Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford F150 / SVT Raptor / Ford Lobo (2009, 2010, 2011, 2012, 2013, 2014).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
The fuse panel is located under the right-hand side of the instrument panel.
Pull the panel toward you and swing it out away from the side to remove the trim panel. To reinstall it, line up the tabs with the grooves on the panel, then push it shut.
To remove the fuse box cover, press in the tabs on both sides of the cover, then pull the cover off. To reinstall the fuse box cover, place the top part of the cover on the fuse panel, then push the bottom part of the cover until you hear it click shut. Gently pull on the cover to make sure it is seated properly.
Diagram 2009-2010
| № | A | Protected Circuit |
|---|---|---|
| 1 | 30 | Moon roof |
| 2 | 15 | Not used (spare) |
| 3 | 15 | Not used (spare) |
| 4 | 30 | Not used (spare) |
| 5 | 10 | Keypad illumination, Brake Shift Interlock (BSI), SJB microprocessor power |
| 6 | 20 | Turn signals, Stop lamps |
| 7 | 10 | Low beam headlamps (left) |
| 8 | 10 | Low beam headlamps (right) |
| 9 | 15 | Interior courtesy lights, Cargo lamps |
| 10 | 15 | Backlighting, Puddle lamps |
| 11 | 10 | 2010: GPS module |
| 12 | 7.5 | Power mirror switch, Memory seat module microprocessor power, Steering column switch |
| 13 | 5 | SYNC |
| 14 | 10 | 2010: Ambient lighting module |
| 15 | 10 | Climate control |
| 16 | 15 | Ignition switch feed |
| 17 | 20 | All lock motor feeds |
| 18 | 20 | Driver memory seat switch |
| 19 | 25 | Not used (spare) |
| 20 | 15 | Adjustable pedals, Datalink |
| 21 | 15 | Fog lamps, Fog lamp indicator |
| 22 | 15 | Park lamps, Side marker lamps |
| 23 | 15 | High beam headlamps |
| 24 | 20 | Horn |
| 25 | 10 | Interior demand lamps, Mid box power feed |
| 26 | 10 | Instrument panel cluster, Key out inhibit solenoid, Radio info display (CID), Radio buttons, Key-in chime |
| 27 | 20 | Not used |
| 28 | 5 | Radio muting |
| 29 | 5 | Instrument panel cluster |
| 30 | 5 | Passenger airbag disable indicator |
| 31 | 10 | Restraints control module |
| 32 | 10 | Non-integrated compass module, Heated-only seat module |
| 33 | 10 | Trailer brake controller |
| 34 | 5 | Electronic locking differential indicator |
| 35 | 10 | Rear park assist |
| 36 | 5 | Passive anti-theft system transceiver |
| 37 | 10 | 2010: Upfitter relay coils |
| 38 | 20 | Subwoofer |
| 39 | 20 | Radio, Navigation display |
| 40 | 20 | 2010: Rear heated seats module |
| 41 | 15 | Automatic dimming mirror, Door lock switch illumination, Radio accessory delay |
| 42 | 10 | Not used (spare) |
| 43 | 10 | Heated mirror/backlight relay, Rain sensor, Reverse camera |
| 44 | 10 | Not used (spare) |
| 45 | 5 | Front wiper logic, Blower motor relay |
| 46 | 7.5 | Occupant classification sensor (OCS) |
| 47 | 30 | Circuit Breaker: Power windows, Moon roof, Power sliding backlight |
| 48 | Delayed accessory relay (Feeds fuse 41 and circuit breaker 47) | |
Advertisements
Diagram 2011-2014
| № | A | Protected Circuit |
|---|---|---|
| 1 | 30 | Driver side front window |
| 2 | 15 | SYNC, Display module (8 Inch) (2013-2014) |
| 3 | 30 | Passenger side front window |
| 4 | 10 | Interior lamps |
| 5 | 20 | Memory module |
| 6 | 5 | Not used (spare) |
| 7 | 7.5 | Power mirror switch. Memory seat module |
| 8 | 10 | Not used (spare) |
| 9 | 10 | Radio display, GPS module. Electric finish panel module (2013-2014), Navigation display (2011-2012) |
| 10 | 10 | Run/accessory relay |
| 11 | 10 | Instrument cluster |
| 12 | 15 | Interior lighting, Puddle lamps, lighting. Cargo lamp |
| 13 | 15 | Right turn signals/stop lamps |
| 14 | 15 | Left turn signals/stop lamps |
| 15 | 15 | Reverse lights. High-mounted |
| 16 | 10 | Right low-beam headlamp |
| 17 | 10 | Left low-beam headlamp |
