Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Chevrolet Malibu (2013, 2014, 2015).
Checking and Replacing Fuses
The wiring circuits in the vehicle are protected from short circuits by fuses. This greatly reduces the chance of damage caused by electrical problems.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure to replace a bad fuse with a new one of the identical size and rating.
Fuses of the same amperage can be temporarily borrowed from another fuse location if a fuse goes out. Replace the fuse as soon as possible.
Note
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can cause damage to the electrical system and fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
The instrument panel fuse block is in the instrument panel, on the driver side of the vehicle. To access the fuses, open the fuse panel door by pulling down at the top. Press in on the sides of the door to release it from the instrument panel. Pull the door toward you to release it from the hinge.
| № | A | Protected Component |
|---|---|---|
| 1 | 2 | Steering Wheel Controls Switch (Left/Right) |
| 2 | 15 | Body Control Module (Right Rear Turn Signal, Left Mirror Turn Signal, Left Front Turn Signal, Door Locks) |
| 3 | 15 | Body Control Module (Left Stoplamp, Left Daytime Running Light Lamp, Headlamp Control, Right Taillamp, Right Park/Sidemarker Lamps, Right MirrorTurn, Right Front Turn Signals) |
| 4 | 15 | Radio |
| 5 | 7.5 | Telematics Communication Interface Control Module (OnStar) |
| 6 | 20 | Front Accessory Power Outlet |
| 7 | 20 | Console Bin Power Outlet, Accessory Power Outlet 110V AC |
| 8 | 15 | Body Control Module (License Plate Lamp, Center High-Mounted Stoplamp, Rear Fog Lamps, Right Front Park/Sidemarker Lamps, LED Indicator Dim, Washer Pump, Right Stoplamp, Trunk Release) |
| 9 | 15 | Body Control Module (Left Low - Beam Headlamp, Daytime Running Light) |
| 10 | 30 | Body Control Module, Power Door Locks |
| 11 | 40 | Blower Control Module |
| 12 | 25 | Circuit Breaker: Passenger Seat |
| 13 | 25 | Circuit Breaker: Driver Seat, Seat Memory Control Module |
| 14 | 7.5 | Data Link Connector |
| 15 | 10 | Inflatable Restraint Sensing and Diagnostic Module |
| 16 | 5 | Rear Compartment Lid Unlatch Relay |
| 17 | 10 | Heater Ventilation Air Conditioning (HVAC) Control Module |
| 18 | 30 | Audio System |
| 19 | 10 | Radio Controls, Heater Ventilation Air Conditioning (HVAC) Controls, Info Display Module, Auxiliary Audio Input with Memory Card Receptacle (MCR) |
| 20 | 5 | Passenger Presence Module |
| 21 | 5 | Instrument Cluster |
| 22 | 2 | Ignition Switch (without BTM) |
| 23 | 15 | Body Control Module (Right Low - Beam Headlamp, Daytime Running Light) |
| 24 | 15 | Body Control Module (Ambient Light, Switch Backlighting (LED), Trunk Lamp, Shift Lock, Key Capture) |
| 25 | 25 | Accessory AC/DC Power Inverter Module (110V AC) |
| 26 | - | - |
| R1 | Rear Compartment Lid Unlatch | |
| R2 | - | |
| R3 | Power Outlets | |
Advertisements
Engine Compartment Fuse Box
The engine compartment fuse block is on the driver side of the engine compartment, near the battery.
| № | A | Protected Component |
|---|---|---|
| 1 | 15 | Transmission Control Module (TCM) |
| 2 | 10 | 2.5L LKW: Air Conditioning Compressor Clutch Relay |
| 5 | 2.4L LUK, 2.0L LTG: Engine Control Module (ECM) | |
| 3 | 10 | 2.4L LUK, 2.0L LTG: Air Conditioning Compressor Clutch Relay |
| 4 | 5 | 2.5L LKW: Engine Control Module (ECM) |
| 5 | 5 | 2.4L LUK, 2.0L LTG: Engine Control Module (ECM) |
| 6 | 25 | Windshield Wiper Relay, Windshield Wiper Speed Control Relay |
| 7 | 5 | 2.5L LKW: Engine Control Module (ECM) |
| 8 | 15 | - |
| 9 | 15 | Ignition Coils |
| 10 | 20 | Engine Control Module (ECM) |
| 11 | 10 | 2.5L LKW, 2.0L LTG: Multifunction Intake Air Sensor, Heated Oxygen Sensor |
| 12 | 40 | 2.5L LKW: Starter Relay No.2 |
| 30 | 2.4L LUK, 2.0L LTG: Starter Relay | |
| 13 | 7.5 | 2.5L LKW, 2.0L LTG: Chassis Control Module, Control Solenoid Valve Assembly, Fuel Pump Driver Control Module |
| 7.5 | 2.4L LUK: Control Solenoid Valve Assembly | |
| 14 | 10 | 2.4L LUK: Auxiliary Heater Coolant Pump |
| 15 | 10 | 2.4L LUK: Starter/Generator Coolant Pump Relay |
| 16 | 7.5 | 2.5L LKW, 2.0L LTG: Active Grille Air Shutter Actuator |
| 7.5 | 2.4L LUK: Starter/Generator Control Module, Active Grille Air Shutter Actuator | |
