Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses Volvo C30, S40, V50, C70 (2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013).
- Volvo C30 / C70 (2006-2013)
- Volvo S40 / V50 (2004-2012)
Checking and Replacing Fuses
All electrical functions and components are fused to protect the car’s electrical system from damage by short circuiting and overloading.
If an electrical component or function does not work, it may be because the component’s fuse was temporarily overloaded and blew.
- Look in the fuse diagram to locate the fuse.
- Pull out the fuse and check from the side to see whether the curved wire has blown.
- If this is the case, replace it with a new fuse of the same colour and amperage.
Note
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box Diagram
The fuse box in the passenger compartment is located under the glove compartment.
To access the fuses:
- Remove the interior trim concealing the fuse box by pressing in the pin in the centre of the clips (1) about one cm and then withdrawing the clips.
- Turn the two wing screws (that secure the fuse box) (2) anticlockwise and remove them.
- Lower the fuse box (3) half way. Pull it towards the seat until it stops. Lower it completely. The fuse box can be fully unhooked.
| № | A | Protected Component |
|---|---|---|
| 37 | - | - |
| 38 | - | - |
| 39 | - | - |
| 40 | - | - |
| 41 | - | - |
| 42 | - | - |
| 43 | 15 | Integrated Audio Module (IAM - 2006-2013), RTI Display, Phone Module (PHM), Multimedia Module (MMM), Accessory USB Unit (AUU (2008-2013)), Cellular Phone Handsfree Control Module (2008), USB-Port (2008-2013), Bluetooth Phone Module (BPM (2009-2013)) |
| 44 | 10 | Supplemental Restraint System Module (SRS), Engine Control Module (ECM (5-Cyl. - 2008-2013)) |
| 45 | 15 | Front 12V Outlet, Rear 12V Outlet |
| 46 | 5 | Lights Switch Unit, Driver Information Module (DIM), Front Left/Right Lamp Housing (2006-2013), Front Lamp Housing, Glove Compartment Lighting, Left/Right Courtesy Lighting, Alcolock (2008-2013) |
| 47 | 5 | Ceiling Light, Rear Reading Light, Right Vanity Mirror Lighting, Left Vanity Mirror Lighting (except C70), Remote Control Unit For Garage Door Opener (2009-2013) |
| 48 | 15 | Rear Window Wiper Relay, Windshield Washer Motor Relay, Rear Window Washer Motor Relay, Washer Pump, Rear Window Wiper Motor |
| 49 | 10 | Supplemental Restraint System Module (SRS), Occupant Weight Sensor (OWS (USA/CDN)) |
| 50 | - | - |
| 51 | 10 | 2004-2005: Front Left/Right Beam Length Adjustment Lamp Housing, Left Gas Discharge Lamp Master Control Module, Right Gas Discharge Lamp Slave Control Module, PTC Element (Diesel) |
| 10 | 2006-2007: Fuel Filter Preheater Relay, Parking Assistance Module (PAM), Left Gas Discharge Lamp (GDL) Module (Master), Right Gas Discharge Lamp (GDL) Module (Slave), PTC-Element, Front Left/Right Lamp Housing (Beam Length Adjustment) | |
| 10 | 2008-2013: Fuel Filter Preheater Relay, Differential Electronic Module (DEM), PTC-Element | |
| 52 | 5 | Brake Control Module (BCM), Transmission Control Module (TCM - 2006-2013) |
| 53 | 10 | Electrical Power Steering Module (EPS) |
| 54 | 10 | 2004-2005: Transmission Control Module (TCM), Generator |