| 18 | 10 | Brake-shift interlock, Keypad illumination, Powertrain control module wake-up, Passive anti-theft system |
| 19 | 20 | Audio amplifier |
| 20 | 20 | Power door locks |
| 21 | 10 | 2011-2012: Ambient lighting |
| 22 | 20 | Horn |
| 23 | 15 | Steering wheel control module |
| 24 | 15 | Datallnk connector. Steering wh module |
| 25 | 15 | Not used (spare) |
| 26 | 5 | Radio frequency module |
| 27 | 20 | Not used (spare) |
| 28 | 15 | Ignition switch |
| 29 | 20 | Radio |
| 30 | 15 | Front parking lamps |
| 31 | 5 | Brake on/off - Instrument panel. Engine |
| 32 | 15 | Delay/accessory - moonroof, power windows, locks. Automatic dimming mlrror/Compass, Trailer tow power telescope mirrors |
| 33 | 10 | Rear heated seats |
| 34 | 10 | Reverse sensing system, 4x4 switch, Rear video, Off-road indicator (SVT Raptor), Front video (SVT Raptor), Camera splice module (SVT Raptor) |
| 35 | 5 | Hill descent switch (SVT Raptor) |
| 36 | 10 | Restraint control module, Oc flcatlon system module |
| 37 | 10 | Trailer brake control |
| 38 | 10 | Delayed accessory - 110-volt Radio |
| 39 | 15 | Hlgh-beam headlamps |
| 40 | 10 | Rear park lamps |
| 41 | 7.5 | Passenger airbag deactivate Auxiliary switch (SVT Rapto |
| 42 | 5 | Overdrive cancel switch |
| 43 | 10 | Not used (spare) |
| 44 | 10 | Not used (spare) |
| 45 | 5 | Not used (spare) |
| 46 | 10 | Climate controls module |
| 47 | 15 | Fog lamps, Exterior mirror tu |
| 48 | 30 | Circuit breaker: Power windows, Power sliding back window |
| 49 | Delayed accessory | |
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Advertisements
| № | A | Protected Circuit |
|---|---|---|
| 11 | 30 | Power running board motors |
| 12 | 40 | 2010-2014: Electric fan |
| 50 | 2011-2014: Electric fan (3.5L, 6.2L with max trailer tow, SVT Raptor) | |
| 13 | 30 | Starter relay power |
| 14 | 30 | Passenger power seat |
| 15 | 40 | 2010-2014: Electric fan |
| 50 | 2011-2014: Electric fan (3.5L, 6.2L wlth max trailer tow, SVT Raptor) | |
| 16 | 20 | 2013-2014: Hlgh-lntenslty discharge headlamp -passenger side |
| 17 | 30 | Trailer brake control |
| 18 | 30 | 2010-2014: Auxiliary switch 1 (SVT Raptor) |
| 19 | 30 | 2010-2014: Auxiliary switch 2 (SVT Raptor) |
| 20 | 20 | 4x4 module (electronic shift) |
| 21 | 30 | Trailer tow battery charge relay power |
| 22 | 20 | Auxiliary power point (Instrument panel) |
| 26 | 10 | Powertrain control module - keep alive power and relay coll, canister vent solenoid, transmission (2009-2010) |
| 27 | 20 | Fuel pump relay power |
| 28 | 10 | 2010-2014: Auxiliary switch 4 (SVT Raptor) |
| 29 | 10 | 4x4 integrated wheel end solenoid |
| 30 | 10 | Air conditioner clutch relay power |
| 31 | 15 | 2011-2014: Run/start relay power |
| 20 | 2009-2010: Trailer tow park lamp relay | |
| 32 | 40 | Rear window defroster relay power, Heated mirror relay power |
| 33 | 40 | 2011-2014: 110-volt AC power point |
| 34 | 40 | 2009-2014: Powertrain control module relay power |
| 50 | 2011-2014: Powertrain control module relay power (3.5L engine) | |
| 35 | 20 | 2013-2014: Hlgh-lntenslty discharge headlamps -driver side |
| 36 | 30 | Roll stability control / Anti-lock brake system |
| 41 | 15 | 2012-2014: Front camera washer (SVT Raptor) |
| 2010: Heated mirror | ||
| 42 | 5 | 2011-2014: Run/start relay coll |
| 43 | 15 | 2011-2014: Trailer tow back-up lamp relay power |
| 20 | 2009-2010: Backup lamp relay | |
| 44 | 15 | 2010-2014: Auxiliary switch 3 (SVT Raptor), Trailer tow power folding mirrors |
| 45 | 10 | 2011-2014: Alternator sensor |
| 20 | 2009-2010: Trailer tow stop turn relay feed | |
| 46 | 10 | Brake on/off switch |
| 47 | 60 | Roll stability control / Anti-lock brake system module (2011-2014) |
| 48 | 20 | 2011-2014: Moonroof |
| 49 | 30 | Wiper relay power |
| 50 | - | Not used |
| 51 | 40 | Blower motor relay power |
