Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Explorer Sport Trac (2000, 2001, 2002, 2003, 2004, 2005).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
Pull the panel out to access the passenger compartment fuse panel.
| № | A | Circuits Protected |
|---|---|---|
| 1 | 5 | Mirrors, Autolamp (2002-2003) |
| 2 | 5 | 2000-2001: Aux. High Mount Stop Lamp |
| 7.5 | 2002-2003: Cluster, Autolamp. Generic Electronic Module (GEM), Keyless entry, 4x4 | |
| 15 | 2004-2005: Ignition | |
| 3 | 7.5 | 2000-2001: Left Stop/Turn Trailer Tow Connector |
| 2002-2005: Trailer tow right-hand stop/turn lamps | ||
| 4 | 15 | 2000-2001: Subwoofer |
| 7.5 | 2002-2003: Starter | |
| 2004-2005: Not used | ||
| 5 | 15 | 2000-2001: Not Used |
| 2002-2005: Park lamps, Autolamps, Instrument panel dimming, Trailer tow | ||
| 6 | 15 | 2000-2001; With Rear Blower:Blower Motor Relay, Airbag Diagnostic Monitor |
| 7.5 | 2000-2001; Without Rear Blower: Airbag Diagnostic Monitor | |
| 2002-2005: Air bags (2002-2003), Cluster | ||
| 7 | 7.5 | 2000-2001: Right Stop/Turn Trailer Tow Connector |
| 2002-2005: Trailer tow left-hand stop/turn lamps | ||
| 8 | 7.5 | 2000-2001: Not Used |
| 2002-2003: Cluster, Audio, GEM | ||
| 2004-2005: Not used | ||
| 9 | 7.5 | 2000-2001: Brake Pedal Position Switch |
| 2002-2005: Speed control, Anti-lock Brake System (ABS), 4x4, Powertrain Control Module (PCM), Park interlock, Keyless entry | ||
| 10 | 7.5 | 2000-2001: Speed Control/Amplifier Assembly, Generic electronic Module (GEM), Shift Lock Actuator, Blend Door Actuator, A/C -Heater Assembly, Flasher, Overhead Console, 4X4 Module |
| 15 | 2002-2003: Ignition, IPATS | |
| 10 | 2004-2005: Air bags | |
| 11 | 7.5 | 2000-2001: Instrument Cluster, 4X4 Module |
| 15 | 2002-2003: Subwoofer | |
| 2004-2005: Climate control, Rear climate control | ||
| 12 | 7.5 | Washer Pump Relay |
| 15 | 2002-2003: Air bags, Climate control, Rear climate control | |
| 2004-2005: Not used | ||
| 13 | 15 | 2000-2001: Brake Pedal Position Switch, Brake Pressure Switch |
| 2002-2003: Stop lamps, Speed control, Auxiliary Center High-Mounted Stop Lamp (CHMSL) | ||
| 2004-2005: Subwoofer | ||
| 14 | 10 | 2000-2001: 4 Wheel Anti-Lock Brake System (4WABS) Module |
| 2002-2003: Not used | ||
| 7.5 | 2004-2005: Cluster, Keyless entry, 4x4 | |
| 15 | 7.5 | 2000-2001: Instrument Cluster |
| 2004-2005: Turn signals, Park interlock, Overhead console, Climate control, 4x4, Speed control | ||
| 15 | 2002-2003: 4x4 module | |
| 16 | 30 | 2000-2001: Windshield Wiper Motor, Wiper Hi-Lo Relay, Wiper Run/Park Relay |
| 7.5 | 2002-2003: Turn signals, Park interlock, Overhead console, Climate control, 4x4, Speed control | |
| 2004-2005: Not used | ||
| 17 | 20 | 2000-2004: Cigar Lighter, Data Link Connector |
| 2005: Not used | ||
| 18 | 25 | 2000-2001: Power Door Locks |
| 20 | 2002-2003: Power locks, Keyless entry | |
| 15 | 2004: Not used | |
| 2005: Stop lamps, Flashers | ||
| 19 | 25 | 2000-2001: PCM Power Diode |
| 15 | 2002-2003: Trailer tow park lamps | |
| 2004-2005: Daytime Running Lamps (DRL), Reverse lamps, PCM | ||
