Advertisements
Fuse box diagram (fuse layout), location and assignment of fuses and relays Chevrolet Malibu (LS, LT, Maxx, SS) (2004, 2005, 2006, 2007).
Checking and Replacing Fuses
The wiring circuits in your vehicle are protected from short circuits by fuses and fusible thermal links in the wiring itself.
Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace a bad fuse with a new one of the identical size and rating.
If you ever have a problem on the road and don’t have a spare fuse, you can borrow one that has the same amperage. Just pick a feature of your vehicle that you can get along without – like the radio or cigarette lighter – and use its fuse if it is the correct amperage. Replace it as soon as you can.
There are three fuse blocks in your vehicle: one in the center of the instrument panel, one in the engine compartment and one in the trunk. There is a fuse puller located on the instrument panel fuse block. It can be used to easily remove fuses from the fuse block.
Note
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Do not repair fuses and never replace a blown fuse with one that has a higher amp rating. This can cause damage to the electrical system and fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Instrument Panel Fuse Box
The instrument panel fuse block is located on the lower front side of the console, on the passenger side of the vehicle. To access the fuses, open the fuse panel door by pulling out.
To reinstall the door, insert the hooks at the front end first, then push the door into the console panel to secure it.
| № | A | Protected Component |
|---|---|---|
| 1 | 15 | Body Control Module (Door Locks) |
| 2 | 10 | Body Control Module (Interior Lamps) |
| 3 | - | - |
| 4 | 10 | Adjustable Pedals Module, Adjustable Pedals Position Switch |
| 5 | 10 | Adjustable Pedals Module, Adjustable Pedals Position Switch |
| 6 | 2 | Outside Rearview Mirror Switch |
| 7 | 10 | Heated Seat Control Module (Driver/Passenger), Heated Seat Switch (Driver/Passenger), Inside Rearview Mirror, Sunroof Control Module |
| 8 | 20 | Rear Window Wiper Module |
| 9 | - | - |
| 10 | 10 | Windshield Wiper/Washer Switch |
| 11 | - | - |
| 12 | 2 | Power Steering Control Module |
| 13 | 30 | Power Windows |
| 14 | 10 | Inflatable Restraint Sensing and Diagnostic Module (SDM) |
| 15 | 2 | A/T Shift Lock Control Assembly, Cruise Control On/Off Switch |
| 16 | - | - |
| 17 | 10 | Heating Ventilation Air Conditioning (HVAC) Control Module |
| 18 | - | - |
| 19 | 20 | Heating Ventilation Air Conditioning (HVAC) Blower Switch |
| 20 | 10 | Inflatable Restraint Sensing and Diagnostic Module (SDM) |
| 21 | 10 | Audio System |
| 22 | 2 | Ignition Switch |
| 23 | 10 | Data Link Connector (DLC), Heating Ventilation Air Conditioning (HVAC) Control Module |
| 24 | 10 | Instrument Panel Cluster, Theft Deterrent Control Module |
| R1 | Blower Motor | |
| R2 | Power Door Lock (Lock) | |
| R3 | Power Door Lock (Unlock) | |
| R4 | Driver Door Lock Actuator (Unlock) | |
| R5 | Interior Lamps | |
Back Side
| № | Relay |
|---|---|
| R1 | Accessory (Power Window, Sunroof, Heated Seat, Windshield Wiper/Washer Switch) |
| R2 | Run (Heating Ventilation Air Conditioning (HVAC)) |
Advertisements
Engine Compartment Fuse Box
The engine compartment fuse block is located on the driver’s side of the vehicle, near the battery.
