Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Focus Mk1 (1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The fuse panel is located behind the cover on the dashboard (LHD) or behind the glove box (RHD).
| № | A | Protected components |
|---|---|---|
| 30 | 7.5 | 1998-2001: Anti-lock Brake System (ABS) |
| 10 | 2002-2004: Light switch | |
| 2005-2007: Parking lamps | ||
| 31 | 15 | 1998-2004: Radio |
| 20 | 2005-2007: Radio | |
| 32 | 10 | 1998-2001: Light switch |
| 15 | 2002-2007: Turn signal | |
| 33 | 15 | 1998-2001: Hazard |
| 20 | 2002-2005: Horn, Power seats (SVT - 2003-2004) | |
| 2006-2007: Sunroof | ||
| 34 | 20 | 1998-2001: Horn |
| 2002-2005: Sunroof | ||
| 2006-2007: Horn | ||
| 35 | 7.5 | 1998-2005: Interior lamps, Power mirrors |
| 2006-2007: A/C switch, Instrument cluster | ||
| 36 | 7.5 | 1998-2001: Central timer, Electronic modules |
| 2002-2005: A/C switch, Hazard flasher (2002-2004), Instrument cluster | ||
| 2006-2007: Interior lamps, Power mirrors | ||
| 37 | 25 | Europe: Power windows, central global closing (left-hand side) |
| 25 | USA: | |
| 1998-2003: Not used | ||
| 2004-2005: Decklid/Liftgate release | ||
| 2006-2007: Not used | ||
| 38 | 25 | Europe: Power windows, central global closing (right-hand side) |
| USA: Not used | ||
| 39 | 10 | USA: |
| 1998-2001: Reversing light | ||
| 2002-2005: Not used | ||
| 2 | 2006-2007: PCM relay coil | |
| 40 | 10 | 1998-2001: Not used |
| 2002-2005: Reversing light | ||
| 25 | 2006-2007: Rear defroster | |
| 41 | 7.5 | 1998-2001: Not used |
| 2002-2005: Radio and cluster (accessory) | ||
| 2006-2007: Not used | ||
| 42 | 15 | 1998-2001: Not used |
| 2002-2004: Stop lamps | ||
| 10 | 2005-2007: Stop lamps, Shift interlock (P/N; 2006-2007) | |
| 43 | 15 | Europe: Power windows, rear screen wiper |
| USA: | ||
| 2005-2007: Rear wiper, Sunroof (ignition) | ||
| 44 | 20 | 1998-2004: Front and rear fog lights |
| 2005-2006: Not used | ||
| 15 | 2007: Daytime running lights | |
| 45 | 7.5 | 1998-2001: Not used |
| 2002-2007: Air conditioning, recirculated air | ||
| 46 | 15 | 1998-2001: Cigar lighter |
| 7.5 | 2002-2004: Anti-lock Brake System (ABS) | |
| 2005-2007: Not used | ||
| 47 | 15 | Europe: Cigar lighter, centre power point |
| 7.5 | USA: | |
| 1998-2001: Side lights (left) | ||
| 20 | 2002-2007: Cigar lighter, rear power point (SVT - 2003-2004) | |
| 48 | 7.5 | 1998-2001: Side lights (right) |
| 10 | 2002-2007: Data link connector | |
| 49 | 25 | 1998-2005: Rear defroster |
| 7.5 | 2006-2007: Heated mirror, heated backlite indicator | |
| 50 | 7.5 | 1998-2001: Central timer, radio |
| 2002: Not used | ||
| 2003-2005: Heated mirror, heated backlite indicator | ||
| 10 | 2006-2007: Reversing light (automatic transaxle only) | |
| 51 | 7.5 | 1998-2004: Not used |
| 2005-2007: Front passenger sensing system | ||
| 52 | 15 | 1998-2002: Not used |
| 2003-2007: Heated seats | ||
| 53 | 10 | Europe: Reversing light, heated washer jets |
| 10 | USA: Reversing light (manual transaxle only), speed control (2005-2007) | |
| 54 | - | Europe: Not used |
| 15 | USA: | |
| 1998-2001: Stop lamps | ||
| 25 | 2002-2007: Rear power windows | |
| 55 | 20 | 1998-2001: Front wipers |
| 25 | 2002-2007: Front power windows | |
| 56 | 25 | 1998-2001: Front power windows |
| 20 | 2002-2007: Front wipers | |
| 57 | 25 | 1998-2001: Rear power windows |
| 7.5 | 2002-2004: Position and side lights (right) | |
| 2005: Not used | ||
| 2006-2007: Radio and cluster (accessory) | ||
| 58 | 7.5 | 1998-2001: Air conditioning, recirculated air |
| 2002-2004: Position and side lights (left) | ||
| 2005-2007: Not used | ||
| 59 | 10 | Europe: Light switch (headlamps) |
| 7.5 | USA: | |
| 1998-2001: Electronic modules, instrument cluster | ||