| 20 | 7.5 | 2000-2001: Generic Electronic Module (GEM), Radio, Moonroof Relay, Power Window Relay, Power Down Back Window |
| 15 | 2002-2003: Daytime Running Lamps (DRL), Reverse lamps, PCM | |
| 2004-2005: Not used | ||
| 21 | 15 | 2000-2002: Flasher (Hazard) |
| 20 | 2003: Heated seats | |
| 2004-2005: Not used | ||
| 22 | 20 | 2000-2004: Auxiliary Power Socket |
| 2005: Security module/Power locks | ||
| 23 | 10 | 2000-2001: Not Used |
| 2002: Front washers | ||
| 7.5 | 2003: Front washers | |
| 2004-2005: Not used | ||
| 24 | 7.5 | 2000-2001: Starter Interrupt Relay, Anti-Theft |
| 2004-2005: Starter | ||
| 30 | 2002-2003: Front wiper | |
| 25 | 7.5 | 2000-2001: Generic Electronic Module (GEM), Instrument Cluster, Securi-Lock |
| 2002-2003: Cluster, GEM | ||
| 2004-2005: Cluster, 4x4 | ||
| 26 | 10 | Interior illumination, Battery saver |
| 27 | 15 | 2000-2001: DRL, Backup Lamps Switch, DTR Sensor |
| 7.5 | 2002-2003: Audio, Windows, GEM, Moonroof, Rear window | |
| 2004-2005: Cluster, Delayed accessory, Front wiper | ||
| 28 | 7.5 | 2000-2001: Radio |
| 2004-2005: Cluster, Audio | ||
| 15 | 2002: Rear wiper (on glass) | |
| 2003: Not used | ||
| 29 | 20 | Audio, Rear audio |
| 30 | 25 | 2000-2003: Power Seats |
| 2004-2005: Not used | ||
| 31 | 5 | 2000-2001: Rear Blower Motor |
| 2002: Rear climate control | ||
| 2003: Instrument panel dimming (XLS)/Rear audio control (XLT) | ||
| 2004-2005: Rear climate control | ||
| 32 | 5 | 2000-2001: Not Used |
| 2002-2005: Auxiliary Center High-Mounted Stop Lamp (CHMSL) | ||
| 33 | 15 | 2000-2001: Headlamps, Daytime Running Lamps (DRL) Module, Instrument Cluster |
| 2002-2005: Highbeam headlamps | ||
| 34 | 5 | 2000-2001: Rear Integrated Control Panel |
| 2002-2003: Rear audio | ||
| 2004-2005: Not used | ||
| 35 | 15 | 2000-2001: 4X4 Module |
| 5 | 2002-2005: ABS module | |
| 36 | 15 | 2000-2001: Trailer Tow Relay |
| 2002-2005: Not used |
Advertisements
Power Distribution Box
| № | A | Circuits Protected |
|---|---|---|
| 1 | 50 | Fuse Panel |
| 2 | 50 | 2000-2002: Not Used |
| 2003: Ultimate Audio System | ||
| 2004-2005: Not Used | ||
| 3 | 30 | 2000-2001: Power Down Back Window |
| 2004-2005: Powertrain control | ||
| 20 | 2002-2003: Power down back window, Moonroof | |
| 4 | 20 | 2000-2004: Not Used |
| 2005: Power point | ||
| 5 | 20 | 2000-2003: Not Used |
| 2004: Fuel pump | ||
| 2005: Not Used | ||
| 6 | 50 | 2000-2003: ABS Pump Motor |
| 2004-2005: Not Used | ||
| 7 | 30 | 200-2003: Powertrain Control |
| 40 | 2004-2005: Blower motor | |
| 8 | 30 | 2000-2003: Not Used |
| 2004-2005: Starter motor | ||
| 9 | 20 | 2000-2003: Not Used |
| 2004-2005: Wiper motor | ||
| 10 | 20 | 2000-2003: Not Used |
| 2004-2005: Rear window/roof | ||
| 11 | 50 | 2000-2003: Ignition Switch |
| 2004-2005: Adrenalin audio | ||
| 12 | — | Not Used |
| 13 | 20 | 2000-2003: 4X4 Motor |
| 2004-2005: Not Used | ||
| 14 | 25 | 2000-2003: Not Used |
| 2004-2005: Ignition switch | ||
| 15 | 20 | 2000-2003: Not Used |
| 2004-2005: Rear power point | ||
| 16 | 40 | 2000-2003: Blower Motor |
