Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Escape (2001, 2002, 2003, 2004, 2005, 2006, 2007).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
If electrical components in the vehicle are not working, a fuse may have blown. To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Check the appropriate fuses before replacing any electrical components.
Notice
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
The fuse panel is located on the left-hand side kick panel (2001-2004), or on the right-hand side of the center console, by the instrument panel (2005-2007). Remove the panel cover to access the fuses. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
Diagram 2001-2004
| № | A | Fused function |
|---|---|---|
| 1 | 5 | Canister vent control solenoid |
| 2 | 5 | Blower relay (coil), Pressure switch to PCM, Blower Relay (coil), Rear Defrost Relay (coil; up to 2002) |
| 3 | 10 | Rear wiper motor, Rear washer motor, Rear wiper relay (coil) |
| 4 | 10 | Four-wheel drive control module, Cluster (restraints control warning) |
| 5 | 5 | ABS unit (EVAC & FILL), ASC unit, Restraints Control Module (RCM), ASC main SW to ASC unit, Clock spring switch (as of 2003) |
| 6 | 10 | Flasher unit, Reversing lamps, Park Aid Module (PAM; as of 2003) |
| 7 | 10 | Passive Anti-theft Transceiver (PATS), Restraints Control Module, EEC fuse (as of 2003) |
| 8 | 10 | Cluster, Shift lock relay (coil), O/D signal to PCM, GEM (as of 2003), E/C autolamp mirror (as of 2003) |
| 9 | 3 | PCM relay (coil), Fan relay 1, 2, 3 (coil), A/C relay (coil) |
| 10 | 20 | Front wiper motor, Front washer motor |
| 11 | 10 | ACC relay (coil), Key interlock solenoid, GEM, IGN Relay (coil; up to 2002), Starter Relay (coil; up to 2002) |
| 12 | 5 | Radio, Clock (up to 2002) |
| 13 | — | Not used |
| 14 | 20 | Cigar lighter |
| 15 | 15 | Park lamp relay, Front position lamps, License lamps, Tail lamps, Park lamp relay (coil), Trailer fuse, Illumination fuse |
| 16 | 10 | Cluster, Power mirror, GEM, Heated seats (as of 2003) |
| 17 | 15 | Sun roof motor |
| 18 | 5 | Illumination for: Cluster, Heater unit, Radio, Hazard switch, Rear defrost switch, 4WD switch, Front fog switch |
| 19 | 10 | Subwoofer amp |
| 20 | 15 | Turn Indicators, Front Side Turn Lamps, Front turn lamps, Rear turn lamps, Trailer turn, Flasher unit |
| 21 | 10 | Trailer position lamps |
| 22 | 15 | Not used |
| 23 | 20 | as of 2002: Horn relay |
| 15 | up to 2001: Horn | |
| 24 | 15 | Stoplamps, High mounted stoplamp, Trailer stoplamp, ABS unit, ASC unit (Brake Pedal Position Switch), PCM, Shift solenoid |
| 25 | 30 | Power window motors |
| 26 | 30 | Power door lock motors, GEM (door lock relay coil), Power seat, 4WD relay (as of 2003) |
| 27 | 10 | GEM, Audio, Cluster, Interior lamp, Map lamp, Cargo lamp, Datalink connector (as of 2003) |
| ACC | Accessory relay | |
Advertisements
Diagram 2005-2007
| № | A | Fused function |
|---|---|---|
| 1 | 15 | Trailer tow park lamps |
| 2 | — | Not used |
| 3 | 15 | Front and rear park lamps |
| 4 | 10 | Ignition switch |
| 5 | 2 | Powertrain Control Module (PCM relay), Fuel pump relay, Main fan relay, High/Low speed fan relay 2, PATS module |
| 6 | 15 | Center High-Mounted Stop Lamp (CHMSL), Stop lamps, PCM, Anti-lock Brake System (ABS), Speed control, Brake On-Off switch |
| 7 | 10 | Instrument cluster, Diagnostic connector, Power mirror switch, Radio |
| 8 | 5 | as of 2007: Canister vent |
| 9 | 30 | Power door locks, Power seats |
| 10 | 15 | Heated mirrors |
| 11 | 15 | Sunroof, Electrochromatic mirror |
| 12 | 5 | Radio |
| 13 | — | Not used |
| 14 | — | Not used |
| 15 | 30 | Power windows |
| 16 | 15 | Subwoofer |
| 17 | 15 | Low beams |
| 18 | 10 | 4WD |
| 19 | — | Not used |
| 20 | 15 | Horn |
| 21 | 10 | up to 2006: Rear wiper motor, Rear wiper washer |
| 15 | as of 2007: Rear wiper motor, Rear wiper washer | |
| 22 | 10 | Instrument cluster |
| 23 | — | Not used |
| 24 | 20 | Cigar lighter |
| 25 | 20 | Front wiper motor, Front wiper washer |
| 26 | 5 | Climate control system mode switch |
| 27 | 5 | Canister vent (up to 2006), Speed control cancel switch |
| 28 | 10 | Instrument cluster |
| 29 | 10 | Reverse park aid |
| 30 | — | Not used |
| 31 | — | Not used |
| 32 | 10 | Brake-Transmission shift lock |
| 33 | 15 | Air bag module, Passenger Air bag Deactivation (PAD) indicator lamp, Occupant Classification Sensor (OCS) |
| 34 | 5 | ABS module, Evac and Fill, Speed control |
| 35 | 5 | Heated seats module, 4WD |
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment.