| 17 | 5 | Inflatable Restraint Sensing and Diagnostic Module |
| 18 | 5 | 2.5L LKW: Battery Isolator Control Module |
| 19 | - | - |
| 20 | 25 | 2.5L LKW: Transmission Fluid Pump Relay (Auxiliary) |
| 21 | 30 | Rear Power Window |
| 22 | 30 | Sunroof Motor |
| 23 | 7.5 | 2.4L LUK: Starter/Generator Control Module |
| 24 | 30 | Front Power Window |
| 25 | 30 | Keyless Entry Control Module |
| 26 | 60 | Electronic Brake Control Module (ABS - Pump) |
| 27 | 30 | - |
| 28 | 40 | Rear Window Defogger |
| 29 | 15 | Seat Lumbar Support Switch (Driver) |
| 30 | 15 | Seat Lumbar Support Switch (Passenger) |
| 31 | 15 | 2.5L LKW, 2.0L LTG: Chassis Control Module |
| 15 | 2.4L LUK: Hybrid/EV Battery Pack Cooling Fan | |
| 32 | 15 | Body Control Module (Back-Up Lamps, Interior Lamp) |
| 33 | 25 | Seat Heating Control Module, Seat Memory Control Module |
| 34 | 25 | Electronic Brake Control Module (ABS - Valve) |
| 35 | 30 | Audio Amplifier |
| 36 | - | - |
| 37 | 10 | Right Headlamp (High Beam), High Beam Solenoid Actuator (Right) |
| 38 | 10 | Left Headlamp (High Beam), High Beam Solenoid Actuator (Left) |
| 39 | - | - |
| 40 | - | - |
| 41 | - | - |
| 42 | 30 | Cooling Fan High Speed Relay |
| 43 | - | - |
| 44 | 20 | 2.5L LKW: Starter Relay No.1 |
| 30 | 2.4L LUK: Transmission Fluid Pump Relay (Auxiliary) | |
| 45 | 30 | Cooling Fan Low Speed Relay |
| 46 | 10 | Cooling Fan Low Speed Relay, Cooling Fan Speed Control Relay |
| 47 | 10 | 2.5L LKW: Heated Oxygen Sensor 1, Evaporative Emission Purge Solenoid Valve, Rocker Arm Actuator |
| 10 | 2.0L LTG: Heated Oxygen Sensor 1, Evaporative Emission Purge Solenoid Valve, Turbocharger Bypass Solenoid Valve, Turbocharger Wastegate Solenoid Valve, Engine Oil Pressure Control Solenoid Valve | |
| 10 | 2.4L LUK: Heated Oxygen Sensor 1, Heated Oxygen Sensor 2, Mass Air Flow/Intake Air Temperature Sensor, Evaporative Emission Purge Solenoid Valve | |
| 48 | 15 | Front Fog Lamps |
| 49 | 15 | Right Headlamp |
| 50 | 15 | Left Headlamp |
| 51 | 15 | Horn |
| 52 | 5 | Instrument Cluster |
| 53 | 10 | Inside Rearview Mirror, Rearview Camera |
| 54 | 5 | Heater Ventilation Air Conditioning (HVAC) Control Module, Collision Alert Indicators |
| 55 | 7.5 | Outside Rearview Mirror Switch, Window Switch (Driver), Garage Door Opener |
| 56 | 15 | Windshield Washer Pump |
| 57 | 5 | - |
| 58 | - | - |
| 59 | 50 | 2.4L LUK: Secondary Air Injection Pump Relay |
| 60 | 7.5 | Outside Rearview Mirror Glass (Driver/Passenger) |
| 61 | - | - |
| 62 | 10 | Evaporative Emission Vent Solenoid Valve |
| 63 | - | - |
| 64 | - | - |
| 65 | - | - |
| 66 | 15 | 2.4L LUK: Secondary Air Injection Solenoid Valve Relay |
| 67 | 20 | 2.5L LKW, 2.0L LTG: Fuel Pump Control Module |
| 20 | 2.4L LUK: Chassis Control Module | |
| 68 | - | - |
| 69 | 5 | Body Control Module |
| 70 | 5 | Side Object Sensor Module (Left/Right), Rear Parking Assist Control Module, Vehicle Camera Module |
| 71 | 5 | Keyless Entry Control Module |
| R1 | Air Conditioning Compressor Clutch | |
| R2 | Starter (No.1) | |
| R3 | - | |
| R4 | Front Wiper (Speed) | |
| R5 | Front Wiper (On/Off) | |
| R6 | 2.4L LUK: Auxiliary Heater Coolant Pump | |
| R7 | Engine Control Module (ECM) | |
| R8 | 2.5L LKW: Transmission Auxiliary Oil Pump | |
| R9 | Cooling Fan (No.2) | |
| R10 | Cooling Fan (No.3) | |
| R11 | 2.5L LKW: Starter (No.2) | |
| 2.4L LUK: Transmission Auxiliary Oil Pump | ||
| R12 | - | |
| R13 | Cooling Fan (No.1) | |
| R14 | Low Beam | |
| R15 | Run/Crank | |
| R16 | 2.4L LUK: Secondary Air Injection Pump | |
| R17 | Rear Window Defogger | |
| R18 | Child Security Lock Disable | |
| R19 | 2.4L LUK: Starter/Generator Coolant Pump | |
| R20 | Headlamp (High Beam) | |
| R21 | Horn | |
| R22 | Front Fog Lamp | |
| R23 | Windshield Washer Pump | |
| R24 | 2.4L LUK, 2.5 LKW: Secondary Air Injection Pump | |
| R25 | - | |
| R26 | - | |
Advertisements
Fusible Link Block
Located on the battery.
| № | A | Circuit Protected |
|---|---|---|
| 1 | 60 | Fuse Block (Instrument Panel) |
| 2 | 60 | Fuse Block (Instrument Panel) |
| 3 | 80 | Power Steering Control Module |
| 4 | 175 | Type 2: Battery (Auxiliary) |
| 5 | 250 | Type 1: Fuse Block (Underhood) |
| 200 | Type 2: Fuse Block (Underhood) | |
| 6 | 300 | Type 1: Generator, Starter Motor |
| 500 | Type 2: Generator, Starter Motor |
Advertisements