Chevrolet Malibu (2004-2007) Fuse Diagram

Fuse box diagram (fuse layout), location and assignment of fuses and relays Chevrolet Malibu (LS, LT, Maxx, SS) (2004, 2005, 2006, 2007).

Chevrolet Malibu (2004-2007)

Checking and Replacing Fuses

The wiring circuits in your vehicle are protected from short circuits by fuses and fusible thermal links in the wiring itself.

Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace a bad fuse with a new one of the identical size and rating.

If you ever have a problem on the road and don’t have a spare fuse, you can borrow one that has the same amperage. Just pick a feature of your vehicle that you can get along without – like the radio or cigarette lighter – and use its fuse if it is the correct amperage. Replace it as soon as you can.

There are three fuse blocks in your vehicle: one in the center of the instrument panel, one in the engine compartment and one in the trunk. There is a fuse puller located on the instrument panel fuse block. It can be used to easily remove fuses from the fuse block.

Note

  • Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
  • Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can cause damage to the electrical system and fire.
  • Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
  • If a fuse blows again contact a qualified service center.

Instrument Panel Fuse Box

The instrument panel fuse block is located on the lower front side of the console, on the passenger side of the vehicle. To access the fuses, open the fuse panel door by pulling out.

To reinstall the door, insert the hooks at the front end first, then push the door into the console panel to secure it.

Instrument Panel Fuse Box Diagram

AProtected Component
115Body Control Module (Door Locks)
210Body Control Module (Interior Lamps)
3- -
410Adjustable Pedals Module, Adjustable Pedals Position Switch
510Adjustable Pedals Module, Adjustable Pedals Position Switch
62Outside Rearview Mirror Switch
710Heated Seat Control Module (Driver/Passenger), Heated Seat Switch (Driver/Passenger), Inside Rearview Mirror, Sunroof Control Module
820Rear Window Wiper Module
9- -
1010Windshield Wiper/Washer Switch
11- -
122Power Steering Control Module
1330Power Windows
1410Inflatable Restraint Sensing and Diagnostic Module (SDM)
152A/T Shift Lock Control Assembly, Cruise Control On/Off Switch
16- -
1710Heating Ventilation Air Conditioning (HVAC) Control Module
18- -
1920Heating Ventilation Air Conditioning (HVAC) Blower Switch
2010Inflatable Restraint Sensing and Diagnostic Module (SDM)
2110Audio System
222Ignition Switch
2310Data Link Connector (DLC), Heating Ventilation Air Conditioning (HVAC) Control Module
2410Instrument Panel Cluster, Theft Deterrent Control Module
Relay
R1Blower Motor
Relay (Non-Serviceable)
R2Power Door Lock (Lock)
R3Power Door Lock (Unlock)
R4Driver Door Lock Actuator (Unlock)
R5Interior Lamps

Back Side

Instrument Panel Fuse Box (back side)

Relay
R1Accessory (Power Window, Sunroof, Heated Seat, Windshield Wiper/Washer Switch)
R2Run (Heating Ventilation Air Conditioning (HVAC))

Advertisements


Engine Compartment Fuse Box

The engine compartment fuse block is located on the driver’s side of the vehicle, near the battery.

