Advertisements
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Volkswagen Golf III / Vento (1991, 1992, 1993, 1994, 1995, 1996, 1997).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Switch off the headlights, the ignition, and all electrical consumers.
- Open the appropriate fuse box.
- See diagrams below for details about which fuse to check.
- Remove the fuse using the plastic tweezers located on the fuse box cover.
- Check if the fuse is blown – if the thin metal strip inside is broken, the fuse has blown.
- If the fuse is blown, replace the fuse with a new fuse of the same amperage (same color and same imprint) and the same overall size.
- Replace the cover.
Notice
- Never replace a fuse with one that has a higher amp rating. Replace a blown fuse only with a fuse of the same amperage (same color and same imprint) and the same overall size.
- Never repair fuses.
- Never replace fuses with a metal strip, a paper clip, or a similar object.
- If a newly replaced fuse blows again after a short time, the electrical system should be checked by an authorized Volkswagen dealer or an authorized Volkswagen Service Facility.
Passenger Compartment Fuse Box
The fuse panel is located behind the cover underneath the driver’s side of the dashboard.
Advertisements
| № | A | Circuits protected |
|---|---|---|
| 1 | 10 | Headlight, low beam, left |
| 2 | 10 | Headlight, low beam, right |
| 3 | 10 | Instrument and number plate lighting |
| 4 | 15 | Rear window wiper and washer system, sliding/tilting roof |
| 5 | 15 | Windscreen wiper, windscreen and rear window washer, electric heated windscreen washer jets |
| 6 | 20 | Fresh air blower, A/C |
| 6 | 30 | Blower, air conditioner |
| 7 | 10 | Tail lights, right |
| 8 | 10 | Tail lights, left |
| 9 | 15 | Rear window defogger |
| 9 | 20 | Rear window heating, mirror heating |
| 10 | 15 | Fog lights, rear fog light |
| 11 | 10 | Headlight, high beam, left. main beam warning lamp |
| 12 | 10 | Headlight, high beam, right |
| 13 | 10 | Horn, radiator fan (run-on) |
| 14 | 10 | Back-up fights |
| 14 | 15 | Reversing lights, electric outside mirrors, seat heating, elec. windows, air conditioner cruise control system |
| 15 | 10 | Engine electronics, coolant circulation run-on pump, (six cylinder engine) |
| 16 | 15 | Warning lamps, glove box light, cassette storage box light, power sunroof, front map/reading light |
| 17 | 10 | Emergency flashers |
| 18 | 20 | Fuel pump (FP), heated oxygen sensor (H02S) control module |
| 19 | 30 | Coolant fan, A/С relay |
| 20 | 10 | Brake lights, cruise control system (trigger contacts on brake and clutch pedals) |
| 21 | 15 | Interior and luggage compartment lights, clock, cigarette lighter, central locking, multi-function indicator |
| 22 | 10 | Cigarette fighter, radio, luggage compartment |
| R1 | Air conditioner relay | |
| R2 | Rear window wiper / washer relay | |
| R3 | Engine electronics relay | |
| R4 | Ignition Relay | |
| R5 | - | |
| R6 | Turn signal relay | |
| R7 | Headlight washer relay | |
| R8 | Windshield Wiper / Washer Relay | |
| R9 | Safety Belt Indicator Relay | |
| R10 | Fog lamp relay | |
| R11 | Horn relay | |
| R12 | Fuel pump relay | |
| R13 | Intake manifold heater relay | |
| R14 | - | |
| R15 | ABS pump relay | |
| R16 | Reverse Light Relay (Ecomatic) | |
| R17 | Headlamp high beam relay (Ecomatic) | |
| R18 | Headlamp low beam relay (Ecomatic) | |
| R19 | Fuse (30A - air conditioning, Climatronic 2.0 / 2.8 (1993) | |
| R20 | Start inhibit switch relay | |
| R21 | Oxygen sensor relay | |
| R22 | Seat Belt Indicator Relay | |
| R23 | Vacuum pump relay (Ecomatic) | |
| R24 | Thermal Fuse (20A) - Power Windows | |
Additional fuses
In separate holders, above the relays
| № | A | Circuits protected |
|---|---|---|
| 1 | 30 | Fuse for ABS motor relay |
| 2 | 30 | Fuse for ABS main relay |
| 3 | 10 | Fuse for normal air conditioner |
| 4 | 30 | Fuse for fresh air blower on Climatronic |
| 5 | 5 | Fuse for Climatronic |
| 6 | 20 | Automatic fuse for electric windows |
| 7 | 15 | Trailer permanent + |
In the engine compartment on the bulkhead above the brake servo
| № | A | Circuits protected |
|---|---|---|
| 1 | 50 | Diesel glow plugs |
Advertisements