| 10 | Diesel (2006-2007): Transmission Control Module (TCM) | |
| 10 | 5-Cyl. Petrol (2006-2007): Engine Control Module (ECM) | |
| 10 | 2008-2013: Engine Control Module (ECM (5-Cyl.)), Parking Assistance Module (PAM), Left Gas Discharge Lamp (GDL) Module (Master), Right Gas Discharge Lamp (GDL) Module (Slave), Headlamp Control Module (HCM), Front Left/Right Lamp Housing | |
| 55 | 20 | 2005-2013: Keyless Vehicle Module (KVM) |
| 56 | 10 | Siren Control Module (SCM), Remote Keyless Entry (RKE (2008-2013)), Remote Receiver Module (RRX (2008-2013)) |
| 57 | 15 | 2004-2005: Engine Control Module (ECM), Central Electronic Module (CEM), Data Link Connector |
| 15 | 2006-2013: Contact Brake Light, Data Link Connector | |
| 58 | 7.5 | 2004 (L.E.): Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp Slave Control Module, Right High Beam |
| 10 | 2004 (E.E.): Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp Slave Control Module, Right High Beam | |
| 7.5 | 2005: Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp Slave Control Module, Right High Beam | |
| 7.5 | 2006-2013: Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp (GDL) Module (Slave), Front Right Lamp Housing | |
| 59 | 7.5 | 2004 (L.E.): Left Gas Discharge Lamp (GDL) Module (Master), Front Left Lamp Housing |
| 10 | 2004 (E.E.): Left Gas Discharge Lamp (GDL) Module (Master), Front Left Lamp Housing | |
| 7.5 | 2005: Auxiliary Light (Accessory) Relay, Right Gas Discharge Lamp (GDL) Module (Slave), Front Right Lamp Housing | |
| 7.5 | 2006-2013: Left Gas Discharge Lamp (GDL) Module (Master), Front Left Lamp Housing | |
| 60 | 15 | Seat Heating Module (SHM) - Driver’s Side |
| 61 | 15 | Seat Heating Module (SHM) - Passenger Side |
| 62 | 20 | Sunroof Control Module |
| 63 | 20 | S40, V50: Right Rear Door Module (RDM) |
| 64 | 5 | Traffic Message Channel Module (TMC (2004-2007)), Global Positioning System Module (GPS (2004-2007)), Remote Digital Audio Receiver (RDAR - 2006-2013), AM/FM Tuner Module (AFM - 2004-2006) |
| 5 | C70: Left/Right Door Lock Indicator, Remote Digital Audio Receiver (RDAR), Traffic Message Channel Module (TMC (2006-2007)), Global Positioning System Module (GPS (2006-2007)) | |
| 65 | 5 | Remote Control IR Sensor, RTI Display, Audio Module (AUD), Left Amplifier Window Antenna (C30), Subwoofer Control Module Relay (2008-2011), Cellular Phone Handsfree Control Module (2004, 2008), Right Rear Fender AM/FM Antenna and Amplifier (C70), Media Player Module (MPM - 2004-2005), Multimedia Module (MMM - 2004) |
| 66 | 10 | Climate Control Module (CCM), Integrated Audio Module (IAM - 2006-2013), Infotainment Control Module (ICM) |
| 67 | 15 | 2004: Subwoofer Module (SUB) |
| 68 | 5 | Steering Wheel Module (SWM) |
| 69 | 5 | Damper Motor Module (DMM) (Recirculation, Left-Hand Side, Right-Hand Side, Defroster, Floor/Ventilation), Rain Sensor Module (RSM), Air Quality Sensor (AQS), Climate Control Module (CCM (2008-2013)), Switch BLIS/PAS/DRIVe (2008-2013), Center Rear Belt Buckle Contact, Sunroof Control Module (2004-2005), Auto-Dimming Rearview Mirror (2004-2005), Ceiling Light (2004-2005) |
| 70 | - | - |
| 71 | - | - |
| 72 | - | - |
| 73 | 5 | Ceiling Light Switch Unit, Rear Left/Right Belt Buckle Contact, Sunroof Control Module, Auto-Dimming Rearview Mirror, Ceiling Light |