| 2002-2007: Light switch (headlamps) | ||
| 60 | 7.5 | Air bag module |
| 61 | 7.5 | Europe: Electronic modules, instrument cluster |
| 7.5 | USA: | |
| 1998-2001: Light switch (headlamps) | ||
| 2002-2007: PATS modules, instrument cluster | ||
| 62 | 7.5 | 1998-2001: Not used |
| 2002-2004: License plate lamp | ||
| 2005-2007: Radio (Start) | ||
| R1 | Starter | |
| R2 | Rear intermittent wiper | |
| 2006-2007: Not used | ||
| R3 | Front intermittent wiper | |
| 2006-2007: Not used | ||
| R4 | Power point | |
| R5 | Not used | |
| 2006-2007: Daytime running lamps | ||
| R6 | Europe: Not used | |
| USA: | ||
| 2004-2005: Decklid/Liftgate release | ||
| R7 | Horn | |
| 2006-2007: Not used | ||
| R8 | Battery saver relay | |
| 2006-2007: Not used | ||
| R9 | Rear defrost/Heated mirror | |
| № | A | Protected components |
|---|---|---|
| 10 | 20 | Central locking system |
Advertisements
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Protected components |
|---|---|---|
| 1 | 40 | Main power supply (to passenger compartment fuse panel) |
| 2 | 30 | USA: |
| 1999-2004: Engine cooling fan (A/C) 2nd fuse | ||
| 2005-2007: Not used | ||
| 3 | 40 | Europe: Glow plug heater 2 |
| 30 | USA: | |
| 1999-2002: Not used | ||
| 2003-2004: Cooling fan (2.0L engine only) | ||
| 2005-2007: Not used | ||
| 4 | 50 | Europe: Heated front screen |
| 30 | USA: | |
| 1999-2002: Not used | ||
| 2003-2007: Air pump motor (PZEV engine only) | ||
| 5 | 60 | Europe: Diesel glow plug |
| 30 | USA: | |
| 1999-2002: Not used | ||
| 2003-2004: Cooling fan 2 (2.0L engine only) | ||
| 2005: Not used | ||
| 2006-2007: Anti-lock Brake System (ABS) (pumps) | ||
| 6 | 30 | Europe: Engine cooling fan (air conditioning) |
| 50 | USA: Engine cooling fan (Primary fuse) | |
| 7 | 40 | Main power supply (to passenger compartment fuse panel) |
| 8 | 30 | Ignition switch, starter solenoid |
| 9 | 20 | Engine management |
| 10 | 10 | Europe: Battery voltage sensor |
| 10 | USA: | |
| 1999-2004: Battery voltage sensor, diagnostic plug (1999-2001) | ||
| 1 | Europe: | |
| 2000-2005: Battery voltage sensor | ||
| USA: | ||
| 2003-2007: Battery voltage sensor | ||
| 11 | 30 | Europe: Anti-lock Brake System (ABS) (pumps) |
| 30 | USA: | |
| 1999-2004: Anti-lock Brake System (ABS) | ||
| 2005-2007: Subwoofer | ||
| 12 | 15 | Fuel pump, diesel injection pump |
| 13 | 30 | Europe: Headlight washer system |
| 20 | USA: | |
| 1999-2005: Not used | ||
| 2006-2007: Anti-lock Brake System (ABS) (valves) | ||
| 14 | 10 | Europe: Daytime running lights (parking lights) |
| - | USA: Not used | |
| 15 | 10 | Europe: A/C clutch solenoid |
| 10 | USA: | |
| 1999-2001: Not used | ||
| 2002-2004: A/C clutch solenoid | ||
| 20 | 2005: Anti-lock Brake System (ABS) | |
| 2006-2007: Not used | ||
| 16 | 15 | Europe: Low beam (left side) |
| USA: Low beam (left side - HID headlamps) | ||
| 16 | 10 | USA: Low beam (left side - conventional headlamps) |
| 17 | 15 | Europe: Low beam (right side) |
| USA: Low beam (right side - HID headlamps) | ||
| 17 | 10 | USA: Low beam (right side - conventional headlamps) |
| 18 | 10 | Europe: Heated oxygen sensors |
| 10 | USA: | |
| 1999-2002: Heated oxygen sensors | ||
| 2003-2004: Heated oxygen sensors (2.0L engine only) | ||
| 15 | 2003-2004: Heated oxygen sensors (2.3L engine only) | |
| 2005-2007: Heated oxygen sensors | ||
| 19 | - | Europe: Not used |
| 40 | USA: | |
| 1999-2004: Not used | ||
| 2005-2007: Heater blower motor | ||
| 20 | 10 | Engine module |
| 21 | 20 | Europe: Anti-lock Brake System (ABS) (valves) |
| 20 | USA: | |
| 1999-2004: Anti-lock Brake System (ABS) | ||
| 10 | 2005-2007: A/C | |
| 22 | 20 | Europe: Daytime running lights (Xenon headlights only) |
| 20 | USA: | |
