Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Ford Ranger (North America) (2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
The fuse panel is located under the right-hand side of the instrument panel behind the kick panel. A fuse puller tool is located near the lower right corner of the fuse box; this tool will assist you in pulling the fuses out for inspection, if necessary.
| № | A | Protected circuits |
|---|---|---|
| 1 | 5 | Instrument panel dimmer switch |
| 2 | 10 | Trailer tow park lamps |
| 3 | 10 | Right low beam headlamp |
| 4 | 10 | Left low beam headlamp |
| 5 | 30 | 2004-2007: Windshield wipers/washer |
| 5 | 2008-2012: Windshield wiper module (run/accy) | |
| 6 | 10 | Radio (RUN/ACCY), Door switch illumination (2008-2012) |
| 7 | 5 | 2004-2006: Headlamp illumination indicator |
| 8 | 10 | Restraints Control Module (RCM), PADI (Passenger Air bag Deactivation Indicator), Occupant classification sensor (OCS; 2007-2012) |
| 9 | 5 | Cluster air bag indicator |
| 10 | 10 | Cluster (RUN/START), 4x4 module (RUN/START) |
| 11 | 10 | Passenger compartment fuse panel (Logic power) |
| 12 | 15 | Center console subwoofer amplifier, Satellite radio |
| 13 | 15 | Horn, Interior lamps |
| 14 | 15 | High beam headlamp, High beam indicator (cluster) |
| 16 | 30 | Power windows |
| 17 | 15 | Turn signals/Hazards |
| 18 | — | Not used |
| 19 | 20 | Center High-Mounted Stop Lamp (CHMSL)/Stop lamps |
| 20 | 10 | Anti-lock Brake System (ABS) module, Brake-shift interlock (2004-2007), Speed control module, Back-up lamps, Overdrive cancel switch, Electronic flasher (turn/hazard) |
| 21 | 5 | Starter relay |
| 22 | 5 | Spare |
| 23 | 30 | Headlamps (low and high beam) |
| 24 | 20 | Radio |
| 26 | 2 | 2004-2006: Brake pressure switch |
| 2007-2012: Redundant cruise switch | ||
| 27 | 10 | Climate control blower relay/blend doors, 4x4 module (2004-2006) |
| 28 | 15 | 4x4 module battery feed (B+) |
| 29 | 20 | Cigar lighter or power point, Diagnostic connector (OBD II) |
| 30 | 5 | Power mirrors |
| 31 | 20 | Front park lamps, Rear park lamps, License plate lamps, Dimmer switch, Trailer tow park lamps |
| 32 | 5 | Brake switch (logic) |
| 33 | 5 | Instrument cluster battery feed (B+) |
| 34 | 20 | Power point |
| 35 | 15 | Power locks |
| 15 | 2004-2007: One-touch down relay | |
| 25 | Accessory relay | |
Advertisements
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment.
2.3L engine
3.0L and 4.0L engines
| № | A | Protected circuits |
|---|---|---|
| 1 | 50 | 2004: Passenger compartment fuse panel |
| 40 | 2005-2012: Passenger compartment fuse panel | |
| 2 | 40 | 2004-2007: Amplifier (Tremor audio system only) |
| 3 | 50 | 2004: Passenger compartment fuse panel |
| 40 | 2005-2012: Passenger compartment fuse panel | |
| 4 | — | Not Used |
| 5 | 50 | Passenger compartment fuse panel |
| 6 | — | Not Used |
| 7 | 40 | 2004-2007: Starter |
| 30 | 2008-2012: Starter | |
| 8 | — | Not Used |
| 9 | 40 | Ignition switch |
| 10 | — | Not Used |
| 11 | 30 | Powertrain Control Module (PCM), Engine sensors |
| 12 | — | Not Used |
| 13 | 30 | Blower motor (climate control) |
| 14 | — | Not Used |
| 15 | 30 | 2004: Anti-lock Brake System (ABS) (solenoids) |
| 16 | — | Not Used |
| 17 | 40 | ABS (motor) |
| 18 | — | Not Used |
| 19 | 20 | 2.3L engine: Engine fan |
| 20 | — | Not Used |
| 21 | 10 | PCM keep alive power, Canister purge valve solenoid (2007-2012) |
| 22 | — | Not Used |
| 23 | 20 | 2004-2006: Fuel pump |
| 30 | 2007-2012: Fuel pump motor, Fuel injectors | |
| 24 | — | Not Used |
| 25 | 10 | A/C clutch solenoid |
| 26 | — | Not Used |
| 27 | 20 | 4x4 module |
| 28 | — | Not Used |
| 29 | 30 | 2008-2012: Wipers/washer |
| 30 | — | Not Used |
| 31 | 15 | Fog lamps |
| 32 | 30 | 2005-2012: Anti-lock brake system (ABS) module |
| 33 | — | Not Used |
| 34 | — | Not Used |
| 35 | — | Not Used |
| 36 | — | Not Used |
| 37 | — | Not Used |
| 38 | 7.5 | Trailer tow (right turn) |
| 39 | 15 | 2007-2012: PCM power |
| 40 | — | Not Used |
| 41 | 15 | 2004-2006: Heated Exhaust Gas Oxygen (HEGO) sensors, EVAP canister vent valve, Exhaust Gas Recirculation (EGR) stepper motor, Transmission |
| 10 | 2007-2012: Automatic transmission | |
| 42 | 7.5 | Trailer tow (left turn) |
| 43 | 20 | 2007-2012: Engine fan relay coil, A/C relay coil, IAC, Mass air flow sensor, Heated exhaust gas oxygen sensor, Catalyst module sensor, Vapor management valve solenoid |
| 44 | 15 | 2007-2012: Ignition coil, Capacitor |
| 45A | 2004-2007: Wiper HI/LO relay | |
| 45B | 2004-2007: Wiper Park/Run relay | |
| 46A | 2004-2006 (2.3 L): Fuel pump relay | |
| 2007-2012 (2.3 L): Fuel pump relay, Fuel injectors relay | ||
| 3.0L and 4.0L engines: A/C clutch solenoid | ||
| 46B | 2004-2007: Washer pump relay | |
| 47 | 2.3L engine: Engine fan relay | |
| 3.0L and 4.0L engines: PCM relay | ||
| 48 | 2.3L engine: Starter relay | |
| 48A | 2004-2006 (3.0 L, 4.0 L): Fuel pump relay | |
| 2007-2012 (3.0 L, 4.0 L): Fuel pump relay, Fuel injectors relay | ||
| 48B | 3.0L and 4.0L engines: Fog lamp relay | |
| 54 | Powertrain Control Module (PCM) relay | |
| 55 | Blower relay | |
| 56 | 3.0L and 4.0L engines: Starter relay | |
| 56A | 2.3L engine: A/C clutch solenoid relay | |
| 56B | 2.3L engine: Fog lamp relay | |
Advertisements