| 74 | 15 | Fuel Pump, Fuel Pump Control Module (Petrol), Additive Dosing Module (ADM (2009-2012)) |
| 75 | - | - |
| 76 | - | - |
| 77 | 15 | Accessory Electronic Module (AEM), Cargo Compartment 12V Outlet, Tow Hitch Cable Harness - 13-pin Outlet |
| 78 | - | - |
| 79 | 5 | Left/Right Reversing Light, Auto-Dimming Rearview Mirror |
| 80 | - | - |
| 81 | 20 | S40, V50: Rear Left Door Module (LDM) |
| 82 | 25 | Passenger Door Module (PDM) |
| 83 | 25 | Driver Door Module (DDM) |
| 84 | 25 | Power Seat Module (PSM), Power Passenger Seat Switch Unit |
| 85 | 25 | Power Seat Module (PSM), Power Driver’s Seat Switch Unit |
| 86 | 5 | Fuel Tank - DC/AC Converter (2006-2013), Power Seat Module (PSM), Cargo Compartment Lighting, Power Driver’s Seat Switch Unit, Power Passenger Seat Switch Unit, Load Assistance Switch (2008-2013), Left Vanity Mirror Lighting (C70) |
| 87 | - | - |
| 88 | - | - |
| 89 | - | - |
| 90 | - | - |
| 91 | - | - |
| 92 | - | - |
| R15 | Fuel Pump | |
| R18 | Comfort | |
| R1 | Interior Lighting | |
| R2 | Reversing Light | |
| R7A | Windshield Washer Motor | |
| R7B | Rear Window Washer Motor | |
| R8 | High Beam | |
| R11A | Rear Window Wiper | |
| R11B | Infotainment | |
Additional Fuse Holder
| № | A | Protected Component |
|---|---|---|
| 1 | 5 | Alcolock |
| 2 | 5 | Alcolock |
Advertisements
Engine Compartment Fuse Box Diagram
| № | A | Protected Component |
|---|---|---|
| 1 | 50 | Cooling Fan Control Modul |
| 2 | 80 | Electrical Power Steering Module (EPS) |
| 3 | 60 | Сomfort Relay (R18), Central Electronic Module (CEM), Fuse №: 45, 48, 49, 60, 61, 62, 63, 68, 69, 80 (2008-2013), 84, 85 |
| 4 | 60 | High Beam Relay, Reverse Interlock Solenoid (Manual Transmission - 2004), Central Electronic Module (CEM), Fuse №: 55, 58, 59, 74, 77 |
| 5 | 80 | PTC Element |
| 6 | 60 | Diesel (2004-2005): Glow Plug Control Module |
| 60 | Diesel 4-Cyl.: Glow Plug | |
| 70 | Diesel 5-Cyl.: Glow Plug Control Module | |
| 7 | 30 | 2006-2012: Brake Control Module (BCM) (Pump) |
| 40 | 2013: Brake Control Module (BCM) (Pump) | |
| 8 | 20 | Brake Control Module (BCM) (Valves) |
| 9 | 30 | Main Relay (Engine Management System), Fuse №: 32, 33, 34, 35, 36 |
| 10 | 40 | Fan Control Module |
| 11 | 20 | C30, S40, V50: Headlight Washer Motor Relay, High Pressure Headlight Washer Pump |
| 20 | С70: Convertible Roof Module (CRM), Headlight Washer Motor Relay, High Pressure Headlight Washer Pump | |
| 12 | 30 | Heated Rear Window Relay, Heated Rear Window |
| 13 | 30 | Starter Motor |
| 14 | 40 | Trailer Module (TRM), 13-pin Outlet (Tow Hitch Cable Harnes) |
| 15 | 30 | С70: Convertible Roof Module (CRM) |
| 16 | 30 | C30, S40, V50: Infotainment Relay, Audio Module (AUD), Fuse №: 22, 43, 64, 65, 66, 67 |
| 40 | С70: Infotainment Relay, Audio Module (AUD), Fuse №: 22, 43, 64, 65, 66, 67 | |
| 17 | 30 | Wiper Motor Module (WMM) |
| 18 | 40 | Reversing Light Relay, Interior Lighting Relay, Central Electronic Module (CEM), Fuse №: 46, 47, 56, 57, 79, 81, 82, 83, 86 |
| 19 | - | - |
| 20 | 15 | Horn Relay, Horn 1 & 2 |
| 21 | 20 | Combustion Preheater Module (CPM) |
| 22 | 15 | 2005: Subwoofer Module (SUB) |
