Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Expedition (U324; 2015, 2016, 2017).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The fuse panel is located under the right-hand side of the instrument panel. Pull the panel toward you, swing it out away from the side, and remove the trim panel for access to the fuse box. To reinstall it, line up the tabs with the grooves on the panel, and then push it shut.
| № | A | Description |
|---|---|---|
| 1 | 30 | Driver window |
| 2 | 15 | Rear seat control. |
| Multimedia gateway module | ||
| 3 | 30 | Passenger window |
| 4 | 10 | Demand lamps |
| 5 | 20 | Amplifier |
| 6 | 5 | Rear electronic automatic temperature control |
| 7 | 7.5 | Power mirror, |
| Driver seat memory switch | ||
| 8 | - | Not used |
| 9 | 10 | SYNC, |
| Power lift gate, | ||
| Electric finish panel, | ||
| Display | ||
| 10 | 10 | Run accessory relay |
| 11 | 10 | Passive entry/start module |
| 12 | 15 | Interior lighting, |
| Puddle lamps | ||
| 13 | 15 | Right turn and stop/turn signals |
| 14 | 15 | Left turn and stop/turn signals |
| 15 | 15 | Reverse lamp, |
| Center high mount stop lamp, | ||
| EC mirror | ||
| 16 | 10 | Right front low beam |
| 17 | 10 | Left front low beam |
| 18 | 10 | Brake shift interlock/start button LED/ keypad illumination, |
| Third row power folding seat, | ||
| Passive entry touch start | ||
| 19 | - | Not used |
| 20 | 20 | Lock/unlock relays |
| 21 | - | Not used |
| 22 | 20 | Horn |
| 23 | 15 | Steering wheel control module, |
| Cluster | ||
| 24 | 15 | Adjustable pedals/power adjustable column, |
| Datalink | ||
| 25 | 15 | Liftgate release decklid, |
| Liftglass release motor | ||
| 26 | 5 | Push to start switch |
| 27 | 20 | Passive entry/start module |
| 28 | 15 | Ignition switch, |
| Key inhibit switch | ||
| 29 | 20 | Radio, |
| GPS | ||
| 30 | 15 | Front park lamps |
| 31 | 5 | Trailer brake on/off |
| 32 | 15 | Power vent, |
| Driver's window motor, | ||
| Power inverter. | ||
| 33 | 10 | CCD suspension module |
| 34 | 10 | Rear park assist, |
| Rear camera, | ||
| BUS, | ||
| Heated seat | ||
| 35 | 5 | Climate module, |
| O/D switch | ||
| 36 | - | Not used |
| 37 | 10 | 4X4 module |
| 38 | 10 | EC mirror, |
| Moonroof, | ||
| DVD, | ||
| AM/FM radio | ||
| 39 | 15 | Left and right front high beams |
| 40 | 10 | Rear park/tail lamps |
| 41 | 7.5 | Restraints control module |
| 42 | - | Not used |
| 43 | - | Not used |
| 44 | - | Not used |
| 45 | 5 | ot used (spare) |
| 46 | 10 | Climate control |
| 47 | 15 | Fog lamps |
| 48 | 30 | Front passenger and rear windows circuit breaker |
| 49 | - | Windows and vents relay |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment.
| № | A | Description |
|---|---|---|
| 1 | - | Rear washer relay |
| 2 | - | Starter relay |
| 3 | - | Blower motor relay |
| 4 | - | Rear wiper relay |
| 5 | - | Fuel pump relay |
| 6 | - | Electronic cooling fan |
| 7 | - | Rear window defroster/heated mirror relay |
| 8 | - | Electronic cooling fan |
| 9 | - | Run/start relay |
| 10 | - | Power distribution box relay. |
| 11 | 40 | Power running boards |
| Heated seats | ||
| 12 | 40 | Run/start, relay |
| 13 | 30 | Starter relay |
| 14 | 50 | Electronic cooling fan |
| 15 | - | Not used |
| 16 | 50 | Electronic fan |
| 17 | - | Not used |
| 18 | 30 | Trailer brake |
| 19 | 20 | Power point (console) |
| 20 | 20 | 4x4 module HAT 2 |
| 21 | 30 | Trailer tow module |
| 22 | 30 | Passenger power seat |
| 23 | - | Air conditioner clutch relay |
| 24 | - | Trailer tow park lamp relay |
| 25 | - | Not used |
| 26 | 10 | ALT sensor |
| 27 | 20 | 4x4 module HAT 1 |
| 28 | 25 | Trailer tow park lamp relay |
| 29 | 10 | Integrated wheel end solenoid |
| 30 | 10 | Air conditioner clutch relay |
| 31 | 15 | Trailer tow back up lamp |
| 32 | 40 | Blower motor relay |
| 33 | 40 | 110 volt AC power point |
| 34 | 30 | Auxiliary blower motor |
| 35 | 30 | Powertrain control module relay |
| 36 | 30 | Power liftgate |
| 37 | - | Not used |
| 38 | - | Not used |
| 39 | - | Trailer tow backup lamps relay |
| 40 | - | Electronic fan 2 relay |
| 41 | 10 | Powertrain control module keep-alive power |
| 42 | 5 | Run/start relay |
| 43 | 10 | Brake on/off switch |
| 44 | 20 | Fuel pump relay |
| 45 | 10 | Not used (spare) |
| 46 | 15 | Front/rear washer pump |
| 47 | 30 | Rear wiper motor |
| 48 | 40 | Trailer tow module |
| 49 | - | Not used |
| 50 | 30 | Front wiper motor relay |
| 51 | 40 | Rear window defroster/heated mirror relay |
| 52 | 10 | Anti-lock brake system run/start feed |
| 53 | 5 | Powertrain control module ISP |
| 54 | 5 | Power steering |
| 55 | - | Not used |
| 56 | 30 | Passenger compartment fuse panel R/S feed |
| 57 | 5 | Blower motor run/start |
| 58 | - | Not used |
| 59 | 15 | Heated mirrors |
| 60 | - | Not used |
| 61 | - | Not used |
| 62 | - | Not used |
| 63 | 25 | Electronic fan |
| 64 | 30 | Moonroof |
| 65 | 20 | Not used (spare) |
| 66 | 20 | Auxiliary power point (rear of center console) |
| 67 | 40 | Front row climate controlled seats |
| 68 | 30 | Anti-lock brake system valves |
| 69 | 60 | Anti-lock brake system pump |
| 70 | 30 | Third row power fold seat |
| 71 | 20 | Auxiliary power point/cigar lighter |
| 72 | 20 | Auxiliary power point (right rear quarter panel) |
| 73 | 20 | Rear seat climate module |
| 74 | 30 | Driver power seat |
| 75 | 25 | Vehicle power 1 - powertrain control module |
| 76 | 20 | Vehicle power 2 - powertrain control module |
| 77 | 20 | Vehicle power 4 - ignition coils |
| 78 | - | Not used |
| 79 | 15 | Vehicle power 3 - powertrain control module |
| 80 | - | Not used |
| 81 | - | Not used |
| 82 | 5 | Rain sensor |
| 83 | - | Not used |
| 84 | - | Not used |
| 85 | - | Wiper motor relay |
Advertisements