| 1999-2005: Daytime running lights | ||
| 2006-2007: Low beams | ||
| 23 | 20 | Europe: Auxiliary heater (diesel engine), power supply for battery backup sounder (ST170 only) |
| 15 | USA: | |
| 1999-2005: Not used | ||
| 2006-2007: High beams, fog lamps | ||
| 24 | 30 | Europe: Glow plug heater 1, subwoofer (ST170 only) |
| 30 | USA: | |
| 1999-2001: Not used | ||
| 2002-2004: Subwoofer | ||
| 2005: Anti-lock Brake System (ABS) (pumps) | ||
| 2006-2007: Not used | ||
| 25 | 15 | Europe: Daytime running lights (conventional headlights only) |
| 30 | USA: | |
| 1999-2001: Not used | ||
| 2002: Subwoofer | ||
| 2005-2007: Not used | ||
| 26 | 10 | Europe: Main beam left-hand side |
| 10 | USA: | |
| 1999-2003: Main beam left-hand side | ||
| 2004: Not used | ||
| 15 | 2005: Fog lamps | |
| 2006-2007: Not used | ||
| 27 | 10 | Europe: Main beam right-hand side |
| 10 | USA: | |
| 1999-2003: Main beam right-hand side | ||
| 15 | 2004-2005: Main beam | |
| 2006-2007: Not used | ||
| 28 | 10 | Europe: Heated front screen, diesel fuel fired heater, diesel engine |
| 1 | USA: | |
| 1999-2006: Not used | ||
| 2007: Anti-lock Brake System (ABS) | ||
| 29 | 30 | Europe: Engine cooling fan (air conditioning) |
| 10 | USA: | |
| 1999-2003: Not used | ||
| 2004: Engine cooling fan (2.3L engine only) | ||
| 2005-2007: Anti-lock Brake System (ABS) , speed control | ||
| 64 | 30 | Europe: Heater blower motor |
| 30 | USA: | |
| 1999-2001: Heater blower motor | ||
| 40 | 2002-2004: Heater blower motor | |
| 2005-2007: Not used | ||
| D1 | - | PCM diode |
| D2 | - | Engine cooling fan diode |
| D3 | 30 | Europe: Engine cooling fan diode |
| D3 | - | USA: |
| 1999-2002: Not used | ||
| 2003-2007: A/C clutch diode | ||
| R1 | Ignition | |
| R2 | Europe: Glow plug | |
| USA: | ||
| 1999-2002: Not used | ||
| 2003-2005: Air pump motor | ||
| 2006-2007: High beam relay, fog lamps relay | ||
| R3 | Europe: | |
| Heated front screen | ||
| Engine cooling fan | ||
| USA: | ||
| 1999-2002: Not used | ||
| 2003-2004: Engine cooling fan (2.3L engine only) | ||
| 2005-2007: Engine cooling fan (high speed) | ||
| R4 | Europe: Headlight washer system | |
| USA: | ||
| 1999-2004: Not used | ||
| 2005-2007: Engine cooling fan (low speed) | ||
| R5 | Europe: High beam | |
| USA: | ||
| 1999-2004: High beam | ||
| 2005: High beam, fog light | ||
| 2006-2007: Air conditioner | ||
| R6 | Low beam | |
| R7 | Fuel pump | |
| R8 | Main relay | |
| Injection pump power | ||
| R9 | Europe: | |
| Engine cooling fan | ||
| Glow plug heater | ||
| USA: | ||
| 1999-2002: Not used | ||
| 2003-2004: Engine cooling fan (2.0L engine only) | ||
| 2005-2007: Engine cooling fan | ||
| R10 | Europe: | |
| Glow plug 2 | ||
| Engine cooling fan 2 | ||
| USA: | ||
| 1999-2002: Not used | ||
| 2003-2004: Engine cooling fan (2.0L engine only) | ||
| 2005-2007: Engine cooling fan | ||
| R11 | Europe: Air conditioner | |
| USA: | ||
| 1999-2005: Air conditioner | ||
| 2006-2007: Not used | ||
| R12 | Europe: Daytime running lights | |
| USA: | ||
| 1999-2005: Daytime running lights | ||
| 2006-2007: Not used | ||
| R13 | Europe: | |
| Fog light | ||
| Starter | ||
| USA: | ||
| 1999-2005: Fog light | ||
| 2005-2007: Not used | ||
| R14 | Europe: Xenon headlights | |
| USA: | ||
| 1999-2000: Not used | ||
| 2001-2002: Stop lights (AdvanceTrac) | ||
| 2003-2004: Xenon headlights (SVT) | ||
| 2005-2007: Not used | ||
| R15 | Europe: Engine cooling fan (high speed) | |
| USA: | ||
| 1999-2004: Engine cooling fan (high speed) | ||
| 2005: Not used | ||
| 2006-2007: Air pump | ||
| R16 | Europe: Engine cooling fan (low speed) | |
| USA: | ||
| 1999-2004: Engine cooling fan (low speed) | ||
| 2005: Not used | ||
| 2006-2007: Not used | ||
Advertisements