Diagram 2001-2004
| Fuse | A | Fused function |
|---|---|---|
| Horn | 15 | Horn |
| H/L LH | 15 | Headlamp (high/low left, High beams) |
| H/L RH | 15 | Headlamp (high/low right, High beams) |
| EEC | 5 | EEC (KPWR) |
| HE GO | 15 | HEGO 1,2, CMS 1,2, VMV |
| FUEL | 20 | Fuel pump, EEC (FPM) |
| HTD SEATS | 30 | Heated seats (if equipped) |
| INJ | 30 | EEC (VPWR), EVR, MAF, I AC, Bulkhead, HEGO fuse (as of 2003) |
| MAIN | 120 | Main |
| ALT | 15 | Alternator/ Regulator |
| DRL | 15 | Daytime Running Lamps (DRL) unit (feed), DRL relay |
| DRL2 | 15 | DRL module |
| HLEV | 10 | DHLEV |
| PWR 1 | 15 | Auxiliary power point |
| FOG | 20 | Foglamps, Foglamp indicator |
| A/C | 15 | A/C clutch |
| ABS | 25 | Anti-Lock Brake System (ABS) SOL, EVAC & FILL (as of 2003) |
| PWR 2 | 15 | Auxiliary power point |
| IG MAIN | 40 | Starter |
| HTR | 40 | Blower motor, Blower motor relay |
| BTN 1 | 40 | JB - Accessory relay, Radio, TNS relay, Cigar lighter, Cluster, Power mirror, GEM, Accessory delay relay (as of 2003), Power windows (as of 2003), Power moonroof (as of 2003), Clock (up to 2002) |
| (ABS) | 60 | ABS motor, EVAC & FILL (as of 2003) |
| BTN 2 | 40 | JB - Radio, CD changer, Cluster, Dome lamps, Map lamps, Cargo lamps, Horn relay (as of 2003), GEM, Power locks (as of 2003), Speed control (as of 2003) |
| MAIN FAN | 40(2.0L) 50(3.0L) | Main fan |
| RDEF | 30 | Rear defroster |
| ADD FAN | 40(2.0L) 50(3.0L) | Add fan |
| EEC MAIN ISO | EEC relay | |
| FUEL PUMP ISO | Fuel pump relay | |
| MAIN FAN ISO | Low-speed fan control relay (2.0L engine) | |
| High-speed fan control relay I (3.0L engine) | ||
| ADD FAN ISO | High-speed fan control relay 1 (2.0L engine) | |
| Low-speed fan control relay (3.0L engine) | ||
| DEF RELAY ISO | Rear defroster relay | |
| ST RELAY ISO | Starter relay | |
| ADD FAN 2 ISO | High-speed fan control relay 2 (3.0L engine) | |
| Medium-speed fan control relay (2.0L engine) | ||
| FOG RELAY MICRO | Foglamp relay | |
| A/C RELAY MICRO | A/C clutch relay | |
| H/L RELAY MICRO | Headlamp (high/low, right/left relay) | |
| DIODE | — | |
| DIODE | — | |
Advertisements
Diagram 2005-2007
| № | A | Fused function |
|---|---|---|
| 1 | — | Not used |
| 2 | 25 | Headlamp power |
| 3 | 25 | High beams, Turn signals, Interior lamps, Headlamp power |
| 4 | 5 | Keep Alive Power (KA PWR) |
| 5 | 15 | Heated Exhaust Gas Oxygen (HEGO) sensors |
| 6 | 20 | Fuel pump |
| 7 | 40 | RUN/ACC relay -Electrochromatic mirror, Cigar lighter, Front and rear wipers |
| 8 | 30 | Powertrain Control Module (PCM), Injectors and coil |
| 9 | 15 | Alternator |
| 10 | 30 | Heated seats |
| 11 | 10 | PCM |
| 12 | 20 | Power point |
| 13 | 20 | Fog lamps |
| 14 | 15 | A/C clutch, A/C relay |
| 15 | 30 | Anti-lock Brake System (ABS) solenoid |
| 16 | 25 | I/P fuse panel (RUN/START) |
| 17 | 50 | Ignition (main) |
| 18 | 40 | Blower motor |
| 19 | 40 | Accessory delay relay - Subwoofer and 4WD, Low beam |
| 20 | 60 | ABS |
| 21 | 40 | Horn, CHMSL, Cluster, Power locks and power seats |
| 22 | 40 (I4) 50 (V6) | Cooling fan |
| 23 | 40 | Rear defroster, Park lamps relay |
| 24 | 40 (I4) 50 (V6) | High/Low speed fan |
| 25 | — | Shunt |
| R2 | PCM relay | |
| R3 | Fuel pump relay | |
| R4 | Cooling fan relay | |
| R5 | High/Low speed fan relay 1 | |
| R6 | Blower motor relay | |
| R7 | Starter relay | |
| R8 | High/Low speed fan relay 2 | |
| R9 | Fog lamps relay | |
| R10 | A/C relay | |
| D1 | Not used | |
| D2 | A/C diode | |
Advertisements