Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Expedition (U324; 2007, 2008).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The fuse panel is located under the right-hand side of the instrument panel. To remove the trim panel for access to the fuse box, pull the panel toward you and swing it out away from the side and remove it. To reinstall it, line up the tabs with the grooves on the panel, then push it shut. To remove the fuse box cover, press in the tabs on both sides of the cover, then pull the cover off.
| № | A | Description |
|---|---|---|
| 1 | 30 | Smart window #1 |
| 2 | 15 | Driver side memory module |
| 3 | 15 | FES, |
| Audio rear seat controls, | ||
| SDARS | ||
| 4 | 30 | Smart window #2 |
| 5 | 10 | Keypad illumination, |
| 3rd row seat enable, | ||
| Brake Shift Interlock (BSI), | ||
| SPDJB | ||
| 6 | 20 | Turn signals |
| 7 | 10 | Low beam headlamps (left) |
| 8 | 10 | Low beam headlamps (right) |
| 9 | 15 | Interior lights |
| 10 | 15 | Backlighting, Puddle lamps |
| 11 | - | Not used |
| 12 | 7.5 | Power mirror switch, |
| Driver seat memory switch | ||
| 13 | - | Not used |
| 14 | 10 | Power liftgate module - keep-alive power |
| 15 | 10 | Climate control |
| 16 | - | Not used |
| 17 | 20 | All lock motor feeds, |
| Liftgate release, | ||
| Liftglass releas | ||
| 18 | 20 | Not used (Spare) |
| 19 | 25 | Rear wiper |
| 20 | 15 | Adjustable pedals, |
| Datalink | ||
| 21 | 15 | Fog lamps, |
| Cornering lamps | ||
| 22 | 15 | Park lamps relay |
| 23 | 15 | High beam headlamps |
| 24 | 20 | Horn relay |
| 25 | 10 | Demand lamps, |
| Glovebox, | ||
| Visor | ||
| 26 | 10 | Instrument panel cluster |
| 27 | 20 | Ignition switch |
| 28 | 5 | Radio |
| 29 | 5 | Instrument panel cluster |
| 30 | 5 | Not used (Spare) |
| 31 | 10 | Compass, |
| Automatic dimming rear view mirror | ||
| 32 | 10 | Restraints control module |
| 33 | - | Not used |
| 34 | 5 | Not used (Spare) |
| 35 | 10 | Rear park assist, 4x4 |
| 36 | 5 | PATS transceiver |
| 37 | 10 | Climate control |
| 38 | 20 | Subwoofer/Amp (Audiophile radio) |
| 39 | 20 | Radio |
| 40 | - | Not used |
| 41 | - | Not used |
| 42 | 10 | Trailer tow battery charge coil |
| 43 | 10 | Rear wiper logic |
| 44 | - | Not used |
| 45 | 5 | Front wiper logic |
| 46 | 7.5 | Climate control, |
| Auxiliary relay control | ||
| 47 | 30 | Power windows, |
| Moon roof | ||
| 48 | - | Not used |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment.
| № | A | Description |
|---|---|---|
| 1 | - | Blower relay |
| 2 | - | Not used |
| 3 | - | Rear window defroster relay |
| 4 | 30 | Third row seats (driver side) |
| 5 | 40 | Trailer tow connector (electric brake) |
| 6 | 60 | ABS (valves) |
| 7 | - | Not used |
| 8 | 40 | Heated/cooled seats |
| 9 | 60 | ABS (pump) |
| 10 | 20 | Rear console power point |
| 11 | 30 | Auxiliary blower |
| 12 | 25 | Trailer tow connector (park lamps) |
| 13 | 30 | Trailer tow connector (battery charge) |
| 14 | - | Not used |
| 15 | - | Not used |
| 16 | - | A/С clutch relay |
| 17 | - | Not used |
| 18 | - | Fuel pump relay |
| 19 | - | Back-up relay |
| 20 | - | Trailer tow connector relay (left turn signal) |
| 21 | - | Trailer tow connector relay (right turn signal) |
| 22 | - | Not used |
| 23 | 15 | Heated mirrors |
| 24 | 40 | Blower motor |
| 25 | - | Not used |
| 26 | - | Not used |
| 27 | 30 | Power liftgate |
| 28 | 40 | Rear window defroster, |
| Heated mirror | ||
| 29 | 30 | Passenger seat |
| 30 | 10 | A/С clutch |
| 31 | 15 | Brake lamps |
| 32 | 20 | Fuel pump |
| 33 | 20 | Back-up lamps |
| 34 | 25 | Trailer tow connector (stop/turn lamps) |
| 35 | 20 | 4x4 module |
| 36 | 10 | Powertrain Control Module (PCM) - Keep alive power, |
| Canister vent | ||
| 37 | 15 | Transmission B+ |
| 38 | 30 | Third row seats (passenger side) |
| 39 | 50 | Air suspension pump |
| 40 | 30 | Starter motor |
| 41 | 20 | IP/Console power point |
| 42 | - | Not used |
| 43 | 20 | 4x4 module motor |
| 44 | - | Not used |
| 45 | 30 | Driver seat |
| 46 | 40 | Run/Start bus bar |
| 47 | 30 | Air suspension - solenoids |
| 48 | - | Not used |
| 49 | 30 | Front wipers/washer |
| 50 | 30 | PCM - bus bar |
| 51 | 20 | Cargo power point |
| 52 | 20 | Cigarette lighter |
| 53 | - | Air suspension relay |
| 54 | - | Starter relay |
| 55 | - | Trailer tow connector relay (park lamp) |
| 56 | - | Trailer tow connector relay (battery charge) |
| 57 | - | Run/Start relay |
| 58 | - | Not used |
| 59 | - | PCM relay |
| 60 | - | One-touch Start diode |
| 61 | - | A/С clutch diode |
| 62 | - | Fuel pump diode |
| 63 | 15 | Trailer tow connector (back-up lamp) |
| 64 | - | Not used |
| 65 | 10 | Air suspension logic |
| 66 | - | Not used |
| 67 | 10 | Blower coil |
| 68 | - | Not used |
| 69 | 30 | Run/Start - passenger compartment fuse panel |
| 70 | 20 | PCM (sensors) - EFC, |
| A/С clutch coil | ||
| 71 | 5 | Fuel coil, |
| ISP-R | ||
| 72 | 20 | PCM (ignition coils) |
| 73 | 5 | Transmission ignition |
| 74 | 20 | PCM (sensors) - HE GO/CMS, |
| MAFS, | ||
| EVMV, | ||
| CMCV, | ||
| Speed deactivation switch, | ||
| VCT | ||
| 75 | 5 | 4x4 Integrated Wheel Ends (IWE) solenoid |
| 76 | 20 | PCM - VPWR |
| 77 | 10 | ABS logic, Heated PCV |
Advertisements