps, tail lamps (left-hand side) |
| 54 | 7.5 | Parking lamps, side lamps, tail lamps (right-hand side) |
| 55 | 20 | Door module (driver door), central locking system |
| 56 | 20 | Keyless entry system |
| 57 | 10 | Alarm horn |
| 58 | 15 | Audio modules (battery supply) |
| 59 | 25 | Luggage compartment auxiliary power socket, trailer tow module |
| 60 | 15 | Right-hand headlight (low beam) |
| 61 | 15 | Left-hand headlight (low beam) |
| 62 | 20 | Power seat (driver side) |
| 63 | 25 | Power windows |
| 64 | - | Not used |
| 65 | 10 | Airbag module |
| 66 | 7.5 | Headlight adjustment switch, low beam headlights, xenon module |
| 67 | 10 | Immobilizer module (WFS), instrument cluster (ignition supply) |
| 68 | 7.5 | Radio, instrument cluster |
| 69 | 20 | Fog light |
| 70 | 10 | Electronic modules (ignition supply) |
| 71 | 10 | Daytime running lights |
| 72 | 25 | GEM |
| 73 | 7.5 | Number plate lights |
| 74 | 15 | Stop light |
| 75 | 10 | Transmission control module, accelerator pedal |
| 76 | 7.5 | Electric parking brake (EPB) |
| 77 | 25 | Central locking relays |
| 78 | 15 | Rear window wiper |
| 79 | 15 | Folding mirror |
| 80 | 10 | Interior lights, outside rear view mirrors |
| 81 | 20 | Door module (right-hand rear) |
| 82 | 20 | Door module (left-hand rear) |
| 83 | 10 | CD-changer, rear seat entertainment (RSE) |
| 84 | 10 | Back-up light, trailer tow module |
| 85 | 10 | Cooling system |
| 86 | 20 | Seat heater |
| K1 | Rear window defroster | |
| K4 | Fuel pump | |
| K5 | Daytime running lights | |
Advertisements
Diagram 2007-2010
| № | A | Protected components |
|---|---|---|
| 100 | 10 | Electronic modules ignition supply |
| 101 | 20 | Electric sunroof control module, driver’s electric seat, |
| 102 | 10 | Heater control, steering column, diesel particulate filter, remote control receiver |
| 103 | 10 | Lighting control battery supply |
| 104 | 10 | Battery saver, interior lamps |
| 105 | 25 | Heated rear window |
| 106 | 20 | Keyless system |
| 107 | 10 | Instrument cluster battery supply, on-board diagnostics |
| 108 | 7.5 | Accessory to cluster (audio and navigation unit) |
| 109 | 20 | Cigar lighter, rear auxiliary power socket |
| 110 | 10 | Daytime running lights ignition supply to lighting control switch |
| 111 | 15 | Fuel pump (petrol engine only) |
| 112 | 15 | Audio modules battery supply |
| 113 | 10 | Daytime running lights (parking lamps) |
| 114 | 10 | Instrument cluster ignition supply, engine immobiliser |
| 115 | 7.5 | Lighting control ignition supply |
| 116 | 20 | Fog lamps |
| 117 | 7.5 | Number plate lamps |
| 118 | 20 | Door module, left-hand rear |
| 119 | 15 | Luggage compartment auxiliary power socket |
| 119 | 25 | Luggage compartment auxiliary power socket (vehicles with trailer tow module) |
| 120 | 20 | Door module, right-hand rear |
| 121 | 20 | Heated front seats |
| 122 | 10 | Airbag module |
| 123 | 7.5 | Heated exterior mirrors |
| 124 | 7.5 | Parking lamps, side lamps, tail lamps (left-hand side) |
| 125 | 7.5 | Parking lamps, side lamps, tail lamps (right-hand side) |
| 126 | 20 | Keyless system |
