Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford C-Max, C-Max Energi, C-Max Hybrid (2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
If an electrical device is not working, check whether the respective fuse is blown. The conductor should be intact. If it is not, replace the fuse with another with the same amperage (same color).
Note
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can cause damage to the electrical system and fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- Do not modify the electrical system of your vehicle in any way. Have repairs to the electrical system and the replacement of relays and high current fuses carried out by properly trained technicians.
- If a fuse blows again contact a qualified service center.
Engine Compartment Fuse Box
Europe
USA (Hybrid, Energi)
| № | A | Protected components |
|---|---|---|
| 1 | 50 | Hybrid, Energi: Cooling fan module |
| 2 | 50 | Hybrid, Energi: Electric water pump |
| 3 | 50 | Hybrid, Energi: Body control module supply 1 |
| 4 | 50 | Hybrid, Energi: Body control module supply 2 |
| 5 | - | Hybrid, Energi: - |
| 6 | - | Hybrid, Energi: - |
| 7 | 40 | Anti-lock Braking System pump |
| 8 | 30 | Anti-lock Braking System valve |
| 9 | 20 | Europe: Headlamp washer |
| 40 | Hybrid, Energi: Vacuum pump | |
| 10 | 40 | Heater blower |
| 11 | 30 | 2011-2015 (EU): Voltage quality module |
| 2015-2018 (EU): Auto-Start-Stop module | ||
| Hybrid, Energi: Engine management | ||
| 12 | 30 | Powertrain control module (except Hybrid, Energi) |
| 13 | 30 | Europe: Starter relay |
| 25 | Hybrid, Energi: Powertrain control module relay | |
| 14 | 40 | Europe: Heated windscreen (right-hand side) |
| 20 | Hybrid, Energi: Rear wiper | |
| 15 | 25 | 1.0L EcoBoost: Intercooler Fan |
| 40 | 2015-2018 (EU): Cooling fan relay 1 | |
| 30 | Hybrid, Energi: Body control module KL30 supply | |
| 16 | 40 | Europe: Heated windscreen (left-hand side) |
| 20 | Hybrid, Energi: Body control module 15 feed | |
| 17 | 20 | Europe: Auxiliary heater |
| Energi: Transmission oil pump | ||
| 18 | 20 | Windscreen wipers |
| 19 | 5 | Anti-lock Braking System, electronic stability program module |
| 20 | 15 | Horn |
| 21 | 5 | Stop light switch |
| 22 | 15 | Europe: Battery monitoring system |
| 5 | Hybrid, Energi: Vacuum pump monitoring | |
| 23 | 5 | Europe: Relay coils, lighting control switch module |
| 5 | Hybrid, Energi: Engine control module 15, powertrain control module 15, transmission oil pump 15 | |
| 24 | 20 | Europe: Rear power outlet |
| 5 | Hybrid, Energi: Relay coils, light switch module | |
| 25 | 10 | 2011-2015 (EU): Electric exterior mirrors |
| Hybrid, Energi: Motor electronic cooling pump | ||
| 26 | 15 | 2011-2015 (EU): Powertrain control module |
| 2015-2018 (EU): Transmission control module - 6-speed powerShift transmission | ||
| 25 | 2015-2018 (EU): Transmission control module - 6-speed automatic transmission | |
| 5 | Hybrid, Energi: Electronic power assist steering module 15 | |
| 27 | 15 | Europe: Air conditioning clutch |
| 5 | Hybrid, Energi: Mass air flow sensor | |
| 28 | 7.5 | 2015-2018 (EU): Rear view camera, collision warning system |
| 15 | Hybrid, Energi: Powertrain control module | |
| 29 | 25 | 2011-2015 (EU): Heated rear window |
| 10 | Hybrid, Energi: Electronic A/C compressor, positive temperature coefficient heater | |
| 30 | 5 | Hybrid, Energi: Powertrain control module |
| 10 | Europe: Engine control module, powertrain control module | |
| 31 | 5 | Energi: Charge port light ring |
| 32 | 10 | 2011-2015 (EU): Exhaust gas recirculation valve, swirl control valves, heated exhaust gas oxygen sensor (engine management), electronic fan control module relay (coil), run on water pump module (1.0L EcoBoost) |
| 2015-2018 (EU): Powertrain control module, cooling fan relay | ||
| 20 | Hybrid, Energi: Vehicle power 2 | |
| 33 | 10 | 2011-2015 (EU): Ignition Coils |
| 15 | 2015-2018 (EU): | |
| 1.5L, 1.6L, 2.0L: Powertrain control module, ignition coils | ||
| 20 | 2015-2018 (EU): | |
| 1.0L EcoBoost: Powertrain control module, ignition coils | ||
| 15 | Hybrid, Energi: Vehicle power 4 | |
| 34 | 10 | Injectors |
| 35 | 5 | 2011-2015 (EU): |
| Gasoline: Intercooler relay coil | ||
| 15 | 2011-2015 (EU): | |