Engine Compartment Fuse Box Diagram

AProtected Component
110Air Conditioning Compressor Clutch Relay
2153.9L (LZ9): Engine Control Module (ECM), Throttle Actuator Control (TAC) Module
152.2 (L61): Powertrain Control Module (PCM)
315Ignition Control Module (ICM), Park/Neutral Position (PNP) Switch
4101-2 Shift Solenoid Valve, 2-3 Shift Solenoid Valve, Torque Convertor Clutch Pulse Width Modulation (TCC PWM) Solenoid Valve
510Fuel Injectors
610Evaporative Emission (EVAP) Canister Purge Solenoid Valve, Heated Oxygen (HO2S) Sensors, Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor
710Left Headlamp (Low Beam)
815Horn Relay
910Right Headlamp (Low Beam)
1015Front Fog Lamp Relay
1110Left Headlamp (High Beam)
1210Right Headlamp (High Beam)
13103.9L (LZ9): Engine Control Module (ECM)
102.2 (L61), 3.5L (LX9): Powertrain Control Module (PCM)
1425Wiper 1 Relay, Wiper 2 Relay, Windshield Wiper Motor Assembly
1510ABS (Electronic Brake Control Module (EBCM))
16103.9L (LZ9): Engine Control Module (ECM)
102.2 (L61), 3.5L (LX9): Powertrain Control Module (PCM)
1730Cooling Fan Relay №1
1830Cooling Fan Relay №2
1930Blower Motor Control Module, Blower Motor Relay, "RUN" Relay
2030Body Control Module (BCM), Fuse (Passenger Compartment): "20", "21", "22", "23", "24"
2130Fuse (Passenger Compartment): "12", "14", "15"
2260Fuse (Luggage Compartment): "10", "14", "16", "17", "20", "23"
2360Fuse (Luggage Compartment): "1", "2", "5", "6", "22", "25"
2460ABS (Electronic Brake Control Module (EBCM))
2550Body Control Module, Fuse (Passenger Compartment): "1", "2", Accessory Relay
2630Starter Relay
4180Power Steering Control Module
4210Transmission Control Module
4315Ignition Control Module (ICM)
4410Fuel Injectors
4510Intake Manifold Tuning (IMT) Valve Solenoid
46- -
47- -
50- -
51- -
52- -
54- -
55- -
56- -
57- -
Relay
28Cooling Fan (№1 (Left))
29Cooling Fan
30Cooling Fan (№2 (Right))
31Starter Motor
32Run/Crank (Ignition)
33Engine Control Module (ECM)
34Air Conditioning Compressor Clutch
35Headlamp (High Beam)
36Front Fog Lamp
37Horn
38Headlamp (Low Beam)
39Wiper (№1)
40Wiper (№2 - Windshield Wiper Motor)
48 -
49 -
53 -
Diode
27Wiper 1 Relay, Wiper 2 Relay

Advertisements


Luggage Compartment Fuse Box

The rear compartment fuse block is located in the trunk of the vehicle. Access the fuse block through the trunk panel on the driver’s side of the rear cargo area.

Luggage Compartment Fuse Box Location

Luggage Compartment Fuse Box Diagram

AProtected Component
1- -
230Driver Seat Controls
3- -
4-Resistor: Door Lock Actuator (Driver)
510Evaporative Emission (EVAP) Canister Vent Solenoid Valve
610Park Lamps Relay (Body Control Module (BCM), License Lamps, Park/Turn Signal Lamps, Tail Lamps, Tail/Stop and Turn Signal Lamps), Instrument Panel Dimming
7- -
8- -
9- -
1015Sunroof Control Module
11- -
1220Power Outlet (Rear)
13- -
1415Heated Seat Controls
15- -
167.5Digital Radio Receiver, Garage Door Opener Transmitter, Remote Control Door Lock Receiver, DVD Player
1710Back-Up Lamps Relay
18- -
19- -
2020Cigar Lighter, Auxiliary Power Outlet (Console or Front)
21- -
2210Trunk Release Relay
2330Rear Window Defogger
2410Heated Mirrors
2515Fuel Pump Relay
Relay
26Rear Window Defogger, Heated Mirrors
27Park Lamps (Back-Up Lamps, Body Control Module (BCM), Garage Door Opener Transmitter, HVAC Control Module, License Lamps, Park/Turn Signal Lamps, Tail Lamps, Tail/Stop and Turn Signal Lamps)
28 -
29 -
30 -
31 -
32 -
33Back-Up Lamps, Inside Rearview Mirror
34 -
35 -
36Trunk Release
37Fuel Pump
Diode
38Trunk Release