Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses Chevrolet Caprice (1991, 1992, 1993, 1994, 1995, 1996).
Checking and Replacing Fuses
The wiring circuits in your vehicle are protected from short circuits by a combination of fuses, circuit breakers, and fusible thermal links in the wiring itself. This greatly reduces the chance of fires caused by electrical problems.
Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace a bad fuse with a new one of the correct size.
If you ever have a problem on the road and don’t have a spare fuse, you can borrow one of the correct value. Just pick some feature of your vehicle that you can get along without – like the radio or cigarette lighter – and use its fuse if it is the size you need. Replace it as soon as you can.
Note
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can cause damage to the electrical system and fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Instrument Panel Fuse Box
The fuses are located behind the cover on the driver’s side of the dash panel.
1991-1993
| № | A | Circuit Protected |
|---|---|---|
| 1 | 15 | Underhood Light, Power Antenna, Keyless Entry, Courtesy Lights, Compass/Lighted Mirror, Horn, Lighted Visor, Door Locks, Power Mirrors, Rear Glass Release, Audible Warning System |
| 2 | 15 | Audible Warning System, Cigarette Lighter, Rear Wiper, Glove Box Light, Radio, Trunk Light, Rear Gate Ajar Light, Trunk Release |
| 3 | 10 | 1991: Anti-Lock Brake System |
| 10 | 1992-1993: Bose Amplifier | |
| 4 | 25 | 1991: Bose Radio Amplifier |
| 10 | 1992: Electronic A/C | |
| 10 | 1993 (Sedan): Electronic Level Control | |
| 25 | 1993 (Wagon): Electronic Level Control | |
| 5 | 7.5 | Instrument Panel Lights |
| 6 | 20 | Keyless Entry, Alternator, Heater, Air Conditioner, Daytime Running Lights |
| 7 | 30 | 1991: Electronic A/C Blower Motor |
| 8 | 15 | Wagon: Rear Wiper/Washer |
| 9 | 10 | Radio |
| 10 | 25 | Windshield Wiper/Washer, Washer Fluid Level |
| 11 | 7.5 | Fuel Injectors |
| 12 | 10 | Supplemental Inflatable Restraint |
| 13 | 10 | Speed Signal Module, ECM, EGR Solenoid, Air Control ESC Module, Canister Purge, Cluster Electronics/Warning Indicator |
| 14 | 15 | Twilight Sentinel, Parking, Side Marker & License Lights, Daytime Running Lights |
| 15 | 30 | Rear Window Defogger |
| 16 | 7.5 | Heated Mirrors |
| 17 | 15 | Audible Warning System, TCC Brake Switch, Compass Mirror, Supplemental Inflatable Restraint, Gauges/Warning Indicator, Headlight Switch Illumination, Rear Window Defogger, Fluid Warning, Anti-Lock Brake System, Twilight Sentinel, Daytime Running Lights, Low Oil Module, Park/Neutral Relay, Height Sensor, Power Vent Switch (1991) |
| 18 | 15 | Turn Signal Lights, Back-Up Lights Cruise Control |
| 19 | 20 | Stoplights, Hazard Lights |
| 20 | 5 | ECM, Supplemental Inflatable Restraint |
| 21 | 30 | Keyless Entry, Power Door Locks, Power Seats, Tailgate Lock Relay, Power Vent Motor (1991) |
| 22 | - | - |
| 23 | 30 | Power Windows |
| 24 | - | - |
| 25 | - | - |
Advertisements
1994-1996
| № | A | Circuit Protected |
|---|---|---|
| 1 | - | - |
| 2 | - | - |
| 3 | - | - |
| 4 | - | - |
| 5 | - | - |
| 6 | 15 | 1994: Turn Signal Lamp Flasher, Park Neutral Position Switch |
| 7 | 10 | 1994: Anti-Lock Brake (ABS) Control Module |
| 10 | 1995-1996 (Police): HUD Projector, Night Vision Control Unit, Auxiliary Display | |
| 8 | 15 | Tailgate Switch Module |
| 9 | 10 | 1994: Radio |
| 15 | 1995-1996: Radio | |
| 10 | 25 | Windshield Wiper Motor Module |
| 11 | 10 | Rear Defog Relay, Air Bag, I/P Cluster, Headlamp Switch |
| 12 | 10 | 1994 (Wagon): Auto Level Control |
| 15 | 1995-1996: Turn Signals, Back-up Lamp, PRNDL Position Sensor | |