| Diesel: Filter heater | ||
| 10 | 2015-2018 (EU): | |
| 1.5L, 1.6L, 2.0L: Water-in-fuel sensor (1.5L, 2.0L), powertrain control module, ignition coils | ||
| 15 | 2015-2018 (EU): | |
| 1.0L EcoBoost: Powertrain control module, ignition coils | ||
| 10 | Hybrid, Energi: Vehicle power 3 | |
| 36 | 10 | 2011-2015 (EU): Powertrain control module |
| 5 | 2015-2018 (EU): Active grille shutter | |
| 20 | Hybrid, Energi: Vehicle power 1 | |
| 37 | - | - |
| 38 | 15 | Powertrain control module, transmission control module (2011-2015 (EU)) |
| 39 | 5 | Headlamp control module |
| 40 | 5 | Electric power assisted steering |
| 41 | 20 | Body Control Module |
| 42 | 15 | 2011-2015 (EU): Rear window wiper |
| 43 | 15 | Headlamp levelling, adaptive front lighting module (2015-2018 (EU)) |
| 44 | 5 | 2015-2018 (EU): Adaptive cruise control |
| 45 | 10 | Windshield heated washer jets |
| 46 | 25 | 2011-2015 (EU): Power windows (front) |
| 2015-2018 (EU): Cooling fan | ||
| 47 | 7.5 | 2011-2015 (EU): Heated exterior mirrors |
| 48 | 15 | Diesel particulate filter vaporizer |
| R1 | Europe: Intercooler fan | |
| R2 | Horn | |
| R3 | Europe: Diesel particulate filter vaporizer | |
| Hybrid powertrain control | ||
| R4 | Front wiper on/off | |
| R5 | Headlamp washer | |
| R6 | Front wiper hi/low | |
| R7 | Europe: Heated windshield | |
| Hybrid, Energi: Vacuum pump | ||
| R8 | Europe: Cooling fan | |
| Hybrid, Energi: Ignition feed | ||
| R9 | - | |
| R10 | Europe: Cooling fan | |
| Hybrid, Energi: Vacuum pump sensor | ||
| R11 | Europe: Air conditioning clutch | |
| R12 | Cooling fan | |
| R13 | Blower motor | |
| R14 | Engine control module | |
| R15 | Europe: Starter | |
| R16 | Europe: Ignition | |
Advertisements
Passenger Compartment Fuse Box Diagram
The fuse panel is located on the right-hand side below the glove box. Pinch the retaining clips to release the cover. Then, lower the fuse box cover and pull it towards you.
| № | A | Protected components |
|---|---|---|
| 56 | 20 | Fuel pump |
| 57 | - | - |
| 58 | - | - |
| 59 | 5 | Passive anti-theft system supply |
| 60 | 10 | Interior lamp, driver's door switch pack, glove box light, ambient lighting, overhead console switch bank |
| 61 | 20 | Cigar lighter, rear auxiliary power points |
| 62 | 5 | Rain sensor module, auto-dimming mirror, humidity sensor |
| 63 | 10 | 2015-2018 (EU): Adaptive cruise control |
| 64 | - | - |
| 65 | 10 | Liftgate release |
| 66 | 20 | Driver's door lock, double locking, fuel door lock (2015-2018 (EU)) |
| 67 | 7.5 | Information and entertainment display, SYNC module, global positioning system module, cell phone passport (Energi) |
| 68 | 15 | Europe: Steering column lock |
| 69 | 5 | Instrument cluster |
| 70 | 20 | Central locking |
| 71 | 10 | 2011-2015: Air conditioning, heating control head (manual A/C (Hybrid, Energi)) |
| 7.5 | 2015-2018: Air conditioning | |
| 72 | 7.5 | Steering wheel control module |
| 73 | 5 | Alarm, on-board diagnostics II, battery backup sounder |
| 74 | 15 | Main beam |
| 75 | 15 | Front fog lamps |
| 76 | 10 | Reversing lamp |
| 77 | 20 | Front and rear windshield washer pump |
| 78 | 5 | Ignition switch, push button ignition switch, keyless vehicle module |
| 79 | 15 | Hazard flasher switch, voice control module, radio, navigation system, DVD player, CD changer, door lock button |
| 80 | 20 | 2015-2018 (EU): Moonroof |
| 81 | 5 | Interior motion sensor, radio frequency receiver, sun blinds |
| 82 | 20 | Washer pump ground |
| 83 | 20 | Central locking ground |
| 84 | 20 | Driver's door lock and double locking ground, fuel door unlock (2015-2018 (EU)) |
| 85 | 7.5 | Radio, navigation system, passenger airbag deactivation switch, heated front seats switch, parking heater, manual air conditioning heater module, rear wiper relay, auxiliary heater, adaptive cruise control |
| 86 | 10 | Restraint system, occupant classification system, passenger air bag deactivation indicator |
| 87 | 15 | Heated steering wheel |
| 88 | 20 | 2015-2018 (EU): Voltage quality module |
| 89 | - | 2015-2018 (EU): - |
Advertisements
Luggage Compartment Fuse Box Diagram
The fuse panel is located in the luggage compartment behind the left side wheel well. Remove the fuse panel cover to gain access to the fuses.