| 127 | 25 | Electric windows |
| 128 | - | Not used |
| 129 | 20 | Windscreen wipers |
| 130 | - | Not used |
| 131 | 15 | Rear window wiper |
| 132 | 15 | Brake lamps |
| 133 | 25 | Central locking relays, passenger door module |
| 134 | 20 | Central locking, driver door module |
| 135 | 20 | Daytime running lights |
| 136 | 15 | Washer pump, heated washer jets |
| 137 | 10 | Battery backup sounder |
| 138 | 10 | Powertrain control module, accelerator pedal, automatic transmission |
| 139 | 10 | Right-hand headlight (high beam) |
| 140 | 10 | Left-hand headlight (high beam) |
| 141 | 10 | Reversing lamp, electric mirrors |
| 142 | 15 | Right-hand headlight (low beam) |
| 143 | 15 | Left-hand headlight (low beam) |
| R1 | Fuel pump | |
| R2 | Not used | |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Protected components |
|---|---|---|
| 1 | 60 | 2004-2007: Cooling fan |
| 40 | 2007-2010: Cooling fan | |
| 2 | 80 | Power steering |
| 3 | 60 | Passenger compartment fuse box supply 1 |
| 4 | 60 | Passenger compartment fuse box supply 2 |
| 5 | 80 | Auxiliary heater |
| 6 | 60 | Diesel: Glow plug |
| 7 | 30 | ABS, stability control pump |
| 8 | 20 | ABS, stability control valves |
| 9 | 20 | Powertrain control module |
| 10 | 30 | Climate control blower |
| 11 | 20 | Ignition switch |
| 12 | 40 | Ignition relay 15l |
| 13 | 20 | Starter solenoid |
| 14 | 40 | Heated windscreen, right-hand side |
| 15 | 30 | Cooling fan relay (Sigma - non A/C only) |
| 16 | 40 | Heated windscreen, left-hand side |
| 17 | 30 | Electric parking brake |
| 18 | 30 | Power inverter |
| 19 | 10 | ABS module |
| 20 | 15 | Horn |
| 21 | 20 | Diesel: Auxiliary heater |
| 22 | 10 | Power steering module |
| 23 | 30 | Headlamp washer |
| 24 | 15 | Diesel: Pre-heating |
| 25 | 10 | Ignition, relays |
| 26 | 10 | 2004-2007: Automatic transmission |
| 15 | 2007-2010: Automatic transmission | |
| 10 | ST, RS: PCM continuous supply | |
| 27 | 10 | Air conditioning clutch |
| 28 | 10 | Diesel: Glow plug monitoring |
| 29 | 10 | Dual zone climate control |
| 30 | 3 | Powertrain control module, automatic transmission |
| 31 | 10 | Battery sensor smart charging |
| 32 | 10 | 2004-2007: 16V+VCT: Ventilation |
| 10 | 2007-2010: Automatic transmission | |
| 10 | ST, RS: Fuel injector power supply | |
| 33 | 10 | Petrol: Heated oxygen sensors |
| 10 | Diesel: Intercooler bypass valve | |
| 20 | ST, RS: Heated oxygen sensor | |
| 34 | 10 | Petrol: Injectors, ignition transformers |
| 10 | Diesel (2004-2007): Fuel pump | |
| 35 | 10 | Powertrain control module, valves, solenoids |
| 36 | 10 | Powertrain control module |
| R1 | Start lock (automatic transmission) | |
| R2 | Horn | |
| R3 | Back-up light (automatic transmission) | |
| R4 | - | |
| R5 | Diesel: Pre-heating | |
| 16V+VCT: Ventilation | ||
| R6 | Main | |
| R7 | Heated windscreen | |
| R8 | Ignition | |
| R9 | Headlamp washer | |
| R10 | Heater blower | |
| R11 | Air conditioning | |
| R12 | Cooling fan (without air conditioning) | |
| R13 | Starter | |
| R14 | Power hold | |
| Cooling fan | ||
Advertisements