| 50 | 2004-2005: Anti-lock Brake System (ABS) pump motor | |
| 17 | — | Not Used |
| 18 | 30 | 2000-2003: Not Used |
| 2004: ABS module | ||
| 2005: Not Used | ||
| 19 | 20 | 2000-2004: Not Used |
| 2005: Cigar lighter, OBD II | ||
| 20 | 20 | 2000-2003: Not Used |
| 2004-2005: 4x4 motor | ||
| 21 | 10 | 2000-2003: PCM Memory |
| 2004: Not Used | ||
| 30 | 2005: ABS module | |
| 22 | 15 | 2000-2003: Horn |
| 2004-2005: 4x4 module | ||
| 23 | 20 | 2000-2003: Fuel Pump Motor |
| 15 | 2004-2005: Trailer tow | |
| 24 | 25 | 2000-2003: Headlamps |
| 10 | 2004-2005: Powertrain Control Module (PCM) memory | |
| 25 | 10 | 2000-2003: A/C Clutch Solenoid |
| 2004-2005: Not Used | ||
| 26 | 20 | 2000-2003: Not Used |
| 2004: Door locks | ||
| 2005: Not Used | ||
| 27 | 20 | 2000-2003: Rear Power Point |
| 15 | 2004-2005: Daytime Running Lamps (DRL) | |
| 28 | 30 | 2000-2003: 4WABS Module |
| 10 | 2004-2005: A/C Clutch Solenoid | |
| 29 | 15 | 2000-2003: Foglamps |
| 25 | 2004-2005: Headlamps | |
| 30 | 20 | 2000-2004: Not Used |
| 2005: Fuel pump | ||
| 31 | 15 | 2000-2003: Daytime Running Lamps (DRL) |
| 2004-2005: Fog lamps | ||
| 32 | 15 | 2000-2003: Not Used |
| 2004-2005: Heated Exhaust Gas Oxygen (HEGO) sensors and solenoids | ||
| 33 | 15 | 2000-2001: Park Lamps |
| 2002-2005: Not Used | ||
| 34 | 15 | 2000-2003: Not Used |
| 2004: Stop lamps | ||
| 2005: Not Used | ||
| 35 | 15 | 2000-2003: Not Used |
| 2004-2005: Horn | ||
| 36 | 10 | 2000-2003: Not Used |
| 2004-2005: Automatic transmission | ||
| 37 | — | Not Used |
| 38 | 10 | Left Low Beam |
| 39 | 10 | 2000-2003: Not Used |
| 2004-2005: Delayed accessory | ||
| 40 | 15 | 2000-2003: Not Used |
| 2004-2005: Injectors, Mass Air Flow (MAF) sensor | ||
| 41 | 15 | 2000-2003: Heated Oxygen Sensors |
| 2004-2005: Not Used | ||
| 42 | 10 | Right Low Beam |
| 43 | 2 | 2000-2003: Not Used |
| 2004-2005: Speed control | ||
| 44 | 2 | 2000-2002: Not Used |
| 2003: Speed control | ||
| 15 | 2004-2005: PCM | |
| 47A | 20 | 2000-2001: Windows/Roof |
| 2002-2004: Windows | ||
| 2005: Windows, Seats | ||
| 47B | 20 | 2000-2003: Not Used |
| 2004: Seats | ||
| 2005: Not Used | ||
| 45A | 2000-2003: Wiper Hi/Low Relay | |
| 2004-2005: Fog lamps relay | ||
| 45B | 2000-2003: Wiper Run/Park Relay | |
| 2004: Not Used | ||
| 2005: A/C clutch solenoid relay | ||
| 46A | 2000-2001: Park Lamp Relay | |
| 2002-2003: Not Used | ||
| 2004-2005: Trailer tow relay | ||
| 46B | 2000-2001: Front Washer Pump Relay | |
| 2002-2004: Not Used | ||
| 2005: Fuel pump relay | ||
| 48 | Window Safety Relay | |
| 49 | 2000-2004: Starter Relay | |
| 50A | 2000-2004: Not Used | |
| 50B | 2000-2004: Fuel Pump Relay | |
| 54 | PCM Relay | |
| 55 | Blower Relay | |
| 56A | 2000-2003: A/C Clutch Solenoid | |
| 2004: Not Used | ||
| 56B | 2000-2003: Horn Relay | |
| 2004: A/C clutch solenoid relay | ||
| 56 | 2005: Starter relay | |
| 51 | 2000-2003: Not Used | |
| 2004-2005: Brake On/Off (BOO) switch resistor (750 Ohm resistor) | ||
| 52 | 2000-2003: Not Used | |
| 2004-2005: A/C clutch diode | ||
| 53 | PCM Diode | |
Advertisements