| № | A | Protected components |
|---|---|---|
| 1 | 5 | Hands-free liftgate entry module |
| 2 | 10 | Keyless vehicle module |
| 3 | 5 | Keyless vehicle door handles |
| 4 | 25 | Door module (left-hand front) (power windows, central locking, electric folding exterior mirror, heated exterior mirror) |
| 5 | 25 | Door module (right-hand front) (power windows, central locking, electric folding exterior mirror, heated exterior mirror) |
| 6 | 25 | Door module (left-hand rear) (power windows) |
| 7 | 25 | Door module (right-hand rear) (power windows) |
| 8 | 10 | Anti-theft alarm |
| 25 | Hybrid, Energi: Passenger seat motor | |
| 9 | 25 | Power driver's seat |
| 10 | 25 | 2015-2018 (EU): Power windows |
| Hybrid, Energi: Heated rear window | ||
| 11 | 5 | 2015-2018: Ignition relay |
| 12 | 10 | 2011-2015 (EU): Air conditioning module |
| 15 | Hybrid, Energi: Battery electronics control module | |
| 13 | 5 | 2011-2015 (EU): Instrument cluster module |
| 14 | 7.5 | Information and entertainment display, GPS module (with start-stop module) |
| 10 | Energi: Charger | |
| 15 | 15 | 2011-2015 (EU): Audio unit, audio unit control panel module |
| 16 | - | - |
| 17 | 10 | Battery electronics control module |
| 18 | 15 | Battery electronics control module — fan |
| 19 | 15 | Energi: Charger fan |
| 20 | - | - |
| 21 | 10 | Hybrid, Energi: |
| 2013: Smart datalink connector | ||
| 15 | Hybrid, Energi: | |
| 2014-2018: Smart datalink connector | ||
| 22 | 10 | Hybrid, Energi: Active noise cancellation |
| 23 | - | - |
| 24 | 30 | DC/AC power converter |
| 25 | 25 | Power liftgate |
| 26 | 40 | Europe: Trailer tow module |
| Energi: AC/DC charger | ||
| 27 | 30 | 2015-2018 (EU): Rear window defroster |
| 20 | Hybrid, Energi: Luggage compartment outlet | |
| 28 | - | - |
| 29 | 5 | Blind spot monitor, lane keeping aid, active city stop, rear view camera (without start-stop module), extended ignition signal (with start-stop module |
| 30 | 5 | Park aid Module |
| 31 | 5 | Hybrid, Energi: Rear view camera |
| 32 | 5 | DC/AC power converter |
| 33 | 15 | 2015-2018 (EU): Rear window wiper relay |
| 34 | 15 | Europe: Heated driver's seat |
| 20 | Hybrid, Energi: Heated driver's seat | |
| 35 | 15 | Europe: Heated front passenger seat |
| 20 | Hybrid, Energi: Heated front passenger seat | |
| 36 | - | - |
| 37 | 20 | Sun blind system |
| 38 | - | - |
| 39 | - | - |
| 40 | - | - |
| 41 | - | - |
| 42 | - | - |
| 43 | - | - |
| 44 | 10 | 2015-2018 (EU): Power exterior mirrors |
| 45 | 7.5 | 2015-2018 (EU): Heated exterior mirrors |
| 5 | Hybrid, Energi: Humidity sensor | |
| 46 | 5 | 2011-2015 (EU): Blind spot monitor, lane keeping aid, rear view camera (with start-stop module) |
| 10 | Hybrid, Energi: Fuel system | |
| R1 | Europe: Ignition switch | |
| Hybrid, Energi: Rear 15 relay | ||
| R2 | Heated rear window | |
| R3 | Europe: Rear window wiper | |
| Energi: Fuel door | ||
| R4 | - | |
| R5 | Europe: Anti-theft alarm horn | |
| R6 | Delayed accessory power | |
| Hybrid, Energi: Rear window wiper | ||
Advertisements