| 13 | 10 | Automatic Inside Rearview Mirror, Chime Module, TCC Cruise Brake Switch, Twilight Sentinel, Daytime Running Lights Canada), Keyless Entry System |
| 14 | 10 | Pass-Key II |
| 15 | 15 | Air Bag |
| 16 | 10 | Cruise Control |
| 17 | 20 | Heater & A/C Control |
| 18 | 10 | 1995-1996: Seat Heater, Power Steering Control Module |
| 19 | - | - |
| 20 | 10 | Instrument Cluster, Daytime Running Lights (Canada) |
| 21 | 15 | 1995-1996 (Police): RH Spot Lamp |
| 22 | 15 | 1995-1996 (Police): LH Spot Lamp |
| 23 | - | - |
| 24 | 10 | Air Bag, Theft Deterrent Relay |
| 25 | - | - |
| 26 | 20 | 1994: Power Antenna |
| 10 | 1995-1996 (Police): Night Vision Roof Unit | |
| 27 | 10 | 1994: Heat Sensor, Trunk Lamp |
| 10 | 1995-1996: Automatic Level Control, Trunk Lamp | |
| 28 | 20 | Cigarette Lighter |
| 29 | 20 | Keyless Entry System, Trunk Release, Rear Glass Release Liftgate Wiper Latch Switch (Wagon) |
| 30 | 15 | Radio |
| 31 | 20 | Headlamp Switch, Twilight Sentinel, Daytime Running Lights (Canada) |
| 32 | 25 | Horn |
| 33 | 10 | Chime Module, Heater and A/C, Glove Box Light, Instrument Cluster |
| 34 | 10 | Pass-Key II |
| 35 | 15 | Dome Lamp, Front Reading Lights, Rear Reading Lights, Automatic Inside Rearview Mirror, Illuminated Visor Vanity Mirror, Power Door Locks, Front Door Courtesy Lights, Rear Door Courtesy Lights, Power Mirror Sw. Instrument Panel Courtesy Lights |
| 36 | 15 | Wagon: Rear Wiper |
| 37 | 20 | Hazard Warning Flasher, Stop Lights |
| 38 | 30 | 1995-1996: Blower Motor Control |
| 39 | 20 | 1995-1996: Power Door Lock Relay |
| 40 | 20 | 1995-1996: Heated Seats |
| 41 | 10 | Cornering Lamps, Side Marker Lamp, Turn-Park Lamp |
| 42 | 10 | Instrument Cluster, Radio, Brightness Control, Headlamp and Instrument Panel Lamp Dimmer Switch, Panel Lamps Dimming Module |
| 43 | 10 | License Lights, Taillights, Tail/Stop/Turn Lights, Markerlamps |
| 44 | 10 | Heater Power Mirrors |
| 45 | 10 | 1995-1996 (Police): HUD Projector |
| 46 | 20 | 1995-1996: Power Seat Recline, Lumbar Support, Power Antenna Relay |
| 47 | 30 | Power Window, Power Window Lockout Switch |
| 48 | 30 | 1994: Door Locks, Power Seat Switch, Passenger Seat Lumbar Controls |
| 25 | 1995-1996: Door Locks, Power Seat Switch | |
| 49 | 30 | Rear Window Defogger |
| 50 | - | - |
Advertisements
Engine Compartment Fuse Box (1994-1996)
| № | A | Protected Component |
|---|---|---|
| 1 | 10 | Fuel Injector (2, 3, 5, 8) |
| 2 | 10 | Fuel Injector (1, 4, 6, 7) |
| 3 | 20 | 1994: Primary Air Pump Relay, Underhood Lamp |
| 25 | 1995-1996: Primary Air Pump Relay, Underhood Lamp | |
| 4 | 10 | 1994: Secondary Engine Coolant Fan, Generator |
| 15 | 1995-1996: Automatic Transmission, Mass Air Flow Sensor (MAF), Secondary Air Pump Relay, EGR Control Valve Relay, Evaporative Emission Canister Purge Valve Solenoid, LH Heated Oxygen Sensor, RH Heated Oxygen Sensor | |
| 5 | 10 | Control Module (PCM), Ignition Coil Electronic Brake Control Module |
| 6 | 15 | Fuel Pump Relay, Fuel Pump and Engine Oil Pressure Switch Powertrain Control Module (PCM) |
| 7 | 10 | Primary Engine Coolant Fan, A/C Compressor Relay |
| 8 | 10 | Automatic Transmission, Mass Air Flow Sensor (MAF), Secondary Air Pump Relay, EGR Control Valve Relay, Evaporative Emission Canister Purge Valve Solenoid, LH Heated Oxygen Sensor, RH Heated Oxygen Sensor |
| 9 | 25 | Automatic Level Control Air Compressor (ALC) |
| 10 | 40 | Secondary Engine Coolant Fan |
| 11 | 40 | Primary Engine Coolant Fan |
| 12 | 60 | Fuse Block |
| 13 | 60 | Main |
| 80 | Main | |
| R1 | Coolant Fan | |
| R2 | Coolant Fan | |
| R3 | Air Pump | |
| R4 | A/C Compressor | |
| R5 | Fuel Pump | |
Advertisements