Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays:
- Chrysler 300 / 300C (2005-2010)
- Dodge Charger (2006-2010)
- Dodge Magnum (2005-2008)
Checking and Replacing Fuses
The wiring circuits in the vehicle are protected from short circuits by fuses. This greatly reduces the chance of damage caused by electrical problems.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure to replace a bad fuse with a new one of the identical size and rating.
Fuses of the same amperage can be temporarily borrowed from another fuse location if a fuse goes out. Replace the fuse as soon as possible.
Note
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can cause damage to the electrical system and fire.
- If a fuse blows again contact a qualified service center.
- When installing the Power Distribution Center cover, it is important to ensure the cover is properly positioned and fully latched. Failure to do so may allow water to get into the Power Distribution Center, and possibly result in an electrical system failure.
- When replacing a blown fuse, it is important to use only a fuse having the correct amperage rating. The use of a fuse with a rating other than indicated may result in a dangerous electrical system overload. If a properly rated fuse continues to blow, it indicates a problem in the circuit that must be corrected.
Engine Compartment Fuse Box Diagram
A front power distribution center is located in the engine compartment.
| № | A | Protected Component |
|---|---|---|
| 1 | 20 | HID: Left High Intensity Discharge Lamp |
| 2 | 20 | HID: Right High Intensity Discharge Lamp |
| 3 | 15 | Adjustable Pedals Relay (except Memory) |
| 4 | 20 | Horn Relay, Front Control Module, Air Conditioner Compressor Clutch (Gasoline) |
| 5 | 20 | HID: Headlamp Washer Relay |
| 20 | Cluster (2005) | |
| 20 | Police: Underhood Lamp | |
| 6 | 15 | Front Control Module |
| 7 | 20 | Front Fog Lamp, Front Control Module |
| 8 | 15 | Park Lamp Relay (Front Park/Turn Lamp, Front/Rear Side Marker Lamp, License Lamp, Tail/Stop Lamp or Tail/Stop/Park Lamp), Front Control Module |
| 9 | 15 | Front Control Module |
| 10 | 5 | Powertrain Control Module, Starter Relay, Engine Control Module (Diesel) |
| 11 | 15 | SRT8: Powertrain Control Module |
| 20 | execept SRT8: Powertrain Control Module | |
| 12 | - | - |
| 13 | - | - |
| 14 | 20 | SRT8: Powertrain Control Module |
| 25 | execept SRT8: Powertrain Control Module | |
| 20 | 2005: Powertrain Control Module | |
| 25 | Diesel: Engine Control Module, PTC Relay No.1, PTC Relay No.2, PTC Relay No.3 | |
| 15 | 25 | Gasoline (execept SRT8): Fuel Injector, Ignition Coil, Ignition Capacitor, Short Runner Valve Solenoid (3.5L) |
| 20 | 2005: Fuel Injector, Ignition Coil, Ignition Capacitor | |
| 20 | SRT8: Fuel Injector, Ignition Coil, Ignition Capacitor | |
| 25 | Diesel: Engine Control Module, Glow Plug Module, Oxygen Sensor, Intake Swirl Servo Motor, Crankcase Vent Heater, EGR Valve, Boost Pressure Servo Motor, Air Conditioner Compressor Clutch, Fuel Pump Relay, | |
| 16 | 15 | Diesel: Engine Control Module |
| 20 | 2005: Powertrain Control Module | |
| 17 | 30 | ABS |
| 18 | 30 | Wiper On/Off Relay |
| 19 | 50 | Radiator Fan (High) Relay, Radiator Fan Control (High/Low) Relay, Front Control Module |
| 20 | 20 | Starter Relay |
| 21 | 50 | ABS |
| 22 | 40 | Radiator Fan Control Relay, Air Conditioner Compressor Clutch |
| 23 | 50 | HID: High Intensity Discharge Lamp Relay (Fuse (Engine Compartment): "1", "2") |
| 24 | 60 | AWD/SRT/Diesel: Fan Radiator |
| 25 | 30 | Front Control Module |
| 26 | 20 | RLE: Transmission Control Relay |
| 20 | Diesel: Air Conditioner Compressor Clutch Relay | |
| 27 | 30 | Front Control Module |
| R1 | Horn | |
| R2 | Gasoline: Air Conditioner Compressor Clutch | |
| R3 | Radiator Fan Control (High/Low) | |
| R4 | Radiator Fan (High) | |
| R5 | Wiper On/Off | |
| R6 | RLE: Transmission Control | |
| R7 | Radiator Fan Control | |
| R8 | Wiper High/Low | |
| R9 | Starter | |
| R10 | Adjustable Pedals (except Memory) | |
| R11 | Park Lamp | |
| R12 | Front Fog Lamp | |
| R13 | Auto Shut Down | |
| R14 | High Intensity Discharge Relay | |
| R15 | - | |
Advertisements
Relay Box (Diesel)
| № | A | Protected Component |
|---|---|---|
| 1 | 50 | PTC No.1 Relay |
| 2 | 50 | PTC No.2 Relay |
| 3 | 50 | PTC No.3 Relay |
| R1 | PTC No.3 | |
| R2 | PTC No.2 | |
| R3 | PTC No.1 | |
Luggage Compartment Fuse Box Diagram
The rear power distribution center is located in the rear compartment under the spare tire access panel.