| 25 | 2006-2011: Subwoofer Module (SUB) | |
| 20 | 2011-2013: Subwoofer Module (SUB) | |
| 25 | С70: Subwoofer Module (SUB) | |
| 23 | 10 | Transmission Control Module (TCM), Engine Control Module (ECM (5-Cyl.)) |
| 15 | 6-speed PowerShift - MPS6 (2009-2013): Transmission Control Module (TCM) | |
| 24 | 20 | Diesel: PTC-Resistor - Crankcase Ventilation (5-Cyl. - 2006-2013), Electrically Heated Fuel Filter |
| 25 | 10 | 2010-: Secondary Battery (1.6l Diesel), Central Electronic Module (CEM (1.6l Diesel)) |
| 26 | 15 | Starter Motor Relay, Start Control Module (SCU), Engine Control Module (2004-2005), Central Electronic Module (CEM), Fuse №: 44, 51, 52, 53, 54, 73 and Fuse in Holder |
| 27 | 10 | Electromagnetic Clutch (Climate Control System) |
| 28 | 10 | 2005: Climate Control Module (CCM), Multimedia Module (MMM) |
| 29 | 15 | Front Fog Lights Relay, Front Left/Right Fog Light |
| 30 | 3 | Diesel 4-Cyl.: Engine control module (ECM (2.0l Diesel, 1.6l Petrol)) |
| 10 | 2010-2013: Coolant Pump (1.6l Diesel) | |
| 31 | 10 | 2004-2005 (Diesel): Alternator (Voltage Regulator) |
| 10 | 2006-2013 (4-Cyl.): Alternator (Voltage Regulator) | |
| 32 | 10 | Petrol (2004): Injectors |
| 10 | 2005: Fuel Filter Pre-Heater Relay, Front Heated Oxygen Sensor, Injectors (Petrol), Valve Coolant | |
| 10 | 2006-2013: Mass Airflow Sensor (MAF) (5-Cyl. Diesel), Regulator Motor (Turbo), Front Heated Oxygen Sensor (4-Cyl.), Rear Heated Oxygen Sensor (4-Cyl.), Injection Valves (5-Cyl.), Coolant Valve (4-Cyl. 2.0L Diesel), Rear Heated Oxygen Sensor (4-Cyl. 1.6L Diesel (2007)), Glow Plug System Relay (2008-2013), Intercooler Bypass Valve (1.6l Diesel), Fuel Flow Control Valve (2011) | |
| 33 | 20 | 2004: Fuel Filter Pre-Heater Relay (Diesel), Vacuum Pump, Front/Rear Heated Oxygen Sensor |
| 20 | 2005: Vacuum Pump, Front/Rear/Middle Heated Oxygen Sensor | |
| 20 | 2006-2013: Vacuum Pump Switch, Engine Control Module (ECM (5-Cyl. Diesel)), Vacuum Pump (5-Cyl.), Front Heated Oxygen Sensor (5-Cyl.), Rear Heated Oxygen Sensor (5-Cyl.), Center Heated Oxygen Sensor (5-Cyl. without Turbo), PTC-Resistor - Crankcase Ventilation (4-Cyl. 2.0L), Heated Fuel Filter (Diesel), Vacuum Pump Relay (2010-2013) | |
| 34 | 10 | 2004: Engine Control Module (ECM), Fuel Volume Control Valve (Diesel), Fuel Pressure Control Valve (Diesel), Spark Plug and Ignition Coil |
| 10 | 2005: Engine Control Module (ECM - 5-Cyl.), Injection Valves, Injector, Fuel Volume Control Valve (Diesel), Spark Plug and Ignition Coil, Transformer - Ignition Coils, PTC Resistor - Oil Trap | |
| 10 | 2006-2013: EGR Valve, Fuel Pressure Control Valve (2006-2007), Spark Plug and Ignition Coil, EGR Cooling Bypass Valve (2006-2008), Fuel Pressure Bypass Valve (Man), Injection Valves (1.6l), Fuel Volume Control Valve (4-Cyl. 2.0l Diesel), Fuel Flow Control Valve (4-Cyl. 1.6l Diesel), Pressure Monitor (Climate Control System (5-Cyl.)), Ignition Coils (Transformer (1.6l)), Glow Plug Control Module (GCU (5-Cyl. Diesel - 2008-)), EGR Valve (5-Cyl. Diesel - 2008-2013), Starter Motor Relay (1.6l Diesel - 2010-2013), Battery Relay (1.6l Diesel - 2010-2013), Secondary Battery Relay (1.6l Diesel - 2010-2013), Coolant Pump Relay (1.6l Diesel - 2010-2013), Engine Control Module (1.6l Diesel - 2010-2013), Front Heated Oxygen Sensor (4-Cyl. - 2011-2013) | |