| 52 | 5 | 2011-2014: Run/start - Electronic power assist steering. Blower relay coll |
| 53 | 5 | 2011-2014: Run/start - Powertrain control module |
| 2009-2010: PCM, 6R80 transmission | ||
| 54 | 5 | 2011-2014: Run/start - 4x4 module. Back-up lamps, Roll stability control /Anti-lock brake system. Trailer tow battery charge relay coll. Rear window defroster relay coll. Front camera washer relay coll (SVT Raptor) |
| 2009-2010: 4x4 module, Back up lamp, RSC, Trailer tow battery charge relay | ||
| 55 | 5 | 2009-2010: Electronic compass mirror (6R transmission only) |
| 56 | 15 | 2011-2014: Heated mirrors |
| 57 | - | Not used |
| 58 | 15 | 2009-2010: Trailer tow backup lamps |
| 59 | 15 | 2009: Heated mirrors |
| 60 | - | 2009-2010: One-touch Start diode |
| 61 | - | 2009-2010: Fuel pump diode |
| 63 | 25 | 2010-2014: Electric fan relay power |
| 64 | 30 | 2009-2010: Amplifier |
| 40 | 2011-2012: Vacuum pump relay power (3.5L engine) | |
| 65 | 20 | Auxiliary power point (Instrument panel) |
| 66 | 20 | Auxiliary power point (Inside center console) |
| 67 | 20 | 2011-2014: Trailer tow park lamps relay power |
| 68 | 25 | 4x4 module, 4x2 elocker module (2013-2014) |
| 69 | 30 | Front heated or heated/cooled seats |
| 70 | - | Not used |
| 71 | 20 | 2011-2014: Heated rear seats |
| 72 | 20 | Auxiliary power point (rear) |
| 73 | 20 | 2011-2014: Trailer tow stop/turn lamps relay power |
| 74 | 30 | Driver power seat/memory module |
| 75 | 15 | 2009-2014: Powertrain control module - voltage power 1 |
| 25 | 2011-2014: Powertrain control module - voltage power 1 (3.5L engine) | |
| 76 | 20 | 2011-2014: Powertrain control module - Voltage power 2: General powertrain components (Mass air flow/intake air temp sensor -3.7L, 5.0L, 6.2L engines) (Canister vent solenoid - 3.5L engine) |
| 2009-2010: Voltage power 2, Voltage - battery voltage, Mass air flow/Intake air temp, CMS 12 and 22 with 6R80 transmission, Brake on/off switch (BOO) | ||
| 77 | 10 | 2011-2014: Powertrain control module - Voltage power 3 (Emission related powertrain components, Electric fan relays coll) |
| 2009-2010: Voltage power 3, Electric fan clutch, A/C clutch relay coil, Floor shifter (4–speed transmission) | ||
| 78 | 15 | 2010-2014: Powertrain control module - Voltage power 4 - Ignition colls (3.5L, 3.7L, 5.0L engines) |
| 20 | 2011-2014: Powertrain control module - Voltage power 4 - Ignition colls (6.2L engine) | |
| 25 | 2009: Ignition coils, Voltage power 4 | |
| 79 | 5 | 2011-2014: Rain sensor |
| 10 | 2009-2010: CMS 4–speed transmission, 12 and 22 with 4–speed transmission | |
| 80 | - | Not used |
| 81 | - | Not used |
| 82 | 10 | 2009-2010: Trailer Brake Control Module (TBCM), After market Center High Mounted Stop Lamp (CHMSL) |
| 83 | - | Not used |
| 84 | - | Not used |
| 1 | Powertrain control module | |
| 2 | Starter | |
| 3 | Blower motor | |
| 4 | Rear window defroster | |
| 5 | 2010-2014: Electric fan (high speed) | |
| 6 | Trailer tow park lamp | |
| 7 | 2010: Upfitter 1 relay | |
| 2011-2014: Run/start | ||
| 8 | Fuel pump | |
| 9 | Trailer tow battery charger | |
| 10 | 2010: Upfitter 2 relay | |
| 2011-2014: Powertrain control module (3.5L engine) | ||
| 23 | Air conditioner clutch | |
| 24 | Not used | |
| 25 | Not used | |
| 37 | Trailer tow left stop/turn | |
| 38 | Trailer tow right stop/turn | |
| 39 | Trailer tow back-up lamps | |
| 40 | 2010-2014: Electric fan | |
| 62 | 2011-2014: Wiper motor | |
| 2010: Upfitter 3 relay | ||
| 85 | 2010-2014: Electric fan (low speed) | |
Auxiliary Relay Box (SVT Raptor only)
The relay box is located in the left-hand corner of the engine compartment near the windshield.
| № | Protected Circuit |
|---|---|
| 1 | Auxiliary switch 1 |
| 2 | Auxiliary switch 2 |
| 3 | Auxiliary switch 3 |
| 4 | Auxiliary switch 4 |
| 5 | Front camera washer |
| 6 | Not used |
Advertisements