| № | A | Protected Component |
|---|---|---|
| 1 | 10 | Air Conditioning Compressor Clutch Relay |
| 2 | 15 | 3.9L (LZ9): Engine Control Module (ECM), Throttle Actuator Control (TAC) Module |
| 15 | 2.2 (L61): Powertrain Control Module (PCM) | |
| 3 | 15 | Ignition Control Module (ICM), Park/Neutral Position (PNP) Switch |
| 4 | 10 | 1-2 Shift Solenoid Valve, 2-3 Shift Solenoid Valve, Torque Convertor Clutch Pulse Width Modulation (TCC PWM) Solenoid Valve |
| 5 | 10 | Fuel Injectors |
| 6 | 10 | Evaporative Emission (EVAP) Canister Purge Solenoid Valve, Heated Oxygen (HO2S) Sensors, Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor |
| 7 | 10 | Left Headlamp (Low Beam) |
| 8 | 15 | Horn Relay |
| 9 | 10 | Right Headlamp (Low Beam) |
| 10 | 15 | Front Fog Lamp Relay |
| 11 | 10 | Left Headlamp (High Beam) |
| 12 | 10 | Right Headlamp (High Beam) |
| 13 | 10 | 3.9L (LZ9): Engine Control Module (ECM) |
| 10 | 2.2 (L61), 3.5L (LX9): Powertrain Control Module (PCM) | |
| 14 | 25 | Wiper 1 Relay, Wiper 2 Relay, Windshield Wiper Motor Assembly |
| 15 | 10 | ABS (Electronic Brake Control Module (EBCM)) |
| 16 | 10 | 3.9L (LZ9): Engine Control Module (ECM) |
| 10 | 2.2 (L61), 3.5L (LX9): Powertrain Control Module (PCM) | |
| 17 | 30 | Cooling Fan Relay №1 |
| 18 | 30 | Cooling Fan Relay №2 |
| 19 | 30 | Blower Motor Control Module, Blower Motor Relay, "RUN" Relay |
| 20 | 30 | Body Control Module (BCM), Fuse (Passenger Compartment): "20", "21", "22", "23", "24" |
| 21 | 30 | Fuse (Passenger Compartment): "12", "14", "15" |
| 22 | 60 | Fuse (Luggage Compartment): "10", "14", "16", "17", "20", "23" |
| 23 | 60 | Fuse (Luggage Compartment): "1", "2", "5", "6", "22", "25" |
| 24 | 60 | ABS (Electronic Brake Control Module (EBCM)) |
| 25 | 50 | Body Control Module, Fuse (Passenger Compartment): "1", "2", Accessory Relay |
| 26 | 30 | Starter Relay |
| 41 | 80 | Power Steering Control Module |
| 42 | 10 | Transmission Control Module |
| 43 | 15 | Ignition Control Module (ICM) |
| 44 | 10 | Fuel Injectors |
| 45 | 10 | Intake Manifold Tuning (IMT) Valve Solenoid |
| 46 | - | - |
| 47 | - | - |
| 50 | - | - |
| 51 | - | - |
| 52 | - | - |
| 54 | - | - |
| 55 | - | - |
| 56 | - | - |
| 57 | - | - |
| 28 | Cooling Fan (№1 (Left)) | |
| 29 | Cooling Fan | |
| 30 | Cooling Fan (№2 (Right)) | |
| 31 | Starter Motor | |
| 32 | Run/Crank (Ignition) | |
| 33 | Engine Control Module (ECM) | |
| 34 | Air Conditioning Compressor Clutch | |
| 35 | Headlamp (High Beam) | |
| 36 | Front Fog Lamp | |
| 37 | Horn | |
| 38 | Headlamp (Low Beam) | |
| 39 | Wiper (№1) | |
| 40 | Wiper (№2 - Windshield Wiper Motor) | |
| 48 | - | |
| 49 | - | |
| 53 | - | |
| 27 | Wiper 1 Relay, Wiper 2 Relay | |
Advertisements
Luggage Compartment Fuse Box
The rear compartment fuse block is located in the trunk of the vehicle. Access the fuse block through the trunk panel on the driver’s side of the rear cargo area.
| № | A | Protected Component |
|---|---|---|
| 1 | - | - |
| 2 | 30 | Driver Seat Controls |
| 3 | - | - |
| 4 | - | Resistor: Door Lock Actuator (Driver) |
| 5 | 10 | Evaporative Emission (EVAP) Canister Vent Solenoid Valve |
| 6 | 10 | Park Lamps Relay (Body Control Module (BCM), License Lamps, Park/Turn Signal Lamps, Tail Lamps, Tail/Stop and Turn Signal Lamps), Instrument Panel Dimming |
| 7 | - | - |
| 8 | - | - |
| 9 | - | - |
| 10 | 15 | Sunroof Control Module |
| 11 | - | - |
| 12 | 20 | Power Outlet (Rear) |
| 13 | - | - |
| 14 | 15 | Heated Seat Controls |
| 15 | - | - |
| 16 | 7.5 | Digital Radio Receiver, Garage Door Opener Transmitter, Remote Control Door Lock Receiver, DVD Player |
| 17 | 10 | Back-Up Lamps Relay |
| 18 | - | - |
| 19 | - | - |
| 20 | 20 | Cigar Lighter, Auxiliary Power Outlet (Console or Front) |
| 21 | - | - |
| 22 | 10 | Trunk Release Relay |
| 23 | 30 | Rear Window Defogger |
| 24 | 10 | Heated Mirrors |
| 25 | 15 | Fuel Pump Relay |
| 26 | Rear Window Defogger, Heated Mirrors | |
| 27 | Park Lamps (Back-Up Lamps, Body Control Module (BCM), Garage Door Opener Transmitter, HVAC Control Module, License Lamps, Park/Turn Signal Lamps, Tail Lamps, Tail/Stop and Turn Signal Lamps) | |
| 28 | - | |
| 29 | - | |
| 30 | - | |
| 31 | - | |
| 32 | - | |
| 33 | Back-Up Lamps, Inside Rearview Mirror | |
| 34 | - | |
| 35 | - | |
| 36 | Trunk Release | |
| 37 | Fuel Pump | |
| 38 | Trunk Release | |
Advertisements