Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Five Hundred / 500 (2004, 2005, 2006, 2007).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The fuse panel is located under the instrument panel to the left of the steering wheel.
| № | A | Fused function |
|---|---|---|
| F1 | 20 | High beams |
| F2 | 15 | Interior lamps (Courtesy and demand lamps), Delayed accessory (Power windows and moonroof) |
| F3 | 25 | Access/Security (Power door lock actuators, Decklid lock actuator, Decklid solenoid) |
| F4 | 15 | Adjustable pedal switch |
| F5 | 20 | Horns |
| F6 | 20 | Audio (Subwoofer) |
| F7 | 7.5 | Power/Keep Alive Memory (KAM): Cluster and Powertrain Control Module (PCM), Climate control, Analog clock |
| F8 | 15 | Park lamps, Side markers, Trailer tow protect |
| F9 | 20 | Cigar lighter, Data Link Connector (DLC) |
| F10 | 7.5 | Mirrors and memory module, SDARS |
| F11 | 20 | Audio, Family Entertainment System (FES) |
| F12 | 10 | Back-up lamps, Electrochromatic mirror, Reverse Sensing System (RSS), Trailer tow protect |
| F13 | 7.5 | Audio |
| F14 | 7.5 | Starter relay coil, PCM |
| F15 | 10 | Delayed accessory (Driver window motor logic, Moonroof, Audio, Driver door lock switch illumination) |
| F16 | 10 | Rear defroster indicator, Heated mirrors |
| F17 | 30 | Rear defroster |
| F18 | 10 | PCM relay coil, Shifter Brake-Shift Interlock (BS1), Passive Anti-Theft System (PATS) module, Fuel relay coil, Brake lamps, Center High-Mounted Stop Lamp (CHMSL) |
| F19 | 10 | Anti-lock Brake System (ABS)/Traction control module, All Wheel Drive (AWD) module, RSS, Heated seat modules |
| F20 | 7.5 | Cluster, Climate control |
| F21 | 7.5 | Restraint Control Module (RCM) |
| F22 | 7.5 | Electrochromatic mirror, Compass module |
| F23 | 7.5 | Wiper relay coil, Blower relay coil, Cluster logic |
| F24 | 7.5 | Occupant Classification Sensor (OCS), Passenger Air bag Deactivation (PAD) |
| C1 | 30 | Delayed accessory (Front passenger window, Rear passenger windows [via window switch], Window switch illumination, Backlighting) |
Advertisements
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Diagram 2004-2005
| № | A | Fused function |
|---|---|---|
| 1 | 80 | SJB, SJB fuses 1, 2, 3, 4, 5, 8 and 12 |
| 2 | — | Not used |
| 3 | — | Not used |
| 4 | 50 | Wiper RUN/ACC relay to PDB, PDB fuses 37 and 38 |
| 5 | — | Not used |
| 6 | 20 | Moonroof |
| 7 | — | Not used |
| 8 | 60 | Engine cooling fan |
| 9 | — | Not used |
| 10 | 40 | Anti-lock Brake System (ABS) (Motor) |
| 11 | 30 | Starter |
| 12 | 30 | Powertrain Control Module (PCM) |
| 13 | 20 | ABS (Valves) |
| 14 | — | Not used |
| 15 | — | Not used |
| 16 | 15 | Traction Control Module (TCM) |
| 17 | 20 | Power point (Console) |
| 18 | 10 | Alternator |
| 19 | 40 | Logic feed to SJB, SJB solid state devices |
| 20 | — | Not used |
| 21 | 40 | Rear defroster |
| 22 | 30 | Power seat motors (passenger) |
| 23 | 30 | Heated seat modules |
| 24 | 15 | Fog lamps |
| 25 | 10 | A/C clutch relay, A/C compressor clutch |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 15 | Fuel relay (Fuel pump driver module, Fuel pump) |
