Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Fiesta Mk5 (2002, 2003, 2004, 2005, 2006, 2007, 2008).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The central fuse box is located behind the glove box. Open the glove box and empty the contents. Press the sides inwards and swivel the glove box downwards.
| № | A | Fused component |
|---|---|---|
| F1 | - | Not used |
| F2 | - | Trailer towing module |
| F3 | 7.5 | Lighting |
| - | Trailer towing module | |
| F4 | 10 | Air conditioning, blower motor |
| F5 | 20 | ABS, ESP |
| F6 | 30 | ABS, ESP |
| F7 | 15 | Transmission |
| F8 | 7.5 | Power mirrors |
| F9 | 10 | Left low beam headlamp |
| F10 | 10 | Right low beam headlamp |
| F11 | 15 | Daytime running lights |
| F12 | 15 | Engine management |
| F13 | 20 | Engine management, catalytic converter |
| F14 | 30 | Starter |
| F15 | 20 | Fuel pump |
| F16 | 3 | Engine management |
| F17 | 15 | Light switch |
| F18 | 15 | Radio, diagnostic connector |
| F19 | 15 | Daytime running lights |
| F20 | 7.5 | Instrument cluster, battery saver, number plate lamp, generic electronic module |
| F21 | - | Not used |
| F22 | 7.5 | Position and side lights (left) |
| F23 | 7.5 | Position and side lights (right) |
| F24 | 20 | Central locking, alarm horn |
| F25 | 15 | Hazard warning lights, direction indicators |
| F26 | 20 | Heated rear screen |
| F27 | 15 | Horn |
| F28 | 3 | Battery, charging system |
| F29 | 15 | Cigar lighter |
| F30 | 15 | Ignition |
| F31 | 10 | Light switch |
| F32 | 7.5 | Heated mirror |
| F33 | 7.5 | Instrument cluster, battery saver, number plate lamp, generic electronic module |
| F34 | 20 | Sunroof |
| F35 | 7.5 | Heated front seats |
| F36 | 30 | Power windows |
| F37 | 3 | ABS, ESP |
| F38 | 7.5 | Generic electronic module |
| F39 | 7.5 | Air bag |
| F40 | 7.5 | Transmission |
| 10 | Light switch | |
| F41 | 7.5 | Transmission |
| F42 | 30 | Heated front screen |
| F43 | 30 | Heated front screen |
| F44 | 3 | Radio, diagnostic connector |
| F45 | 15 | Stop lights |
| F46 | 20 | Front screen wiper |
| F47 | 10 | Rear screen wiper |
| F48 | 7.5 | Backup lamps |
| F49 | 30 | Blower motor |
| F50 | 20 | Fog lamps |
| F51 | 15 | Cigar lighter |
| F52 | 10 | Left high beam headlamp |
| F53 | 10 | Right high beam headlamp |
| F54 | - | Trailer towing module |
| F55 | - | Not used |
| F56 | - | Trailer towing module |
| R1 | Power mirrors | |
| Lighting | ||
| R2 | Heated front screen | |
| R3 | Ignition | |
| R4 | Low beam headlamp | |
| R5 | High beam headlamp | |
| R6 | Fuel pump | |
| R7 | Starter | |
| R8 | Cooling fan | |
| Daytime running lights | ||
| R9 | Daytime running lights | |
| R10 | Charging system | |
| R11 | Engine management | |
| R12 | Power mirrors | |
Advertisements
Engine Compartment Fuse Box
It is attached to the battery basket.
| № | A | Fused component |
|---|---|---|
| F1 | 80 | Auxiliary heater (РТС) |
| F2 | 60 | Transmission |
| F3 | 60 | Auxiliary heater (РТС) / Glow plug |
| F4 | 40 | Cooling fan, air conditioning |
| F5 | 60 | Lighting, Generic electronic module (GEM) |
| F6 | 60 | Ignition |
| F7 | 60 | Engine, lighting |
| F8 | 60 | Heated front screen, ABS, ESP |
Engine Compartment Relay Box
Located near the battery.
| № | Relay |
|---|---|
| R1 | Air conditioning |
| R2 | Cooling fan |
| R3 | Auxiliary heater (РТС) |
| R4 | Auxiliary heater (РТС) |
Advertisements