Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Fiesta Mk4 (1997, 1998, 1999, 2000, 2001, 2002).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The fuse block is located in the dash panel.
| № | A | Protected Component |
|---|---|---|
| 1 | 15 | Cigar lighter |
| 2 | 20 | 1) Clock, Heating, Interior Lights, Clock, Radio Memory |
| 7.5 | 2) Interior Lights, Climate Control Module, Clock, Instrument Panel | |
| 3 | 10 | 2) GEM Module |
| 2) Fridge Van; up to 1999: Refrigeration System Relay, Evaporator Control Relay | ||
| 4 | 15 | 1) Heated Rear Window, Heated Exterior Mirrors |
| 20 | 2) Heated Rear Window | |
| 5 | 20 | 1) Horn, Alarm |
| 15 | 2) Multifunction Switch (Horn) | |
| 6 | 10 | 1) Left Side Lamp |
| 7.5 | 2) Left Side Lamp, Headlight Range Control, License Plate Light, Climate Control Module, Radio, Heated Rear Window Switch, Instrument Panel, Rear Fog Light Switch, Front Fog Light Switch, Heated Windshield Switch | |
| 7 | 10 | 1) Right Side Lamp |
| 7.5 | 2) Right Side Lamp, License Plate Light | |
| 8 | 15 | Up to 09.1999: Central Locking, Electric Mirrors |
| As of 09.1999: GEM Module | ||
| 9 | 15 | 1) Seat Height Adjustment |
| 25 | 2) Multifunction Switch (Exterior Light) | |
| 10 | 15 | Heated Front Seat |
| 11 | 30 | Electric Windows, Central Locking |
| 12 | 20 | Wiper Motor, Screen Washer Pump |
| 13 | 15 | 1) Brake Light, Instrument Panel |
| 15 | 2) Brake Light Switch, Climate Control Module, Gearbox Switch (Manual Transmission), Gearbox Position Sensor (Automatic Transmission), Heater Control Valve Solenoid, Heated Rear Window Switch, Instrument Panel | |
| 14 | 10 | Air Bag |
| 15 | 10 | 1) Heated Mirrors |
| 7.5 | 2) Electric Mirrors | |
| 16 | 30 | Heater Blower Motor |
| 17 | 15 | Direction Indicators |
| 18 | 15 | 1) Ignition |
| 15 | 2) GEM Module, Auxiliary Relay, Main Relay, Ignition coil DIS (1,3 L Endura–E, 1,25 and 1,4 L ZETEC–SE), Passive Anti-Theft Module (1,8 L Diesel Endura–DE) | |
| 19 | 10 | 1) Engine Management, Radio, Alarm |
| 7.5 | 2) Fuse No.30, Radio, Clock, Instrument Panel | |
| 20 | 30 | 1) Headlight Washer |
| 10 | 1) RHD: Dim/Dip | |
| 20 | 2) Multifunction Switch (Daytime Running Lights, Exterior Light) | |
| 21 | 15 | 2) As of 09.1999: Central Locking |
| 22 | 10 | Data Link Connector (DLC), Radio |
| 42 | 15 | 2) Up to 09.1999: GEM Module |
| 10 | 2) Fridge Van; as of 09.1999: Refrigeration System Relay, Evaporator Control Relay | |
| 43 | 10 | 2) Daytime Running Light Relay (Parking Lights) |
| 49 | 20 | 2) Daytime Running Lights, Exterior Light |
| 50 | 25 | 2) Exterior Light |
| I | Ignition Relay | |
| II | Heated Windshield Relay | |
| III | - | |
| IV | - | |
| V | - | |
| VI | - | |
| VII | Daytime Running Light Relay (Parking Lights) | |
| VIII | Daytime Running Light Relay (DTRL) | |
| IX | Heated Windshield Relay | |
| X | Heated Rear Window Relay | |
| XI | Daytime Running Light Relay (Parking Lights) | |
| 1) Haynes 2) Electrical Wiring Diagrams (CG1647es) | ||
Advertisements
Engine Compartment Fuse Box
| № | A | Protected Component |
|---|---|---|
| 20 | - | Diode |
| 21 | - | Not Used |
| 22 | - | Not Used |
| 23 | 10 | Left Main Beam |
| 24 | 10 | Right Main Beam |
| 25 | 10 | Left Low Beam |
| 26 | 10 | Right Low Beam |
| 27 | 10 | Petrol Engines: Lambda Sensor |
| 15 | Diesel Engines: Fuel Heater | |
| 28 | 15 | 1,8 L Diesel Endura–DE: PCM Module, EGR, Glow Plug Relay, Engine Cooling Fan Relay, High Speed Cooling Fan Relay (with air conditioning), Air Conditioning Relay, Vehicle Speed Sensor (VSS) |
| Petrol Engines: Fuel Pump Relay, Engine Cooling Fan Relay, High Speed Cooling Fan Relay (with air conditioning), Air Conditioning Relay, Vehicle Speed Sensor (VSS), Passive Anti-Theft Module (1,25 L ZETEC–SE 1,3 L Endura–DE), PCM Module, Mass Air Flow Sensor (MAF; 1,4 L ZETEC–SE), Idle Air Control Valve, Injector, Canister Purge Valve | ||
| 29 | 20 | Air Conditioning Relay, Front Fog Light Relay, Dual Pressure Switch, Refrigeration System Relay (Fridge Van), Evaporator Control Relay (Fridge Van) |
| 30 | 3 | ABS |
| 31 | 30 | ABS |
| 32 | 3 | PCM Module |
| 33 | 30 | ABS (all models with ABS), Engine Cooling Fan (without ABS, without A/C) |
| 34 | 30 | PCM Module |
| 35 | 10 | Passive Anti-Theft Module (1,8 L Diesel Endura–DE), Fuel Pump Relay |
| 36 | 60 | Engine Cooling Fan Relay, High Speed Cooling Fan Relay (with air conditioning), Glow Plug Relay, Inhibitor Relay |
| 37 | 40 | Heated Windshield Relay |
| 60 | Fridge Van: Cooling Fan Relay (Refrigeration System), High Speed Cooling Fan Relay | |
| 38 | 10 | Main Relay |
| 39 | 60 | Daytime Running Light Relay (DTRL), Fuse No.: 1, 2, 3, 4, 5, 21, 22 (Passenger Compartment Fuse Box) |
| 40 | 60 | Ignition Lock, Fuse No.: 42, 50 (Passenger Compartment Fuse Box) |
| R1 | Auxiliary Relay | |
| R2 | Inhibitor Relay | |
| R3 | Diesel Engines: Glow Plug Relay | |
| R4 | Engine Cooling Fan Relay | |
| R5 | High Speed Cooling Fan Relay | |
| R6 | Air Conditioning Relay | |
| R7 | Air Conditioning Relay | |
| R8 | Main Relay | |
| R9 | Petrol Engines: Fuel Pump Relay | |
| Diesel Engines: Fuel Heater Relay | ||
| R10 | Front Fog Light Relay | |
| R11 | Low Beam Relay | |
| R12 | High Beam Relay | |
Relay Box (Fridge Van)
| № | Relay |
|---|---|
| R1 | Refrigeration System |
| R2 | Evaporator |
| R3 | Chiller |
| R4 | Cooling Fan |
| R5 | High Speed Cooling Fan |
| R6 | Low Speed Cooling Fan |
| R7 | Clutch Control |
Advertisements