Advertisements
| № | A | Protected Component |
|---|---|---|
| 1 | 60 | Fuse (Luggage Compartment): "14", "36", "38", "44" |
| 2 | 40 | Engine Compartment Fuse Box (Fusible Link 14) |
| 3 | 20 | Police: Dome Lamp |
| 4 | 40 | Engine Compartment Fuse Box (Fusible Link 14) |
| 5 | 30 | execept SRT8: Heated Seat Module, Zener Diode, Fuse (Luggage Compartment): "30" |
| 40 | SRT8: Heated Seat Module, Zener Diode, Fuse (Luggage Compartment): "30" | |
| 6 | 20 | Fuel Pump Relay |
| 7 | 20 | SRT8: Subwoofer Amplifier |
| 15 | Police: Spot Lamp (Right) | |
| 8 | 15 | Data Link Connector, Occupant Classification System (LHD), Ignition Switch (Engine Control Module (Diesel), Powertrain Control Module, Lock Steering Column Module (RHD), Fuel Pump Relay (Gasoline), Fuse (Luggage Compartment): "27", "29", "40", Diode No.1) |
| 9 | 20 | Power Outlet - Console |
| 10 | 10 | Export: Rear Fog Lamp Relay |
| 15 | Police: Spot Lamp (Left) | |
| 14 | 10 | A/C / Heater Control, Sentry Key Remote Entry Module (LHD), Cluster, Intrusion Transceiver Module (RHD) |
| 15 | 20 | Brake Module (Trailer Tow) |
| 16 | 20 | Magnum (300C Touring): Rear Power Outlet |
| 17 | 20 | Cluster, Lock Steering Column Module (RHD), Sentry Key Remote Entry Module (RHD) |
| 18 | 20 | Cigar Lighter |
| 19 | 10 | Stop Lamp Switch, Stop Lamp Inhibit Relay (except MK25E) |
| 20 | 20 | Magnum (300C Touring): Rear Wiper Relay |
| 27 | 10 | Occupant Classification System, Occupant Restraint Controller Module |
| 28 | 10 | execept SRT8: Occupant Restraint Controller Module |
| 5 | SRT8: Occupant Restraint Controller Module | |
| 29 | 5 | Stop Lamp Switch, Cluster, Sentry Key Remote Entry Module, Mass Air Flow Sensor (Diesel), ABS, Front Control Module, Powertrain Control Module (Gasoline), Engine Control Module (Diesel) |
| 30 | 10 | Driver/Passenger Door Module, Mirror Switch, Steering Control Module, Police/Taxi Interface Module |
| 35 | 5 | Mirror Switch (except Memory), Passenger Express Window/Door Lock Switch (except Base), Backlite Antenna Amplifier, Headlamp Flasher (Police), Police Relay No.1, Police Relay No.2, Police Relay No.3, Electronic Overhead Module (Export), Rain Sensor (Export) |
| 36 | 20 | Radio, Hands-Free Module, Satellite Receiver, Monitor/DVD Media System, Traffic Information Receiver Module (Export) |
| 37 | 15 | NAG1: Transmission Control Module |
| 38 | 5 | Cargo Lamp (except Magnum), Analog Clock Module, Electronic Overhead Module, Siren (RHD) |
| 39 | 10 | Heated Mirror |
| 40 | 5 | execept SRT8: Left/Right Heated Seat Switch, A/C Heater Control, Inside Rearview Mirror |
| 10 | SRT8: Left/Right Heated Seat Switch, A/C Heater Control, Inside Rearview Mirror | |
| 5 | Police: Bank Switch | |
| 41 | 10 | A/C Heater Control, Tire Pressure Monitor, Left/Right Headlamp Level Sensor (Export), Parl Assist Module, Headlamp Leveling Module (Export), Left/Right High Intensity Discharge Lamp (Export) |
| 42 | 30 | Front Blower Motor (MTC), Front Blower Module (ATC) |
| 43 | 30 | Rear Window Defogger |
| 44 | 20 | Front Control Module, Sunroof Motor/Module, Radio Amplifier |
| CB1 | 25 | Driver Seat Switch (except Memory), Memory Seat Module, Cluster (except Power/Memory Seat) |
| CB2 | 25 | Passenger Seat Switch |
| CB3 | 25 | execept SRT8:Driver/Passenger Window/Door Lock Switch (Base), Driver/Passenger Door Module (except Base), Driver Express Window/Door Lock Switch (except Base) |
| 30 | SRT8:Driver/Passenger Window/Door Lock Switch (Base), Driver/Passenger Door Module (except Base), Driver Express Window/Door Lock Switch (except Base) | |
| D1 | NAG1: Transmission Control Relay | |
| D2 | Front Control Module | |
| D3 | Zener | |
| R1 | Run | |
| R2 | Rear Window Defogger | |
| R3 | Accessory Delay | |
| R4 | NAG1: Transmission Control | |
| R5 | Export: Rear Fog Lamp | |
| R6 | Magnum (300C Touring): Rear Wiper | |
| R7 | - | |
| R8 | Stop Lamp Inhibit (except MK25E) | |
| R9 | Fuel Pump | |
| R10 | - | |
Advertisements