Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Explorer Sport Trac (2006, 2007, 2008, 2009, 2010).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
The fuse panel is located below the instrument panel on the driver’s side. To remove a fuse use the fuse puller tool provided on the fuse panel box.
| № | A | Circuits Protected |
|---|---|---|
| 1 | 20 | Moon roof, Adjustable pedals |
| 2 | 5 | Microcontroller power |
| 3 | 20 | Radio, Navigation amplifier, GPS module |
| 4 | 10 | On-board diagnostic (OBD II) connector |
| 5 | 5 | Moon roof, Power down back window, Door lock switch illumination (2008-2010), Auto dimming rear view mirror (2010), Rearview mirror with microphone (2008-2009) |
| 6 | 20 | Door unlock/lock |
| 7 | 15 | Trailer tow stop/turn lamps |
| 8 | 15 | Ignition switch power, Passive anti-theft system (PATS), Cluster |
| 9 | 2 | 6-speed Transmission control module/Powertrain control module (Ignition RUN/START), Fuel pump relay |
| 10 | 5 | Front wiper RUN/ACC relay in power distribution box (PDB) |
| 11 | 5 | Radio start |
| 12 | 5 | Radio, Trailer tow battery charge (relay in PDB) |
| 13 | 15 | Heated mirror |
| 14 | 20 | Horn |
| 15 | 10 | Reverse lamps |
| 16 | 10 | Trailer tow reverse lamps |
| 17 | 10 | Restraints its control module, Passenger occupancy, PAD lamp (2006-2007) |
| 18 | 10 | Roll Stability Control (RSC) switch (2010), RSC (2010), 4x4 module, 4x4 switch, Heated seat switches, Reverse park aid (2010) |
| IVD switch (2006-2009), IVD, Compass (2006-2009), Electrochromatic mirror (2006-2009), RSS module (2006-2009) | ||
| 19 | — | Not used |
| 20 | 10 | Climate control system, Brake shift, DEATC (2006-2009) |
| 21 | — | Not used |
| 22 | 15 | Brake switch, Stop lamps, Turn lamps |
| 23 | 15 | Interior lamps, Puddle lamps, Cargo lamp, Battery saver, Instrument illumination |
| 24 | 10 | Instrument cluster, Theft indicator light |
| 25 | 15 | Trailer tow park lamps |
| 26 | 15 | License plate lamps, Rear park lamps, Front park lamps, Manual climate control |
| 27 | 15 | Not used |
| 28 | 10 | Climate controls |
| CB1 | 25 | Windows |
Advertisements
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment.
| № | A | Circuits Protected |
|---|---|---|
| 1 | 50 | Battery feed 2 (passenger compartment fuse panel) |
| 2 | 50 | Battery feed 3 (passenger compartment fuse panel) |
| 3 | 50 | Battery feed 1 (passenger compartment fuse panel) |
| 4 | 30 | Fuel pump, Fuel injectors |
| 5 | — | Not used |
| 6 | 40 | Anti-lock brake system (ABS) pump |
| 7 | 40 | Powertrain control module (PCM) |
| 8 | 40 | 2006-2008: Heated windshield (left) |
| 2009-2010: Not used | ||
| 9 | 40 | 2006-2008: Heated windshield (right) |
| 2009-2010: Not used | ||
| 10 | 20 | Power down back window |
| 11 | 30 | Starter |
| 12 | — | Not used |
| 13 | 30 | Trailer tow battery charge |
| 14 | 40 | Power drivers seat |
| 15 | 40 | Heated mirror |
| 16 | 40 | Blower motor |
| 17 | 30 | Trailer tow electronic brakes |
| 18 | — | Not used |
| 19 | — | Not used |
| 20 | 30 | 2006-2007: Not used |
| 2008-2010: Front wiper motor | ||
| 21 | 20 | Rear of console power point |
| 22 | 20 | Subwoofer |
| 23 | 20 | 4x4 module |
| 24 | 10 | PCM - keep alive power, Canister vent |
| 25 | 20 | Front of console power point/Cigar lighter |
| 26 | 20 | 4x4 module, All wheel drive (AWD) module (2009-2010) |
| 27 | 20 | 6-speed transmission control module (TCM) |
| 28 | 20 | Heated seats, Power mirror (2006-2007) |
| 29 | 15 | Right high/low beam headlamp |
| 30 | 20 | Cargo bed power point |
| 31 | 15 | Fog lamps |
| 32 | 5 | Power mirrors |
| 33 | 30 | ABS valves |
| 34 | 15 | Left high/low beam headlamp |
| 35 | 10 | A/C clutch |
| 36 | 20 | 2006-2007: Not used |
| 2008-2010: Console bin power point | ||
| 37 | 30 | 2006-2007: Front wiper motor |
| 2008-2010: Driver window motor | ||
| 38 | 15 | 5-speed transmission |
| 39 | 15 | PCM power |
| 40 | 15 | Fan clutch, Positive crackcase ventilation (PCV) valve, A/C clutch relay |
| 41 | 15 | Satellite radio module, SYNC®, DVD (2006-2009) |
| 42 | 15 | Speed control deactivation switch, Electronic vapor management valve, Mass air flow sensor, Heated exhaust gas oxygen (HEGO) sensor, EVR, CMS, Variable cam timing (VCT1, VCT2, CMCV on 4.6L only) |
| 43 | 15 | Coil on plug (4.6L engine), Coil tower (4.0L engine) |
| 44 | 15 | Fuel injectors |
| 45A | Not used | |
| 45B | Not used | |
| 46A | Not used | |
| 46B | Not used | |
| 49 | Fuel pump relay | |
| 50A | Fog lamps relay | |
| 50B | A/C clutch relay | |
| 54 | Trailer tow battery charge relay | |
| 55A | PCM relay | |
| 55B | Front wiper relay | |
| 56A | Climate control blower relay | |
| 56B | Starter relay | |
| 51 | Not used | |
| 52 | 2006-2008: A/C clutch diode | |
| 2009-2010: Not used | ||
| 53 | 2006-2007: Not used | |
| 2008-2010: One touch integrated start (OTIS) | ||
Advertisements