Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Volkswagen Transporter (T4) (1990, 1991, 1992, 1993, 1994, 1995).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Switch off the headlights, the ignition, and all electrical consumers.
- Open the appropriate fuse box.
- See diagrams below for details about which fuse to check.
- Remove the fuse using the plastic tweezers located on the fuse box cover.
- Check if the fuse is blown – if the thin metal strip inside is broken, the fuse has blown.
- If the fuse is blown, replace the fuse with a new fuse of the same amperage (same color and same imprint) and the same overall size.
- Replace the cover.
Notice
- Never replace a fuse with one that has a higher amp rating. Replace a blown fuse only with a fuse of the same amperage (same color and same imprint) and the same overall size.
- Never repair fuses.
- Never replace fuses with a metal strip, a paper clip, or a similar object.
- If a newly replaced fuse blows again after a short time, the electrical system should be checked by an authorized Volkswagen dealer or an authorized Volkswagen Service Facility.
Passenger Compartment Fuse Box
The fuses are located to the right side of the steering wheel behind the storage compartment.
Advertisements
| № | A | Description |
|---|---|---|
| 1 | 10 | Left Headlight Low Beam |
| 2 | 10 | Right Headlight Low Beam |
| 3 | 10 | Instrument & License Lights |
| 4 | 15 | Rear Window Wiper/Washer, Heated Front Seats |
| 5 | 15 | Windshield Wiper/Washer, Rear Window Washer, Heated Washer Jets |
| 6 | 30 | A/C, Fresh Air Fan |
| 7 | 10 | Right Tail Light & Side Marker Light, Engine Compartment Lamp |
| 8 | 10 | Left Taillight & Side Marker Light |
| 9 | 20 | Rear Window & Mirror Heater |
| 10 | 15 | Fog Lamps |
| 11 | 10 | Left Headlight High Beam & High Beam Indicator |
| 12 | 10 | Right Headlight High Beam |
| 13 | 10 | Horn, Radiator Cooling Fan |
| 14 | 10 | Backup Lights, Electric Mirrors, Heated Front Seats, Windshield Washer Jets, Cruise Control, Power Roof |
| 15 | 10 | Engine Electronics |
| 16 | 15 | Warning/Indicator Lights, Multi-Function Indicator, Glove Box Light, ABS |
| 17 | 10 | Turn Signals |
| 18 | 20 | Fuel Pump |
| 19 | 30 | A/C, Radiator Cooling Fan |
| 20 | 10 | Brake Lights |
| 21 | 15 | Dome & Luggage Lamps, Clock, Radio, Central Locking System, Multi-Function Indicator, Vanity Mirror, OBD Diagnostic |
| 22 | 10 | Cigarette Lighter |
| 1 | A/C Control Module Relay | |
| 2 | Rear Window Wiper/Washer Relay | |
| 3 | ECM Power Supply Relay | |
| 4 | Load Reduction Relay | |
| 5 | Open | |
| 6 | Emergency Flasher Relay | |
| 7 | Headlight Washer Relay | |
| 8 | Washer/Wiper Intermittent Relay | |
| 9 | Seat Belt Warning Relay | |
| 10 | Fog Lamp/Parking Lamp Relay | |
| 11 | Dual Horn Relay | |
| 12 | Fuel Pump Relay | |
| 13 | Heater Control Module Relay | |
| 14 | Coolant Pump After-Run Relay | |
| 15 | Open | |
| 16 | Open | |
| 17 | Open | |
| 18 | Roof Ventilator Fan (Fuse) | |
| 19 | Heater Air Blower Relay | |
| 20 | Starter Interlock/Back-up Light Relay | |
| 21 | 5 | Back-up Lights, Cruise Control |
| 22 | 20 | A/C (Second Evaporator) |
| 23 | Rear Window Defroster/Heated Mirror Relay | |
| 24 | 20 | Power Windows, Central Locking System |
| 25 | 10 | ABS System |
| 26 | 15 | Rear Window Defroster, Heated Mirrors |
| 27 | A/C Compressor Clutch Relay | |
Additional fuses
| 1 | 50 | Radiator Fan |
| 1 | 50 | Glow Plugs (1995 Diesel Models Only) |
| 1 | 25 | Auxiliary HVAC Fan |
| 2 | 20 | Blower for Auxiliary Heater |
| 3 | 30 | Refrigerator Socket, Socket below Folding Table (MV Models) |
| 4 | 5 | Fluorescent Light (MV Models) |
Advertisements