| 29 | 80 | SJB power, SJB (Circuit breaker, Fuses 6, 7, 9, 10, 11 and 15) |
| 30 | 30 | Driver window motor |
| 31 | — | Not used |
| 32 | — | Not used |
| 33 | 30 | Driver seat motors, Memory module |
| 34 | 30 | Ignition switch (to SJB) |
| 35 | — | Not used |
| 36 | 40 | Front A/C blower motor |
| 37 | 30 | Front wiper, Front washer |
| 38 | 5 | Heated Positive Crankcase Ventilation (PCV) valve |
| 39 | — | Not used |
| 40 | 10 | TCM, EVMV, Canister vent, ESM, Exhaust Gas Oxygen heaters, A/C clutch |
| 41 | 15 | PCM, Injectors, Ignition coils, Mass Air Flow (MAF) sensor |
| 42 | — | Not used |
| 43 | — | Not used |
| 44 | — | Not used |
| 45 | — | Not used |
| 46 | — | Not used |
| 47 | Not used | |
| 48 | Fog lamps | |
| 49 | Not used | |
| 50 | Not used | |
| 51 | A/C clutch | |
| 52 | Not used | |
| 53 | Fuel pump driver module, Fuel pump | |
| 54 | Not used | |
| 55 | PCM relay, PDB fuses 40 and 41 | |
| 56 | Starter motor solenoid | |
| 57 | Front A/C blower motor | |
| 58 | Wipers | |
| 59 | Not used | |
| 60 | PCM | |
| 61 | PCM | |
Advertisements
Diagram 2006-2007
| № | A | Fused function |
|---|---|---|
| 1 | 80 | SJB, SJB fuses 1, 2, 3, 4, 5, 8 and 12 |
| 2 | — | Not used |
| 3 | 30 | Front wiper, Front washer |
| 4 | — | Not used |
| 5 | 20 | Moonroof |
| 6 | — | Not used |
| 7 | 60 | Engine cooling fan |
| 8 | — | Not used |
| 9 | 40 | Anti-lock Brake System (ABS) (Motor) |
| 10 | 30 | Starter |
| 11 | 30 | Powertrain Control Module (PCM) relay |
| 12 | 20 | ABS (Valves) |
| 13 | — | Not used |
| 14 | — | Not used |
| 15 | 15 | Traction Control Module (TCM) |
| 16 | 20 | Power point (Console) |
| 17 | 10 | Alternator |
| 18 | 40 | Logic feed to SJB, SJB solid state devices |
| 19 | — | Not used |
| 20 | 40 | Rear defroster |
| 21 | 30 | Power seat motors (passenger) |
| 22 | 30 | Heated seat module |
| 23 | 15 | Fog lamps |
| 24 | 10 | A/С clutch relay, A/С compressor clutch |
| 25 | — | Not used |
| 26 | — | Not used |
| 27 | 15 | Fuel relay (Fuel pump driver module, Fuel pump) |
| 28 | 80 | SJB power, SJB (Circuit breaker, Fuses 6, 7, 9, 10, 11 and 15) |
| 29 | 30 | Driver window motor |
| 30 | — | Not used |
| 31 | — | Not used |
| 32 | 30 | Driver seat motors, Memory module |
| 33 | 30 | Ignition switch (to SJB) |
| 34 | — | Not used |
| 35 | 40 | Front A/С blower motor |
| 36 | — | Not used |
| 37 | — | Not used |
| 38 | — | Not used |
| 45 | — | Not used |
| 46 | 5 | Heated Positive Crankcase Ventilation (PCV) valve |
| 47 | — | Not used |
| 48 | 10 | TCM, EVMV, Canister vent, ESM, Exhaust Gas Oxygen heaters, A/C clutch |
| 49 | 15 | PCM, Injectors, Ignition coils, Mass Air Flow (MAF) sensor |
| 39 | PCM | |
| 40 | A/С clutch | |
| 41 | Fog lamps | |
| 42 | Not used | |
| 43 | A/С clutch | |
| 44 | Fuel pump driver module, Fuel pump | |
| 50 | PCM relay, PDB fuses 40 and 41 | |
| 51 | St art or motor solenoid | |
| 52 | Front A/С blower motor | |
| 53 | Not used | |
| 54 | Not used | |
| 55 | Not used | |
| 56 | Not used | |
| 57 | Front wipers | |
| 58 | Not used | |
Advertisements