| 35 | 10 | 2004 (E.E.): Climate Control System Relay, Fuel Leakage Control Pump, Mass Airflow Sensor (MAF), EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Variable Valve Timing Outlet Solenoid, Bypass Valve (Diesel), Variable Turbo Geometry Solenoid (Diesel), Expansion Tank Cut-off Valve (Diesel), Intake Control Valve (Diesel), PTC Resistor - Oil Trap |
| 15 | 2004 (L.E.): Climate Control System Relay, Fuel Leakage Control Pump, Mass Airflow Sensor (MAF), EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Variable Valve Timing Outlet Solenoid, Bypass Valve (Diesel), Variable Turbo Geometry Solenoid (Diesel), Expansion Tank Cut-off Valve (Diesel), Intake Control Valve (Diesel), PTC Resistor - Oil Trap | |
| 15 | 2005: Climate Control System Relay, Fuel Leakage Control Pump, Engine EGR, Mass Airflow Sensor (MAF), Water Detection Sensor, Injection Valves, EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Power Steering Pressure Switch, Variable Valve Timing Outlet Solenoid, Bypass Valve (Diesel), Variable Turbo Geometry Solenoid (Diesel), Intake Valve Mixing Air/Fuel Control Valve (Diesel), PTC-Resistor Air Preheating | |
| 15 | 2006-2007: Climate Control System Relay, Fuel Leakage Control Pump, Engine EGR (1.6l Diesel - 2006-2011), Mass Airflow Sensor (MAF), Water Detection Sensor, Injection Valves, EVAP Valve, Intake Variable Valve Timing Solenoid, Turbocharger Control Valve, Power Steering Pressure Monitor, Variable Valve Timing Outlet Solenoid, Control Valve Inlet, Variable Turbo Geometry Solenoid (4-Cyl. Diesel), Valve Mixing Air/Fuel (5-Cyl. 1.8l & 2.0l), Engine Control Module (5-Cyl. Diesel), Crankcase Ventilation PTC-Resistor (5-Cyl. Petrol) | |
| 15 | 2008-2013: Climate Control System Relay, Engine Control Module (5-Cyl. Diesel), Fuel Leakage Control Pump (5-Cyl.), EGR Motor (1.6l Diesel, 1.8l Petrol), Mass Air Flow Sensor (MAF (5-Cyl. Petrol, 4-Cyl. Diesel)), Water Detection Sensor (4-Cyl. Diesel), Injection Valves (1.8l), EVAP Valve (Petrol), Intake Variable Valve Timing Solenoid (5-Cyl. Petrol), Turbocharger Control Valve (2.5l Turbo), Variable Intake Manifold Vacuum Valve (1.8l), Power Steering Pressure Switch (1.6l), Fuel Volume Control Valve (2.0l Diesel - 2008-2010), Exhaust Variable Valve Timing Solenoid (2.5l Turbo), Variable Turbo Geometry Solenoid (4-Cyl. Diesel), Air/Fuel Mixing Valve (1.8l), Intake Control Valve (2.0l Diesel), PTC-resistor - Crankcase Ventilation (5-Cyl. Petrol), EGR Cooling Bypass Valve (2011-2013) | |
| 36 | 10 | Engine Control Module (ECM), Front Heated Oxygen Sensor (5-Cyl. Diesel - 2006-2013), Accelerator Pedal Sensor |
| 20 | Fuse in Holder: Front Left/Right Auxiliary Lights | |
| R1 | 2010-2013: Coolant Pump | |
| R2 | Horn | |
| R3 | 2010-2013: Vacuum Pump | |
| R4 | Front Fog Light | |
| R5 | Fuel Filter Preheate | |
| R6 | 2010-2013: Autostart | |
| R7 | 2010-2013: Secondary Battery | |
| R8 | - | |
| R9 | Headlight Washer Motor | |
| R10 | Heated Rear Window | |
| R11 | Climate Control System | |
| R12 | Diesel (2008-2013): Glow Plug System | |
| R13 | Starter Motor | |
| R14 | Main (Engine Management System) | |
Advertisements